Ford Explorer IV (2005-2010) autolamp/ sunload sensor (behind glove box) Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 MS CAN- PWR GND RUN/START 3 2 1 4 5 6 VAC 2 VAC 1 GND VAC 3 VAC 4 VAC 5 4 3 2 1 5 MTR SINK HBR SW IN VAR SPD IN FB OUT GROUND ANTI-THEFT AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLOWER CTRL VAC 5 HCWV BLOWER MOTOR RELAY 1 BLU WIRE BLU/BRN WIRE BLU/ORG WIRE BLU/WHT WIRE BREAKOUT TO ENGINE COMPT BULKHEAD) BRN WIRE BRN/GRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATC HVAC MODULE (BEHIND LOWER CENTER OF DASH) DIMMING IN DRIVER TEMPERATURE BLEND DOOR ACTUATOR (REAR LEFT SIDE OF HVAC UNIT) EXPLORER, MOUNTAINEER FRONT BLOWER MOTOR (RIGHT SIDE OF HVAC UNIT) FRONT BLOWER MOTOR SPEED CONTROLLER (CENTER OF HVAC UNIT) FUSE 16 FUSE 24 FUSE 28 GRN WIRE GRN/BLU WIRE GRN/BRN WIRE GRN/RED WIRE GRN/VIO WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/VIO WIRE HAT HOT AT ALL TIMES IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT CENTER OF DASH) INSTRUMENT CLUSTER LEFT BD FEEDBACK RIGHT BD FEEDBACK MS CAN+ PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (FRONT LEFT SIDE OF HVAC UNIT) RED WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SENSE A/D VBC FB SN GND IN CAR TEMP VBC OUT RIGHT SUNLOAD AMB TEMP LEFT SUNLOAD VIO WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/ORG WIRE VIO/RED WIRE WHT/BRN WIRE WHT/VIO WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/ORG WIRE YEL/VIO WIRE

1 LO AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/BLU WIRE BLK/GRY WIRE BLK/VIO WIRE BLU WIRE BLU/BRN WIRE BRN WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM EXPLORER, MOUNTAINEER FOG LAMP IND FOG LAMP RELAY FTP FTP/HIGH FULL LEFT FUSE 29 FUSE 31 FUSE 34 GRN WIRE GRN/BRN WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE GRY/YEL WIRE HOT AT ALL TIMES HSD INSTRUMENT CLUSTER (IC) INTERIOR (BASE OF RIGHT "B" PILLAR) LIGHTS SYSTEM LAMPS FOG LANE CHANGE FULL RIGHT LANE CHANGE NEUTRAL LEFT FRONT FOG LAMP (LATE PRODUCTION) LEFT HEADLAMP HI MAIN LIGHT SWITCH MS CAN + MULTI- FUNCTION SWITCH OFF OFF PARK LOW AUTO ORG/ WIRE PARK BRAKE SWITCH RED WIRE RIGHT FRONT FOG LAMP (LATE PRODUCTION) RIGHT HEADLAMP HI SENSE SENSE A/D SENSE SENSE SENSE SENSE SENSE MED CAN SENSE SENSE SENSE SENSE SIG PWM SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) SOLID STATE CONTROL SPORT TRAC VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) YEL WIRE

15 16 MS CAN + MS CAN - 4 5 MS CAN + MS CAN - ADJUSTABLE PEDAL SWITCH AUDIO CONTROL MODULE AUDIO/ CLIMATE CONTROL SWITCH AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/VIO WIRE BLK/WHT WIRE BLU WIRE BLU/BRN WIRE BRAKE SHIFT INTERLOCK (UNDER CENTER FLOOR CONSOLE) BRN WIRE BRN/WHT WIRE CLIMATE CONTROL ASSEMBLY CLOCKSPRING (AT TOP OF STEERING COLUMN) COMPUTER DATA LINES SYSTEM CTRL SOLID STATE DEFEAT DIMMING DK DIM DOME DRIVER SIDE DOOR LOCK SWITCH FOG 6 10 FOG IND 5 9 4 AUTO OFF PARK FOUR WHEEL DRIVE SWITCH FUSE 23 FUSE 5 GND P GRN WIRE GRN/BLU WIRE GRY WIRE GRY/BLU WIRE GRY/ORG WIRE HEATED SEAT/ WINDSHIELD SWITCH HOT AT ALL TIMES HOT W/ ACC/DELAY RELAY ENERGIZED HVAC MODULE (DATC) (BEHIND LOWER CENTER OF DASH) ILLUMINATION DIMMER SWITCH INS ILL POT- INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION LOW 3 2 MAIN LIGHT SWITCH MS CAN + OFF ORG/ WIRE PARK BRAKE SWITCH (BEHIND TOP OF LEFT KICK PANEL) PASSENGER SIDE DOOR LOCK SWITCH REAR WINDOW ADJUST SWITCH ROOF OPENING PANEL SWITCH SENSE SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) STEERING WHEEL/ SPEED CONTROL SWITCH TRACTION CONTROL SWITCH MESSAGE CENTER SWITCH DIMMER UNDEFEATED VIO WIRE VIO/GRN WIRE VIO/ORG WIRE WHT WIRE WHT/BRN WIRE WHT/VIO WIRE YEL WIRE

ANTI-THEFT AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BLK WIRE BLU WIRE COMPUTER DATA LINES SYSTEM EPATS GND EPATS RX EPATS TX FUSE 24 HOT AT ALL TIMES HS CAN+ IGNITION SWITCH INSTRUMENT CLUSTER (IC) OFF ORG/ WIRE PASSIVE ANTI-THEFT TRANSCEIVER (ON STEERING COLUMN) RED WIRE RF GND RF PWR RUN WIRE RUN/ST RX SIG SMART JUNCTION BOX (SJB) (BEHIND LEFT SIDE OF DASH) TX SIG VIO WIRE VIO/GRY WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE YEL WIRE YEL/BLU WIRE YEL/ORG WIRE