Ford Explorer III (2001-2006) hot in Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 B+ B+ 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 SIG RETURN GROUND N TOW SW MOTOR 1 BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 22 BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (TOP RIGHT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DK GRN WIRE DK GRN/LT GRN WIRE DOOR AJAR MOTOR 4 NEUTRAL SENS TRANSFER CASE ENGINE CONTROLS SYSTEM FOUR WHEEL DRIVE SWITCH FOUR-WHEEL DRIVE CONTROL MODULE (AT RIGHT KICK PANEL) FUSE 14 FUSE 16 FUSE 20 FUSE 25 FUSE 9 GEM MODULE, INSTRUMENT CLUSTER, OVERHEAD CONSOLE GROUND TRANSFER CASE IGN (RUN) GRY WIRE GRY/BLK WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGN (ST/RUN) ILLUM INSTRUMENT CLUSTER INSTRUMENT CLUSTER, CENTRAL SECURITY MODULE, ELECTROCHROMIC MIRROR ISO BUS LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE MICROPROCESSOR MOTOR 3 MOTOR 5 BPP SWITCH NCA WIRE NEUTRAL TOW INDICATOR OFF ORG/ WIRE ORG/WHT WIRE POWERTRAIN CONTROL MODULE (MOUNTED THROUGH FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SPEED CONTROL SERVO TRANSFER CASE ASSEMBLY VIO/YEL WIRE VSS INPUT MOTOR 2 WHT WIRE WHT/LT BLU WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

1 3 6 13 SS B 2 10 13 DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) 81 84 89 EPC OSS TP 90 91 92 97 103 VREF SIG RTN BPP POWER GROUND ANTI-LOCK BRAKES SYSTEM AUTOMATIC TRANSMISSION (LEFT SIDE OF TRANSMISSION) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 19 DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE (ECT) SENSOR (FRONT OF ENGINE, LEFT OF THROTTLE BODY) FUSE 2 FUSE 24 FUSE 36 FUSE 44 FUSE 7 PCM POWER DIODE FUSE 9 GROUND SS C TCC KAPWR ISS GRY WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE POWER GROUND GROUND POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE RUN WIRE SHIFT INTERLOCK SYSTEM SHIFT SOLENOIDS TAN WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (ATTACHED TO THROTTLE BODY) TRANSMISSION CONTROL SWITCH (TCS) TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TSS DLC DLC (-) DLC (+) GROUND SS A SS D TCS TFT ECT TURBINE SHAFT SPEED (TSS) SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

A/C CLUTCH FIELD COIL (AT LEFT FRONT OF ENGINE COMPARTMENT) A/C CLUTCH RELAY A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (AT FRONT CENTER OF ENGINE COMPARTMENT) AUXILIARY RELAY BOX 1 (RIGHT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 15 FUSE 28 FUSE 32 FUSE 7 GRY WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATER BLOWER MOTOR (AT RIGHT REAR OF ENGINE COMPARTMENT) HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN HOT IN RUN OR START LT BLU WIRE LT GRN/RED WIRE OF ENGINE COMPT) ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/ORG WIRE RED/YEL WIRE RUN WIRE VIO WIRE W/ HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE WHT WIRE YEL WIRE

BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DEFROST MAX FRONT FUNCTION SELECTOR SWITCH ASSEMBLY (BEHIND CENTER OF DASH) FUSE 11 FUSE 31 GRY/YEL WIRE HIGH MEDIUM HIGH MEDIUM HIGH BLOWER MOTOR SWITCH HOT IN ILLUMINATION LOW OFF LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MAX DEFROST MEDIUM LOW LOW MIX NORMAL FLOOR VENT OFF MODE SWITCH OFF FLOOR VENT NORMAL MIX ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE REAR BLOWER MOTOR (W/ HIGH SERIES CENTER CONSOLE) (AT REAR OF CENTER CONSOLE) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RUN WIRE TEMP DR RESISTOR - VOLTAGE IN RUN GROUND TEMP DR RESISTOR WIPER TEMP DR RESISTOR + TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) TEMPERATURE CONTROL POTENTIOMETER VIO WIRE W/ HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 HIGH AUDIO + HIGH AUDIO - SHIELD MUTE ANTENNA BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN/ORG WIRE DK GRN/VIO WIRE FUSE 13 FUSE 28 FUSE 29 FUSE 39 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT W/ WINDOW SAFETY RELAY ENERGIZED L FRONT SPKR (-) L REAR SPKR (-) R REAR SPKR (-) LEFT FRONT SPEAKER RIGHT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/VIO WIRE MUTE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE POWER WINDOWS SYSTEM RADIO RED WIRE RED/BLK WIRE RIGHT REAR SPEAKER SUBWOOFER SUBWOOFER AMPLIFIER (NEAR RIGHT SIDE OF REAR WINDOW) TAN/YEL WIRE TWISTED PAIR VBATT VIO WIRE VIO/LT BLU WIRE VPWR WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE

-1 +2 1 2 3 4 5 6 7 8 9 10 11 12 (+) (-) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUMINATION GND VPWR 1 2 GND VBATT 3 4 5 6 7 8 9 10 L FRONT SPKR(+) R FRONT SPKR(+) L FRONT SPKR(-) 815 167 TWISTED PAIR ANTENNA BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BEHIND REAR SEATS) BLK WIRE BLK/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE FUSE 11 FUSE 28 FUSE 29 FUSE 39 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT W/ WINDOW SAFETY RELAY ENERGIZED L FRONT SPKR (-) R FRONT SPKR (+) LEFT FRONT SPEAKER LEFT REAR SPEAKER LEFT FRONT SPEAKER RIGHT FRONT SPEAKER LT BLU/WHT WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MUTE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK/LT GRN WIRE POWER WINDOWS SYSTEM R FRONT SPKR (-) L FRONT SPKR (+) R FRONT SPKR - RADIO RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SUBWOOFER SUBWOOFER AMPLIFIER (BEHIND REAR SEATS) TAN/YEL WIRE TWISTED PAIR TWISTED PAIR 820 816 819 VIO WIRE WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE