Ford Explorer III (2001-2006) org/red Wiring diagrams

A/C CLUTCH FIELD COIL (AT LEFT FRONT OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (AT FRONT CENTER OF ENGINE COMPARTMENT) AUXILIARY RELAY BOX 1 (RIGHT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 15 FUSE 28 FUSE 32 FUSE 7 GRY WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATER BLOWER MOTOR (AT RIGHT REAR OF ENGINE COMPARTMENT) HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN HOT IN RUN OR START LT BLU WIRE LT GRN/RED WIRE OF ENGINE COMPT) ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/ORG WIRE RED/YEL WIRE RUN WIRE VIO WIRE W/ HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE WHT WIRE YEL WIRE

BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DEFROST MAX FRONT FUNCTION SELECTOR SWITCH ASSEMBLY (BEHIND CENTER OF DASH) FUSE 11 FUSE 31 GRY/YEL WIRE HIGH MEDIUM HIGH MEDIUM HIGH BLOWER MOTOR SWITCH HOT IN ILLUMINATION LOW OFF LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MAX DEFROST MEDIUM LOW LOW MIX NORMAL FLOOR VENT OFF MODE SWITCH OFF FLOOR VENT NORMAL MIX ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE REAR BLOWER MOTOR (W/ HIGH SERIES CENTER CONSOLE) (AT REAR OF CENTER CONSOLE) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RUN WIRE TEMP DR RESISTOR - VOLTAGE IN RUN GROUND TEMP DR RESISTOR WIPER TEMP DR RESISTOR + TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) TEMPERATURE CONTROL POTENTIOMETER VIO WIRE W/ HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE

-1 +2 1 2 3 4 5 6 7 8 9 10 11 12 (+) (-) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUMINATION GND VPWR 1 2 GND VBATT 3 4 5 6 7 8 9 10 L FRONT SPKR(+) R FRONT SPKR(+) L FRONT SPKR(-) 815 167 TWISTED PAIR ANTENNA BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BEHIND REAR SEATS) BLK WIRE BLK/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE FUSE 11 FUSE 28 FUSE 29 FUSE 39 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT W/ WINDOW SAFETY RELAY ENERGIZED L FRONT SPKR (-) R FRONT SPKR (+) LEFT FRONT SPEAKER LEFT REAR SPEAKER LEFT FRONT SPEAKER RIGHT FRONT SPEAKER LT BLU/WHT WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MUTE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK/LT GRN WIRE POWER WINDOWS SYSTEM R FRONT SPKR (-) L FRONT SPKR (+) R FRONT SPKR - RADIO RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SUBWOOFER SUBWOOFER AMPLIFIER (BEHIND REAR SEATS) TAN/YEL WIRE TWISTED PAIR TWISTED PAIR 820 816 819 VIO WIRE WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION AIR BAG CONTACT AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM ANTENNA ASYSON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM INTERIOR LIGHTS SYSTEM DK GRN WIRE DK GRN/ORG WIRE DVD PLAYER DVD RIGHT + DVD RIGHT - DVD LEFT + DVD LEFT - FAN DOWN TEMP UP FAN UP TEMP DOWN FUSE 28 FUSE 3 GRN WIRE GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START HOT WITH ACC DELAY RELAY ENERGIZED ILLUM LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE MEDIUM NEXT VOL DOWN VOL UP NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) PROTOCOL A PROTOCOL B PTC 1 RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SHIELD SPKR LF+ SPKR RT+ TAN WIRE TAN/ORG WIRE TAN/YEL WIRE TWISTED PAIR VEHICLE SPEED WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) VSS VSS YEL WIRE