Ford Explorer III (2001-2006) (near breakout Wiring diagrams

10 4 3 5 7 MEMORY SET SW MEMORY SET SW MEMORY SET SW MEMORY SET SW ADJ PEDAL POT 12 10 ADJ PEDAL MTR ADJ PEDAL MTR 13 19 POS SENS - POS SENS + 2 1 GROUND POWER 9 8 ADJ PEDAL SW ADJ PEDAL SW ADJUSTABLE PEDAL MEMORY POTENTIOMETER (UNDER DRIVER'S SIDE OF DASH) ADJUSTABLE PEDAL MOTOR (ON PEDAL ASSEMBLY, LEFT OF BRAKE PEDAL) ADJUSTABLE PEDAL SWITCH BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 1 DK GRN WIRE DRIVER SEAT MODULE (IN DRIVER'S SEAT) FORWARD/ HOT AT ALL TIMES LEFT POWER SEAT MOTOR ASSEMBLY (IN DRIVER SEAT) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE MEMORY SEATS CIRCUIT ORG/ WIRE ORG/RED WIRE ORG/WHT WIRE PNK/BLK WIRE REARWARD RED WIRE RED/BLK WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

1 3 6 13 SS B 2 10 13 DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) 81 84 89 EPC OSS TP 90 91 92 97 103 VREF SIG RTN BPP POWER GROUND ANTI-LOCK BRAKES SYSTEM AUTOMATIC TRANSMISSION (LEFT SIDE OF TRANSMISSION) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 19 DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (FRONT OF ENGINE, LEFT OF THROTTLE BODY) FUSE 2 FUSE 24 FUSE 36 FUSE 44 FUSE 7 PCM POWER DIODE FUSE 9 GROUND SS C TCC KAPWR ISS GRY WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE POWER GROUND GROUND POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE RUN WIRE SHIFT INTERLOCK SYSTEM SHIFT SOLENOIDS TAN WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (ATTACHED TO THROTTLE BODY) TRANSMISSION CONTROL SWITCH (TCS) TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TSS DLC DLC (-) DLC (+) GROUND SS A SS D TCS TFT ECT TURBINE SHAFT SPEED (TSS) SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

0) OFF 1) LOW 2) MED LOW 3) MED HIGH 4) HIGH 5) CEILING 6) FLOOR 0) OFF 1) REAR 2) LOW 3) MED LOW 4) MED HIGH 5) CEILING 6) FLOOR A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AUDIO/ CLIMATE CONTROL SWITCH AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COOL CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE FAN UP TEMP UP FAN DN FUSE 25 FUSE 33 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR MODE DOOR ACTUATOR (BEHIND REAR SEATS) RED WIRE RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMP DN TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WARM WHT WIRE YEL WIRE YEL/BLK WIRE

A/C CLUTCH RELAY AUTOLAMP HEADLAMP RELAY MAIN LIGHT SWITCH AUXILIARY RELAY BOX 2 (UNDER LEFT SIDE OF DASH, NEAR STEERING COLUMN) BATTERY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLOWER MOTOR RELAY STARTER RELAY TRAILER TOW RELAY BRAKE PEDAL POSITION SWITCH BRAKE PEDAL POSITION SWITCH SUBWOOFER AMPLIFIER BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY DOOR UNLOCK RELAY MODULE CENTRAL SECURITY MODULE INDICATOR FLASHER RELAY COMPT, AT FENDER APRON) DAYTIME RUNNING LAMPS (DRL) MODULE ABS CONTROL MODULE DK BLU WIRE DK GRN WIRE DOOR LOCK RELAY DRIVER SIDE FRONT SEAT ADJUST SWITCH LEFT FRONT LUMBAR ADJUST SWITCH EXTERIOR REAR VIEW MIRROR SWITCH FOG LAMP RELAY FOUR WHEEL DRIVE CONTROL MODULE FROM FUSE 15 (DIAGRAM 1 OF 2) FROM FUSE 34 (DIAGRAM 1 OF 2) FUEL PUMP RELAY FUSE FUSE 1 FUSE 10 FUSE 11 FUSE 14 FUSE 15 FUSE 20 FUSE 22 FUSE 24 FUSE 26 FUSE 27 FUSE 16 FUSE 18 FUSE 28 FUSE 29 FUSE 31 FUSE 34 FUSE 35 FUSE 5 FUSE 8 FUSE 7 FUSE 23 FUSE 9 FUSE 9 FUSE 13 FUSE FUSE 3 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- FUSIBLE LINK C (18 GA- GENERATOR GRY WIRE HARNESS, NEAR BREAKOUT UNDER DRIVER SEAT) HEATED SEATS RELAY PASSENGER SIDE FRONT SEAT ADJUST SWITCH HORN RELAY LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH AUTOLAMP HEADLAMP RELAY CENTRAL SECURITY MODULE MULTI- FUNCTION SWITCH RIGHT FRONT LUMBAR ADJUST SWITCH NCA WIRE ORG/ WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) REAR POWER POINT (REAR OF VEHICLE, ON LEFT SIDE) REAR WINDOW MOTOR RED WIRE ROOF OPENING PANEL MODULE STARTER MOTOR SUBWOOFER AMPLIFIER TAN WIRE TO FUSE 1 (DIAGRAM 1 OF 2) TO FUSE 14 (DIAGRAM 1 OF 2) TO FUSE 25 (DIAGRAM 2 OF 2) VIO WIRE WHT WIRE WHT/YEL WIRE WINDOW SAFETY RELAY WINDSHIELD WIPER RELAY XLS XLT XLT XLS YEL WIRE YEL/LT BLU WIRE

1/2 2 3 UNLOCK RELAY LOCK RELAY 3/4 5/6 7/8 8 14 3 VBATT VBATT VPWR 9/0 BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) FUSE 16 BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DOOR LOCK/ UNLOCK RELAY DRIVER DOOR UNLOCK RELAY DRIVER SIDE DOOR LOCK SWITCH FUSE 2 FUSE 20 FUSE 22 GROUND HOT AT ALL TIMES KEY PAD SWITCH ASSEMBLY LEFT FRONT DOOR LOCK ACTUATOR (AT REAR OF LEFT FRONT DOOR) LEFT REAR DOOR LOCK ACTUATOR (AT REAR OF LEFT REAR DOOR) LIFTGATE DOOR LOCK SWITCH (AT LEFT REAR LIFTGATE LOCK ACTUATOR (ON CENTER OF LIFTGATE) LOCK LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE MICROPROCESSOR ORG/ WIRE PASSENGER SIDE FRONT DOOR LOCK UNIT PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE PWR RED WIRE RED/ORG WIRE RIGHT FRONT DOOR LOCK ACTUATOR (AT REAR OF RIGHT FRONT DOOR) RIGHT REAR DOOR LOCK ACTUATOR (AT REAR OF RIGHT REAR DOOR) SAFETY BELT BUCKLE SWITCH SIG RTN TAN WIRE TAN/WHT WIRE UNLK CORNER OF VEHICLE) UNLK LOCK VEHICLE SECURITY MODULE (VSM) (ABOVE RIGHT REAR WHEELWELL) VREF WHT WIRE WHT/LT BLU WIRE YEL WIRE

BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN WIRE CIRCUIT CLOSE DN UP DRIVER SIDE FRONT POWER WINDOW MOTOR (IN BOTTOM CENTER OF DRIVER DOOR) FUSE GRY WIRE HOT AT ALL TIMES ILLUM INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (AT LEFT KICK PANEL) LEFT REAR LEFT REAR POWER WINDOW MOTOR (IN CENTER OF LEFT REAR DOOR) LEFT REAR WINDOW ADJUST SWITCH LOCK LT BLU WIRE LT GRN WIRE MASTER WINDOW ADJUST SWITCH ONE- TOUCH DOWN ONE-TOUCH DOWN RELAY OPEN/ VENT ORG/ WIRE PASSENGER PASSENGER SIDE FRONT POWER WINDOW MOTOR (IN BOTTOM CENTER OF PASSENGER DOOR) PASSENGER SIDE WINDOW ADJUST SWITCH PNK WIRE RADIO REAR WINDOW ADJUST SWITCH REAR WINDOW MOTOR (UNDER CENTER OF REAR WINDOW) RED WIRE RIGHT REAR RIGHT REAR POWER WINDOW MOTOR (IN CENTER OF RIGHT REAR DOOR) RIGHT REAR WINDOW ADJUST SWITCH ROOF OPENING PANEL MODULE (AT FRONT CENTER OF ROOF) TAN WIRE UP DN UP DN DN VBATT VIO WIRE VPWR VREF WHT WIRE WINDOW SAFETY RELAY YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 DVD LEFT + DVD LEFT - 1 2 3 4 5 6 7 8 9 10 ENABLE GND 1 2 3 4 5 6 7 8 SUBWOOFER HIGH + SUBWOOFER HIGH - SHIELD ENABLE AIR BAG CONTACT AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM ANTENNA ASYSON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B DVD RIGHT + DVD RIGHT - AUDIO UNIT AUDIO/ CLIMATE CONTROL SWITCH BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CIRCUIT BREAKER PTC 1 CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM INTERIOR LIGHTS SYSTEM DK GRN WIRE DK GRN/ORG WIRE DVD PLAYER FAN DOWN TEMP UP FAN UP FUSE 28 FUSE 3 GRN WIRE GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START HOT W/ ACC DELAY RELAY ENERGIZED ILLUM L FRONT SPKR (-) L REAR SPKR (-) R REAR SPKR (-) LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE MEDIA NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) PROTOCOL A PROTOCOL B RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SHIELD SPKR LF+ SPKR RT+ SUBWOOFER SUBWOOFER AMPLIFIER (AT RIGHT REAR QUARTERPANEL) TAN WIRE TAN/ORG WIRE TAN/YEL WIRE TEMP DOWN TWISTED PAIR VBATT SUBWOOFER HIGH + SUBWOOFER HIGH - VOL DOWN NEXT VOL UP VSS WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE WINDSHIELD WIPER MOTOR (AT LEFT REAR OF ENGINE COMPT) VSS YEL WIRE

4 3 2 1 TRAILER TOW CONNECTOR (ON CENTER OF REAR BUMPER) AUTO HEAD AUTO BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 5 DK GRN WIRE EXTERIOR LAMPS CIRCUIT FUEL PUMP RELAY FUSE 23 HEAD HOT AT ALL TIMES INSTRUMENT CLUSTER MAIN LIGHT SWITCH OFF OFF PARK PARK RED WIRE TAN WIRE TRAILER TOW RELAY WHT WIRE WHT/RED WIRE YEL WIRE

A/C SYSTEM AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION (CKP) SENSOR (LOWER FRONT OF ENGINE COMPT) DIGITAL TRANSMISSION RANGE SENSOR DK BLU WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DLC BUS (-) DLC BUS (+) EGR INPUT FUEL GAUGE EPROM POWER FUSE 3 FUSE 32 FUSE 36 GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 2 IGNITION COIL (CENTER REAR OF ENGINE COMPARTMENT) IGNITION TRANSFORMER CAPACITOR (CENTER REAR OF ENGINE COMPARTMENT) LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE NOT USED KS SENSOR ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PRES SENS INPUT RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE ST CTRL RELAY STARTING/CHARGING SYSTEM TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TSS SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/BLK WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE DIFFERENTIAL PRESSURE FEEDBACK EGR SENSOR (REAR OF ENGINE COMPARTMENT) DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EGR VACUUM REGULATOR SOLENOID (CENTER REAR OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON FRONT OF ENGINE) EVAP CANISTER PURGE VALVE (LEFT FRONT OF ENGINE COMPT) EVAP EMISSIONS CANISTER VENT VALVE (UNDER LEFT REAR OF VEHICLE) FUEL PUMP RELAY FUSE 23 FUSE 40 FUSE 44 GRY WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INTERMEDIATE SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) KNOCK SENSOR (NEAR INTAKE MANIFOLD) LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (ATTACHED TO THROTTLE BODY) VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE YEL/RED WIRE YEL/WHT WIRE