Ford Explorer IV (2005-2010) brn/yel Wiring diagrams

1 2 3 4 5 6 7 8 9 10 CLUTCH COIL AMBER IND AT FENDER APRON) AUTO BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BI-DIR MOTOR BLK/BLU WIRE BLK/VIO WIRE BLK/WHT WIRE BLU/BLK WIRE BLU/BRN WIRE BLU/GRN WIRE BRAKE SHIFT INTERLOCK (UNDER CENTER FLOOR CONSOLE) BRN/GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CLUTCH COMPUTER DATA LINES SYSTEM DIGITAL TRANSMISSION RANGE (DTR) SENSOR (4.0L) (LOWER LEFT FOUR WHEEL DRIVE SWITCH FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 18 FUSE 23 FUSE 26 GND 1 MTR CW MTR CCW GND 2 GRN WIRE GRN/ORG WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED ILLUM LSD NEU TOW IND MODE SEL SW RTN NEUTRAL TOW INDICATOR ORG/ WIRE POS RTN RED WIRE RUN/START HS CAN- HS CAN+ MODE SEL SW DOOR AJAR TRANS NEU SIDE OF AUTOMATIC TRANSMISSION) SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TRANSFER CASE ASSEMBLY (LEFT REAR OF TRANSFER CASE) VIO WIRE VIO/GRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/RED WIRE

1 2 B + R/ACC AUDIO CONTROL MODULE (ACM) AUDIO JACK AUDIO SHLD BLK/BLU WIRE BLU WIRE BLU/GRN WIRE BLU/RED WIRE BRN WIRE BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM FUSE 11 FUSE 12 FUSE 3 GRN/WHT WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START L FRONT SPKR + L REAR SPKR + R REAR SPKR + R FRONT SPKR + R FRONT SPKR - GND L FRONT SPKR - L REAR SPKR - R REAR SPKR - 22 23 LEFT FRONT SPEAKER LEFT REAR SPEAKER NCA WIRE R + L + L - R - MS CAN + MS CAN - RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SMART JUNCTION BOX (SJB) TWISTED PAIR WIRES VIO/ORG WIRE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/GRN WIRE

2 1 VBATT PWR GND ADJUSTABLE PEDAL CIRCUIT BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/ORG WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/RED WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DN UP DRIVER SEAT LUMBAR COMPRESSOR MOTOR (IN DRIVER'S SEAT BACK) DRIVER SEAT MODULE (IN DRIVER'S SEAT) DRIVER SEAT RECLINER MOTOR (RIGHT SIDE OF DRIVER'S SEAT BACK) ENTIRE SEAT EXPLORER, MOUNTAINEER FRONT OF SEAT FRONT UP/DOWN FRT TILT DN SW HORZ BASE FORE SW REAR TILT DN SW FRT TILT HALL EFECT SN REAR TILT MTR UP FRT TILT MTR UP FRT TILT UP SW HORZ BASE AFT SW REAR TILT UP SW FUSE 1 FUSE 14 FWD RWD FWD/RWD GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/ORG WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/YEL WIRE HORIZONTAL HORZ BASE AFT RECLINE MTR UP HORZ BASE FORE HOT AT ALL TIMES IN OUT LEFT POWER SEAT MOTOR ASSEMBLY (UNDER DRIVER'S SEAT) LEFT POWER SEAT SWITCH LUMBAR OF SEAT MEM IND LED MEMORY SET SWITCH MS CAN - MS CAN + ORG/ WIRE PEDAL HALL EFF FEED PEDAL HALL EFF SNS RET PEDAL MTR AFT PEDAL MTR FORE REAR OF SEAT REAR UP/DOWN RECLINE DN SW RECLINE HALL EFFECT SN RECLINE OF SEAT RED WIRE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/ORG WIRE

ACC/DELAY RELAY BLK WIRE BLU/GRY WIRE BLU/ORG WIRE BRN WIRE BRN/GRN WIRE BRN/YEL WIRE CIRCUIT BREAKER 1 CONTROL DRIVER SIDE FRONT POWER WINDOW MOTOR (IN CENTER OF LEFT FRONT DOOR) ELECT FRONT GRN/ORG WIRE GRN/VIO WIRE GRY WIRE GRY/VIO WIRE LEFT REAR LEFT REAR POWER WINDOW MOTOR (IN CENTER OF LEFT REAR DOOR) LEFT REAR WINDOW ADJUST SWITCH LOCKOUT MASTER WINDOW ADJUST SWITCH ONE SHOT PASSENGER SIDE FRONT POWER WINDOW MOTOR (IN CENTER OF RIGHT FRONT DOOR) PASSENGER SIDE WINDOW ADJUST SWITCH RED WIRE RIGHT RIGHT REAR RIGHT REAR POWER WINDOW MOTOR (IN CENTER OF RIGHT REAR DOOR) RIGHT REAR WINDOW ADJUST SWITCH SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) VIO WIRE VIO/BLK WIRE VIO/WHT WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 SW+ SW- SHIELD ENABLE/CLIP DETECT 4 5 9 MIC + MIC - SHIELD ANTENNA AUDIO CONTROL MODULE (ACM) AUDIO JACK (W/ AUDIOPHILE) (IN CENTER CONSOLE) AUTO-DIMMING INTERIOR MIRROR UNIT (W/ MICROPHONE) B+ RUN/ACC 2 3 BLK/BLU WIRE BLU WIRE BLU/GRN WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/BLU WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DETECT FUSE 11 FUSE 12 FUSE 3 GRN WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START L FRONT SPKR + L REAR SPKR + R REAR SPKR + R FRONT SPKR + R FRONT SPKR - GND L FRONT SPKR - L REAR SPKR - R REAR SPKR - 22 23 LEFT LEFT IN + LEFT IN - SHIELD NCA WIRE RIGHT RIGHT START IN - MS CAN + MS CAN - SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SW+ VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE VOICE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/GRN WIRE

ANT AUDIO CONTROL SWITCH BATT DRAIN L- OUT R- OUT BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE CLOCKSPRING (AT TOP OF STEERING COLUMN) COMPUTER DATA LINES SYSTEM FUSE 22 FUSE 41 GRN WIRE GRN/ORG WIRE GRN/YEL WIRE GRY WIRE GRY/ORG WIRE HOT AT ALL TIMES L+ OUT R+ OUT MS CAN- LEFT FRONT SPEAKER LEFT REAR SPEAKER MEDIA MS CAN + NCA WIRE ORG/GRN WIRE RED WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE (BEHIND RIGHT KICK PANEL) SATELLITE RADIO ANTENNA SEEK SHIELD TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VOICE VOL (-) WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE

11 12 MIC + MIC - 12 11 21 8 R FRONT SPKR - R FRONT SPKR + L FRONT SPKR - L FRONT SPKR + 22 9 23 10 L REAR SPKR - L REAR SPKR + R REAR SPKR - R REAR SPKR + 3 4 2 1 SHIELD DETECT SW + SW - 4 5 MONO + MONO - 9 10 1 2 STEREO R + STEREO R - STEREO L + STEREO L - AUDIO CONTROL MODULE (ACM) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE DETECT FUSE 22 GRN WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT FRONT SPEAKER LEFT REAR SPEAKER NCA WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SW+ TWISTED PAIR WIRES VIO WIRE VIO/GRN WIRE VIO/RED WIRE WHT WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 GND 27 28 29 30 31 32 LR SPKR + LR SPKR - LR SPKR - LR SPKR + AUDIO CONTROL SWITCH BATTERY JUNCTION BOX (BJB) BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CLOCKSPRING COMPUTER DATA LINES SYSTEM FUSE 41 GRN WIRE GRN/ORG WIRE GRY WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT REAR SPEAKER MEDIA NCA WIRE ORG/ WIRE OUT L + OUT R + PHONE R+ OUT R- OUT REAR ENTERTAINMENT MODULE (RETM) RED WIRE RED/WHT WIRE RIGHT REAR SPEAKER SATELLITE DIGITAL AUDIO RECEIVER SYSTEM (SDARS) MODULE SEEK SHIELD STEREO R - STEREO R + TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VOICE VOL (-) W/ SATELLITE RECEIVER W/O SATELLITE RECEIVER WHT/BRN WIRE WHT/GRN WIRE YEL WIRE YEL/BLU WIRE YEL/ORG WIRE YEL/VIO WIRE

BATTERY JUNCTION BOX (BJB) BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE DETECT FUSE 22 GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT REAR SPEAKER NCA WIRE RED WIRE RIGHT REAR SPEAKER SUBWOOFER AMPLIFIER (W/ AUDIOPHILE) SW+ TWISTED PAIR WIRES VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE WHT/BRN WIRE WHT/GRN WIRE YEL WIRE YEL/BLU WIRE

4 5 9 MIC + MIC - ACCESSORY PROTOCOL INTERFACE MODULE (APIM) AUDIO CONTROL MODULE (ACM) AUDIO JACK AUTO-DIMMING INTERIOR MIRROR UNIT (W/ MICROPHONE) BLK WIRE BLK/BLU WIRE BLU WIRE BLU/BRN WIRE BLU/GRN WIRE BLU/WHT WIRE BRN/BLU WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DETECT GRN WIRE GRN/ORG WIRE GRN/WHT WIRE GRY WIRE GRY/BRN WIRE GRY/ORG WIRE GRY/YEL WIRE HS CAN + HS CAN - L REAR SPKR - LR SPKR MIC + MIC - MIC - MONO + MONO - MIC + MIC - MONO - MS CAN - MS CAN + NCA WIRE R REAR SPKR - RED WIRE RR SPRK - SHIELD SHIELD SHIELD STEREO 2 L + STEREO 2 L - STEREO 2 R + STEREO 2 R - SHIELD STEREO L+ STEREO R+ SW+ USB USB PORT VBATT VIO WIRE VIO/BRN WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/RED WIRE WHT WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRN WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/VIO WIRE