Automatic a/c circuit for Ford Explorer III (2001-2006)

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 CAN BUS- GROUND VPWR 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SIGNAL RTN 1 2 3 4 5 6 GROUND A/C CLUTCH RELAY A/C INDICATOR DIODE AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CAN-BUS COMPUTER DATA LINES SYSTEM CTRL VALVE DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FEEDBACK VOLTAGE SIG RTN VREF FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 20 FUSE 30 FUSE 36 FUSE 37 GROUND GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED SIGNAL HOT AT ALL TIMES HOT IN RUN OR START HOT IN START OR RUN ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR INSTRUMENT CLUSTER J/C 1 J/C 2 LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MICROPRO- CESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) PNK/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE PWR RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SEATS SYSTEM TAN/YEL WIRE TWISTED PAIR VAR SPEED SIGNAL RIGHT VREF LEFT VPWR VREF VBATT VEHICLE SECURITY MODULE (VSM) (ABOVE RIGHT REAR WHEELWELL) VIO/YEL WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/BLK WIRE

0) OFF 1) LOW 2) MED LOW 3) MED HIGH 4) HIGH 5) CEILING 6) FLOOR 0) OFF 1) REAR 2) LOW 3) MED LOW 4) MED HIGH 5) CEILING 6) FLOOR A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AUDIO/ CLIMATE CONTROL SWITCH AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COOL CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE FAN UP TEMP UP FAN DN FUSE 25 FUSE 33 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR MODE DOOR ACTUATOR (BEHIND REAR SEATS) RED WIRE RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMP DN TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WARM WHT WIRE YEL WIRE YEL/BLK WIRE