Ford Explorer IV (2005-2010) front auxiliary climate control assembly assembly Wiring diagram

1 3 2 SIG RTN ACPT VREF 10 9 8 7 6 5 4 3 2 1 B+ GROUND 18 41 14 16 ACPT SIGRTNC ACCR 57 20 24 7 18 58 VREF VBPWR FSS FC V ECT SIGRTNE 6 5 4 3 2 1 HIGH SPEED MEDIUM HIGH A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH RELAY FUSE A/C CLUTCH SOLENOID A/C PRESSURE TRANSDUCER (LEFT FRONT OF ENGINE COMPT) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RELAY AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (ON AUXILIARY BLOWER MOTOR) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK/GRN WIRE BLK/GRY WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRY WIRE BLU/RED WIRE BREAKOUT TO LEFT REAR QUARTERPANEL) BRN/GRN WIRE ELECTRONIC FAN CLUTCH (CENTER FRONT OF ENGINE) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (4.0L) EXPLORER, MOUNTAINEER FRONT AUXILIARY CLIMATE CONTROL ASSEMBLY ASSEMBLY FUSE FUSE 18 GND VPWR VBPWR FSS FC V GRN/BLU WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT W/ PCM RELAY ENERGIZED HOT W/ RUN/START RELAY ENERGIZED ILLUM MEDIUM LOW LOW GROUND MODE OUT CEILING TEMP MODE OUT FLOOR OF VEHICLE) POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE) REAR BLEND DOOR ACTUATOR (BEHIND LEFT REAR QUARTERPANEL) REAR MODE DOOR ACTUATOR (BEHIND LEFT REAR QUARTERPANEL) SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) THERMAL LUMBER VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/RED WIRE YEL/VIO WIRE