Ford Explorer III (2001-2006) (near breakout behind center of dash) Wiring diagrams

17 16 SCP- SCP+ ABS CONTROL MODULE (ON LEFT SIDE OF OF ENGINE COMPARTMENT) ABS TEST CONNECTOR (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) FEPS FOUR-WHEEL DRIVE CONTROL MODULE (AT RIGHT FUSE 17 HOT AT ALL TIMES INSTRUMENT CLUSTER ISO KICK PANEL) LT BLU WIRE LT BLU/WHT WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RESTRAINTS CONTROL MODULE (BEHIND LOWER CENTER OF DASH) SCP+ TAN/ORG WIRE TWISTED PAIR VIO WIRE W/ KEYLESS ENTRY W/O KEYLESS ENTRY WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DRV UNLOCK 1 640 810 HORNS SYSTEM 1/2 14 195 7 EXTERIOR LIGHTS SYSTEM 3/4 5/6 6 999 140 460 57 124 HORNS SYSTEM 7/8 9/0 AJAR SWITCH (IN REAR TOP OF PASSENGER DOOR) ALL LOCK/ ALL UNLOCK ILLUM UNLK DOORS POWER GROUND BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) FUSE 35 BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 14 CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) DK BLU WIRE DOOR AJAR IND DOOR AJAR SWITCH (IN TOP REAR OF RIGHT REAR DOOR) DRIVER SIDE DOOR LOCK ACTUATOR (IN REAR BOTTOM OF DRIVER DOOR) DRIVER SIDE DOOR LOCK SWITCH LOCK DRIVER SIDE FRONT DOOR AJAR SWITCH (IN REAR TOP OF DRIVER DOOR) DRIVER SIDE REAR DOOR AJAR SWITCH (IN TOP REAR OF LEFT REAR DOOR) FOUR-WHEEL DRIVE CONTROL MODULE (AT RIGHT KICK PANEL) FUSE 26 FUSE 5 FUSE 9 GRY WIRE GRY/RED WIRE HORN DOOR AJAR REVERSE IN VBATT GROUND KEY PAD COM HORN VPWR BPP SWITCH HOT AT ALL TIMES HOT IN START OR RUN ILLUM INSTRUMENT CLUSTER ISO BUS KEY PAD ILL KEY PAD IN KEY PAD IN KEY PAD IN KEY PAD SWITCH ASSEMBLY LEFT REAR DOOR LOCK ACTUATOR (IN BOTTOM REAR OF LEFT REAR DOOR) LOCK LOCK DOORS LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MICRO- PROCESSOR ORG/ WIRE PASS- ENGER SIDE REAR PASSENGER SIDE DOOR LOCK ACTUATOR (IN BOTTOM REAR OF PASSENGER DOOR) PASSENGER SIDE DOOR LOCK SWITCH UNLK PASSENGER SIDE FRONT DOOR PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RIGHT REAR DOOR LOCK ACTUATOR (IN BOTTOM REAR OF RIGHT REAR DOOR) TAN WIRE TAN/WHT WIRE UNLK VBATT PARK LAMPS WHT WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

ABS IND. AIR BAG IND AJAR SW SNS AJAR SW SNS WARNING SW+ AUTOLAMP SENS + ANTI- THEFT IND ANTI-THEFT SYSTEM BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FLUID LEVEL BRN/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) CHARGE IND CHECK ENGINE IND CHECK GAUGE COMPUTER DATA LINES SYSTEM CONN A CONN B CRUISE CONTROL SYSTEM ANTI-LOCK BRAKES SYSTEM DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR AJAR IND DRIVER SIDE FRONT DOOR AJAR SWITCH (IN REAR TOP OF DRIVER DOOR) DRIVER SIDE REAR DOOR AJAR SWITCH (IN TOP REAR OF LEFT REAR DOOR) ENGINE COOLANT TEMPERATURE GAUGE FOUR-WHEEL DRIVE CONTROL MODULE (AT RIGHT KICK PANEL) FUEL GAUGE FUEL TANK UNIT (UNDER LEFT SIDE OF VEHICLE, IN FUEL TANK) FUSE 14 FUSE 25 FUSE 27 FUSE 6 GRY WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN IGNITION KEY SWITCH IGNITION SWITCH ILLUM INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM, POWER WINDOWS SYSTEM LH TURN SIGNAL IND LOW BRAKE FLUID LEVEL/PARK BRAKE IND LOW FUEL IND LOW OIL PRESSURE GAUGE LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MICROPROCESSOR NCA WIRE OFF LOCK ORG/LT BLU WIRE ORG/LT GRN WIRE PARKING BRAKE SWITCH (AT LEFT KICK PANEL) PASSENGER SIDE FRONT DOOR AJAR SWITCH (IN REAR TOP OF PASSENGER DOOR) PASSENGER SIDE REAR DOOR AJAR SWITCH (IN TOP REAR OF PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/BLK WIRE RED/YEL WIRE RH TURN SIGNAL IND RIGHT REAR DOOR RLY CTRL RUN WIRE SAFETY BELT IND SAFETY RLY CTRL BATTERY SAVER RLY CTRL SCP+ SCP- VREF GND SIDE OF DASH) SPEED CONTROL IND SPEEDOMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM SWITCH (ON MASTER CYLINDER) TACHOMETER TAN/LT GRN WIRE TAN/ORG WIRE VIO/ORG WIRE VIO/WHT WIRE VOLTMETER WARNING SYSTEM WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/WHT WIRE

BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DEFROST MAX FRONT FUNCTION SELECTOR SWITCH ASSEMBLY (BEHIND CENTER OF DASH) FUSE 11 FUSE 31 GRY/YEL WIRE HIGH MEDIUM HIGH MEDIUM HIGH BLOWER MOTOR SWITCH HOT IN ILLUMINATION LOW OFF LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MAX DEFROST MEDIUM LOW LOW MIX NORMAL FLOOR VENT OFF MODE SWITCH OFF FLOOR VENT NORMAL MIX ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE REAR BLOWER MOTOR (W/ HIGH SERIES CENTER CONSOLE) (AT REAR OF CENTER CONSOLE) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RUN WIRE TEMP DR RESISTOR - VOLTAGE IN RUN GROUND TEMP DR RESISTOR WIPER TEMP DR RESISTOR + TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) TEMPERATURE CONTROL POTENTIOMETER VIO WIRE W/ HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DRV UNLOCK 1 640 810 HORNS SYSTEM 1/2 14 195 7 EXTERIOR LIGHTS SYSTEM 3/4 5/6 6 999 140 460 57 124 HORNS SYSTEM 7/8 9/0 AJAR SWITCH (IN REAR TOP OF PASSENGER DOOR) ALL LOCK/ ALL UNLOCK ILLUM UNLK DOORS POWER GROUND BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) FUSE 35 BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 14 CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) DK BLU WIRE DOOR AJAR IND DOOR AJAR SWITCH (IN TOP REAR OF RIGHT REAR DOOR) DRIVER SIDE DOOR LOCK ACTUATOR (IN REAR BOTTOM OF DRIVER DOOR) DRIVER SIDE DOOR LOCK SWITCH LOCK DRIVER SIDE FRONT DOOR AJAR SWITCH (IN REAR TOP OF DRIVER DOOR) DRIVER SIDE REAR DOOR AJAR SWITCH (IN TOP REAR OF LEFT REAR DOOR) FOUR-WHEEL DRIVE CONTROL MODULE (AT RIGHT KICK PANEL) FUSE 26 FUSE 5 FUSE 9 GRY WIRE GRY/RED WIRE HORN DOOR AJAR REVERSE IN VBATT GROUND KEY PAD COM HORN VPWR BPP SWITCH HOT AT ALL TIMES HOT IN START OR RUN ILLUM INSTRUMENT CLUSTER ISO BUS KEY PAD ILL KEY PAD IN KEY PAD IN KEY PAD IN KEY PAD SWITCH ASSEMBLY LEFT REAR DOOR LOCK ACTUATOR (IN BOTTOM REAR OF LEFT REAR DOOR) LOCK LOCK DOORS LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MICRO- PROCESSOR ORG/ WIRE PASS- ENGER SIDE REAR PASSENGER SIDE DOOR LOCK ACTUATOR (IN BOTTOM REAR OF PASSENGER DOOR) PASSENGER SIDE DOOR LOCK SWITCH UNLK PASSENGER SIDE FRONT DOOR PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RIGHT REAR DOOR LOCK ACTUATOR (IN BOTTOM REAR OF RIGHT REAR DOOR) TAN WIRE TAN/WHT WIRE UNLK VBATT PARK LAMPS WHT WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

-1 +2 1 2 3 4 5 6 7 8 9 10 11 12 (+) (-) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUMINATION GND VPWR 1 2 GND VBATT 3 4 5 6 7 8 9 10 L FRONT SPKR(+) R FRONT SPKR(+) L FRONT SPKR(-) 815 167 TWISTED PAIR ANTENNA BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BEHIND REAR SEATS) BLK WIRE BLK/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE FUSE 11 FUSE 28 FUSE 29 FUSE 39 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT W/ WINDOW SAFETY RELAY ENERGIZED L FRONT SPKR (-) R FRONT SPKR (+) LEFT FRONT SPEAKER LEFT REAR SPEAKER LEFT FRONT SPEAKER RIGHT FRONT SPEAKER LT BLU/WHT WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MUTE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK/LT GRN WIRE POWER WINDOWS SYSTEM R FRONT SPKR (-) L FRONT SPKR (+) R FRONT SPKR - RADIO RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SUBWOOFER SUBWOOFER AMPLIFIER (BEHIND REAR SEATS) TAN/YEL WIRE TWISTED PAIR TWISTED PAIR 820 816 819 VIO WIRE WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE