Ford Explorer III (2001-2006) fuse Wiring diagrams

1 2 3 4 5 6 7 8 9 10 INDICATOR CONTROL AIR BAG SLIDING CONTACT (ON STEERING COLUMN) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK BLU/ LT WIRE BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESS INPUT GROUND BRAKE PRESSURE SWITCH (ON BRAKE MASTER CYLINDER) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COAST DK BLU/YEL WIRE DK GRN/ORG WIRE FOUR-WHEEL DRIVE CONTROL MODULE (AT RIGHT KICK PANEL) FUSE GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LT BLU/BLK WIRE MICRO- PROCESSOR VPWR OFF REST ON HORN ORG GRN/ DK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON REAR OF TRANSMISSION) OVERHEAD CONSOLE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/ LT GRN WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE REST RESUME SET/ REST SPEED CONT SW IN SPEED CONT SW GND VPWR SPEED CONTROL ACTUATOR (IN RIGHT REAR OF ENGINE COMPARTMENT) SPEED CONTROL INDICATOR STEERING WHEEL/ SPEED CONTROL SWITCH TAN/ORG WIRE VEHICLE SPEED INPUT BRAKE APPLIED IN VIO/ BLK WIRE VSS WINDSHIELD WIPER MOTOR (LEFT OF CENTER, AT REAR OF ENGINE COMPT) YEL/LT GRN WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM AUDIO/ CLIMATE CONTROL SWITCH BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CAN-BUS COMPUTER DATA LINES SYSTEM DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (AT TOP OF ENGINE) ENGINE CONTROLS SYSTEM ETC MOTOR, +/- FUSE GRY/RED WIRE GRY/WHT WIRE HORN SWITCH HOT AT ALL TIMES INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN BATTERY JUNCTION BOX (BJB)) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR ORG/ WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) RES ON SENSOR (A/T: LEFT REAR OF AUTOMATIC TRANSMISSION) SET- SIG SIG RTN SPEED CONTROL INDICATOR SPEED CONTROL SWITCH TAN WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF THROTTLE BODY) TWISTED PAIR VREF WHT WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM AUDIO/ CLIMATE CONTROL SWITCH BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CAN-BUS COMPUTER DATA LINES SYSTEM DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (AT TOP OF ENGINE) ENGINE CONTROLS SYSTEM ETC MOTOR, +/- FUSE GRY/RED WIRE GRY/WHT WIRE HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN BATTERY JUNCTION BOX (BJB)) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR ORG/ WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE RES ON SENSOR (A/T: LEFT REAR OF AUTOMATIC TRANSMISSION) SET- SIG SIG RTN SPEED CONTROL INDICATOR SPEED CONTROL SWITCH TAN WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF THROTTLE BODY) TWISTED PAIR VREF WHT WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN WIRE DRIVER SIDE SEAT BACK HEATER (IN DRIVER SEAT) DRIVER SIDE SEAT CUSHION HEATER (IN DRIVER SEAT) DRIVER SIDE SEAT HEATER SWITCH FUSE FUSE 15 GRY/LT BLU WIRE GRY/YEL WIRE HEATED SEATS RELAY (ON FLOOR, UNDER DRIVER SEAT) HOT AT ALL TIMES HOT IN RUN ILLUM INDICATOR PASSENGER SIDE SEAT BACK HEATER (IN PASSENGER SEAT) PASSENGER SIDE SEAT CUSHION HEATER (IN PASSENGER SEAT) PASSENGER SIDE SEAT HEATER SWITCH RED/BLK WIRE VIO/LT BLU WIRE YEL/LT BLU WIRE

AT FENDER APRON) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK WIRE DK GRN WIRE DRIVER SEAT LUMBAR COMPRESSOR MOTOR (IN DRIVER SEAT) DRIVER SIDE FRONT SEAT ADJUST SWITCH FUSE HEATED SEATS RELAY (UNDER DRIVER SEAT) HOT AT ALL TIMES LEFT FRONT LUMBAR ADJUST SWITCH NCA WIRE OUT PASSENGER SEAT LUMBAR COMPRESSOR MOTOR (IN PASSENGER SEAT) PASSENGER SIDE FRONT SEAT ADJUST SWITCH RED WIRE RIGHT FRONT LUMBAR ADJUST SWITCH

