Ford Explorer III (2001-2006) twisted pair Wiring diagrams

1) BREAK PEDAL FORCE SWITCH 2) ACTIVE BOOSTER SOLENOID ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ABS IND. ABS TEST CONNECTOR (AT LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE BOOSTER SENSOR (ON FRONT OF BRAKE BOOSTER) BRAKE FLUID LEVEL SWITCH (MOUNTED ON SIDE OF MASTER CYLINDER) BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN/WHT WIRE CAN (+) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ELECTRONIC THROTTLE CONTROL INDICATOR FUSE 10 FUSE 21 FUSE 22 FUSE 25 FUSE 26 FUSE 5 GRN WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN ILLUM IND INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (AT LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (AT LEFT REAR WHEEL) LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE LT LT ORG/ WIRE ORG/RED WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWETRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) PRIMARY BRAKE PRESSURE SENSOR (ON MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) RIGHT FRONT WHEEL SPEED SENSOR (AT RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (AT RIGHT REAR WHEEL) SECONDARY BRAKE PRESSURE SENSOR (ON BRAKE BOOSTER) STEERING POSITION SENSOR (AT TOP OF STEERING COLUMN) TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/YEL WIRE TCS DISABLE TRACTION CONTROL SWITCH TWISTED PAIR VBATT VIO/WHT WIRE VPWR WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE YAW VELOCITY SENSOR (BELOW CENTER CONSOLE) YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ABS IND. ABS TEST CONNECTOR (AT LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE FLUID LEVEL SWITCH (MOUNTED ON SIDE OF MASTER CYLINDER) BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CAN (+) CAN BUS- GND CAN-BUS CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM ELECTRONIC THROTTLE CONTROL INDICATOR FUSE 10 FUSE 22 FUSE 21 FUSE 25 FUSE 45 FUSE 5 GRN WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (AT LEFT FRONT WHEEL) LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE LT LT NEAR BREAKOUT TO A/C CLUTCH CYCLING PRESSURE SWITCH) ORG/ WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE REAR AXLE SPEED SENSOR (ON REAR DIFFERENTIAL) RED WIRE RED/YEL WIRE RIGHT FRONT WHEEL SPEED SENSOR (AT RIGHT FRONT WHEEL) TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/YEL WIRE TWISTED PAIR VBATT VIO/WHT WIRE VPWR VPWR VPWR WHT WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 CAN BUS- GROUND VPWR 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SIGNAL RTN 1 2 3 4 5 6 GROUND A/C CLUTCH RELAY A/C INDICATOR DIODE AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CAN-BUS COMPUTER DATA LINES SYSTEM CTRL VALVE DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FEEDBACK VOLTAGE SIG RTN VREF FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 20 FUSE 30 FUSE 36 FUSE 37 GROUND GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED SIGNAL HOT AT ALL TIMES HOT IN RUN OR START HOT IN START OR RUN ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR INSTRUMENT CLUSTER J/C 1 J/C 2 LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MICROPRO- CESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) PNK/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE PWR RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SEATS SYSTEM TAN/YEL WIRE TWISTED PAIR VAR SPEED SIGNAL RIGHT VREF LEFT VPWR VREF VBATT VEHICLE SECURITY MODULE (VSM) (ABOVE RIGHT REAR WHEELWELL) VIO/YEL WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/BLK WIRE

17 16 SCP- SCP+ ABS CONTROL MODULE (ON LEFT SIDE OF OF ENGINE COMPARTMENT) ABS TEST CONNECTOR (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) FEPS FOUR-WHEEL DRIVE CONTROL MODULE (AT RIGHT FUSE 17 HOT AT ALL TIMES INSTRUMENT CLUSTER ISO KICK PANEL) LT BLU WIRE LT BLU/WHT WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RESTRAINTS CONTROL MODULE (BEHIND LOWER CENTER OF DASH) SCP+ TAN/ORG WIRE TWISTED PAIR VIO WIRE W/ KEYLESS ENTRY W/O KEYLESS ENTRY WHT WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM AUDIO/ CLIMATE CONTROL SWITCH BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CAN-BUS COMPUTER DATA LINES SYSTEM DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (AT TOP OF ENGINE) ENGINE CONTROLS SYSTEM ETC MOTOR, +/- FUSE GRY/RED WIRE GRY/WHT WIRE HORN SWITCH HOT AT ALL TIMES INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN BATTERY JUNCTION BOX (BJB)) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR ORG/ WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) RES ON SENSOR (A/T: LEFT REAR OF AUTOMATIC TRANSMISSION) SET- SIG SIG RTN SPEED CONTROL INDICATOR SPEED CONTROL SWITCH TAN WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF THROTTLE BODY) TWISTED PAIR VREF WHT WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM AUDIO/ CLIMATE CONTROL SWITCH BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CAN-BUS COMPUTER DATA LINES SYSTEM DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (AT TOP OF ENGINE) ENGINE CONTROLS SYSTEM ETC MOTOR, +/- FUSE GRY/RED WIRE GRY/WHT WIRE HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN BATTERY JUNCTION BOX (BJB)) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR ORG/ WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE RES ON SENSOR (A/T: LEFT REAR OF AUTOMATIC TRANSMISSION) SET- SIG SIG RTN SPEED CONTROL INDICATOR SPEED CONTROL SWITCH TAN WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF THROTTLE BODY) TWISTED PAIR VREF WHT WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 HIGH AUDIO + HIGH AUDIO - SHIELD MUTE ANTENNA BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN/ORG WIRE DK GRN/VIO WIRE FUSE 13 FUSE 28 FUSE 29 FUSE 39 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT W/ WINDOW SAFETY RELAY ENERGIZED L FRONT SPKR (-) L REAR SPKR (-) R REAR SPKR (-) LEFT FRONT SPEAKER RIGHT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/VIO WIRE MUTE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE POWER WINDOWS SYSTEM RADIO RED WIRE RED/BLK WIRE RIGHT REAR SPEAKER SUBWOOFER SUBWOOFER AMPLIFIER (NEAR RIGHT SIDE OF REAR WINDOW) TAN/YEL WIRE TWISTED PAIR VBATT VIO WIRE VIO/LT BLU WIRE VPWR WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION AIR BAG CONTACT AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM ANTENNA AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CIRCUIT BREAKER PTC 1 CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/ORG WIRE FAN DOWN FAN UP FUSE 28 FUSE 3 GRN WIRE GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START HOT WITH ACC DELAY RELAY ENERGIZED LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/WHT WIRE MEDIA NCA WIRE NEXT ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER TAN/YEL WIRE TEMP DOWN TEMP UP TWISTED PAIR VEHICLE SPEED VOL DOWN VOL UP VSS WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) VSS YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 DVD LEFT + DVD LEFT - 1 2 3 4 5 6 7 8 9 10 ENABLE GND 1 2 3 4 5 6 7 8 SUBWOOFER HIGH + SUBWOOFER HIGH - SHIELD ENABLE AIR BAG CONTACT AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM ANTENNA ASYSON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B DVD RIGHT + DVD RIGHT - AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CIRCUIT BREAKER PTC 1 CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM INTERIOR LIGHTS SYSTEM DK GRN WIRE DK GRN/ORG WIRE DVD PLAYER FAN DOWN TEMP UP FAN UP FUSE 28 FUSE 3 GRN WIRE GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START HOT W/ ACC DELAY RELAY ENERGIZED ILLUM L FRONT SPKR (-) L REAR SPKR (-) R REAR SPKR (-) LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE MEDIA NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) PROTOCOL A PROTOCOL B RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SHIELD SPKR LF+ SPKR RT+ SUBWOOFER SUBWOOFER AMPLIFIER (AT RIGHT REAR QUARTERPANEL) TAN WIRE TAN/ORG WIRE TAN/YEL WIRE TEMP DOWN TWISTED PAIR VBATT SUBWOOFER HIGH + SUBWOOFER HIGH - VOL DOWN NEXT VOL UP VSS WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) VSS YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION AIR BAG CONTACT AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM ANTENNA ASYSON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM INTERIOR LIGHTS SYSTEM DK GRN WIRE DK GRN/ORG WIRE DVD PLAYER DVD RIGHT + DVD RIGHT - DVD LEFT + DVD LEFT - FAN DOWN TEMP UP FAN UP TEMP DOWN FUSE 28 FUSE 3 GRN WIRE GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START HOT WITH ACC DELAY RELAY ENERGIZED ILLUM LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE MEDIUM NEXT VOL DOWN VOL UP NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) PROTOCOL A PROTOCOL B PTC 1 RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SHIELD SPKR LF+ SPKR RT+ TAN WIRE TAN/ORG WIRE TAN/YEL WIRE TWISTED PAIR VEHICLE SPEED WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) VSS VSS YEL WIRE