A/C CLUTCH RELAY AUTOLAMP HEADLAMP RELAY MAIN LIGHT SWITCH AUXILIARY RELAY BOX 2 (UNDER LEFT SIDE OF DASH, NEAR STEERING COLUMN) BATTERY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLOWER MOTOR RELAY STARTER RELAY TRAILER TOW RELAY BRAKE PEDAL POSITION SWITCH BRAKE PEDAL POSITION SWITCH SUBWOOFER AMPLIFIER BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY DOOR UNLOCK RELAY MODULE CENTRAL SECURITY MODULE INDICATOR FLASHER RELAY COMPT, AT FENDER APRON) DAYTIME RUNNING LAMPS (DRL) MODULE ABS CONTROL MODULE DK BLU WIRE DK GRN WIRE DOOR LOCK RELAY DRIVER SIDE FRONT SEAT ADJUST SWITCH LEFT FRONT LUMBAR ADJUST SWITCH EXTERIOR REAR VIEW MIRROR SWITCH FOG LAMP RELAY FOUR WHEEL DRIVE CONTROL MODULE FROM FUSE 15 (DIAGRAM 1 OF 2) FROM FUSE 34 (DIAGRAM 1 OF 2) FUEL PUMP RELAY FUSE FUSE 1 FUSE 10 FUSE 11 FUSE 14 FUSE 15 FUSE 20 FUSE 22 FUSE 24 FUSE 26 FUSE 27 FUSE 16 FUSE 18 FUSE 28 FUSE 29 FUSE 31 FUSE 34 FUSE 35 FUSE 5 FUSE 8 FUSE 7 FUSE 23 FUSE 9 FUSE 9 FUSE 13 FUSE FUSE 3 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- FUSIBLE LINK C (18 GA- GENERATOR GRY WIRE HARNESS, NEAR BREAKOUT UNDER DRIVER SEAT) HEATED SEATS RELAY PASSENGER SIDE FRONT SEAT ADJUST SWITCH HORN RELAY LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH AUTOLAMP HEADLAMP RELAY CENTRAL SECURITY MODULE MULTI- FUNCTION SWITCH RIGHT FRONT LUMBAR ADJUST SWITCH NCA WIRE ORG/ WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) REAR POWER POINT (REAR OF VEHICLE, ON LEFT SIDE) REAR WINDOW MOTOR RED WIRE ROOF OPENING PANEL MODULE STARTER MOTOR SUBWOOFER AMPLIFIER TAN WIRE TO FUSE 1 (DIAGRAM 1 OF 2) TO FUSE 14 (DIAGRAM 1 OF 2) TO FUSE 25 (DIAGRAM 2 OF 2) VIO WIRE WHT WIRE WHT/YEL WIRE WINDOW SAFETY RELAY WINDSHIELD WIPER RELAY XLS XLT XLT XLS YEL WIRE YEL/LT BLU WIRE

BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DOWN DRIVER SIDE EXTERIOR REAR VIEW MIRROR EXTERIOR REAR VIEW MIRROR SWITCH FUSE HOT AT ALL TIMES LEFT LEFT MIRROR LEFT RIGHT NCA WIRE ORG/LT GRN WIRE PASSENGER SIDE EXTERIOR REAR VIEW MIRROR RED WIRE RIGHT RIGHT MIRROR UP DOWN VIO WIRE YEL/BLK WIRE

BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN WIRE DN UP DRIVER SIDE FRONT SEAT ADJUST SWITCH ENTIRE SEAT FRONT OF SEAT FRONT OF SEAT UP/DOWN FUSE HOT AT ALL TIMES LEFT POWER SEAT MOTOR ASSEMBLY (UNDER DRIVER SEAT) LT BLU WIRE LT GRN WIRE LUMBAR CIRCUIT NCA WIRE PASSENGER SIDE FRONT SEAT ADJUST SWITCH REAR OF SEAT REAR SEAT UP/DOWN RED WIRE RIGHT POWER SEAT MOTOR ASSEMBLY (IN PASSENGER SEAT) RWD SEAT FORWARD/ REARWARD WHT WIRE YEL WIRE

BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN WIRE CIRCUIT CLOSE DN UP DRIVER SIDE FRONT POWER WINDOW MOTOR (IN BOTTOM CENTER OF DRIVER DOOR) FUSE GRY WIRE HOT AT ALL TIMES ILLUM INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (AT LEFT KICK PANEL) LEFT REAR LEFT REAR POWER WINDOW MOTOR (IN CENTER OF LEFT REAR DOOR) LEFT REAR WINDOW ADJUST SWITCH LOCK LT BLU WIRE LT GRN WIRE MASTER WINDOW ADJUST SWITCH ONE- TOUCH DOWN ONE-TOUCH DOWN RELAY OPEN/ VENT ORG/ WIRE PASSENGER PASSENGER SIDE FRONT POWER WINDOW MOTOR (IN BOTTOM CENTER OF PASSENGER DOOR) PASSENGER SIDE WINDOW ADJUST SWITCH PNK WIRE RADIO REAR WINDOW ADJUST SWITCH REAR WINDOW MOTOR (UNDER CENTER OF REAR WINDOW) RED WIRE RIGHT REAR RIGHT REAR POWER WINDOW MOTOR (IN CENTER OF RIGHT REAR DOOR) RIGHT REAR WINDOW ADJUST SWITCH ROOF OPENING PANEL MODULE (AT FRONT CENTER OF ROOF) TAN WIRE UP DN UP DN DN VBATT VIO WIRE VPWR VREF WHT WIRE WINDOW SAFETY RELAY YEL WIRE