Ford Explorer III (2001-2006) fuse 10 Wiring diagrams

1) BREAK PEDAL FORCE SWITCH 2) ACTIVE BOOSTER SOLENOID ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ABS IND. ABS TEST CONNECTOR (AT LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE BOOSTER SENSOR (ON FRONT OF BRAKE BOOSTER) BRAKE FLUID LEVEL SWITCH (MOUNTED ON SIDE OF MASTER CYLINDER) BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN/WHT WIRE CAN (+) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ELECTRONIC THROTTLE CONTROL INDICATOR FUSE 10 FUSE 21 FUSE 22 FUSE 25 FUSE 26 FUSE 5 GRN WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN ILLUM IND INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (AT LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (AT LEFT REAR WHEEL) LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE LT LT ORG/ WIRE ORG/RED WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWETRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) PRIMARY BRAKE PRESSURE SENSOR (ON MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) RIGHT FRONT WHEEL SPEED SENSOR (AT RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (AT RIGHT REAR WHEEL) SECONDARY BRAKE PRESSURE SENSOR (ON BRAKE BOOSTER) STEERING POSITION SENSOR (AT TOP OF STEERING COLUMN) TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/YEL WIRE TCS DISABLE TRACTION CONTROL SWITCH TWISTED PAIR VBATT VIO/WHT WIRE VPWR WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE YAW VELOCITY SENSOR (BELOW CENTER CONSOLE) YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ABS IND. ABS TEST CONNECTOR (AT LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE FLUID LEVEL SWITCH (MOUNTED ON SIDE OF MASTER CYLINDER) BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CAN (+) CAN BUS- GND CAN-BUS CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM ELECTRONIC THROTTLE CONTROL INDICATOR FUSE 10 FUSE 22 FUSE 21 FUSE 25 FUSE 45 FUSE 5 GRN WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (AT LEFT FRONT WHEEL) LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE LT LT NEAR BREAKOUT TO A/C CLUTCH CYCLING PRESSURE SWITCH) ORG/ WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE REAR AXLE SPEED SENSOR (ON REAR DIFFERENTIAL) RED WIRE RED/YEL WIRE RIGHT FRONT WHEEL SPEED SENSOR (AT RIGHT FRONT WHEEL) TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/YEL WIRE TWISTED PAIR VBATT VIO/WHT WIRE VPWR VPWR VPWR WHT WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 CAN BUS- GROUND VPWR 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SIGNAL RTN 1 2 3 4 5 6 GROUND A/C CLUTCH RELAY A/C INDICATOR DIODE AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CAN-BUS COMPUTER DATA LINES SYSTEM CTRL VALVE DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FEEDBACK VOLTAGE SIG RTN VREF FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 20 FUSE 30 FUSE 36 FUSE 37 GROUND GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED SIGNAL HOT AT ALL TIMES HOT IN RUN OR START HOT IN START OR RUN ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR INSTRUMENT CLUSTER J/C 1 J/C 2 LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MICROPRO- CESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) PNK/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE PWR RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SEATS SYSTEM TAN/YEL WIRE TWISTED PAIR VAR SPEED SIGNAL RIGHT VREF LEFT VPWR VREF VBATT VEHICLE SECURITY MODULE (VSM) (ABOVE RIGHT REAR WHEELWELL) VIO/YEL WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF BLK WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN WIRE DK GRN/VIO WIRE ENGINE COMPT, AT FENDER APRON) FUSE 10 FUSE 4 FUSE 7 GRN WIRE GRY WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LEFT EXTERIOR REAR VIEW MIRROR LT BLU WIRE MANUAL A/C AUTO A/C MICRO- PROCESSOR ORG/YEL WIRE REAR WINDOW DEFROST GRID REAR WINDOW DEFROST RELAY RIGHT EXTERIOR REAR VIEW MIRROR VIO WIRE

3 7 8 BLEND DR OUTPUT VPWR GROUND A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) A/C INDICATOR DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BLOWER MOTOR SWITCH ILLUMINATION VPWR VBATT EXTERIOR LIGHTS INPUT GROUND BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE COOLANT TEMPERATURE SENSOR (ECT) EXCEPT BASE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND CENTER OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 16 FUSE 30 FUSE 36 FUSE 37 FUSE 7 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT IN START OR RUN HOT W/ REAR WINDOW DEFROST RELAY ENERGIZED INSTRUMENT CLUSTER J/C 2 LT BLU/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MED 1 LOW HIGH MED 2 MEDIUM MICROPRO- CESSOR MODE SWITCH NCA WIRE OFF FLOOR/VENT FLOOR MIX VENT MAX DEF ORG/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) VIO WIRE VIO/YEL WIRE YEL/BLK WIRE YEL/RED WIRE

3 7 8 BLEND DR OUTPUT VPWR GROUND A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) A/C INDICATOR DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BLOWER MOTOR SWITCH ILLUMINATION VPWR VBATT EXTERIOR LIGHTS INPUT GROUND BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE COOLANT TEMPERATURE SENSOR (ECT) EXCEPT BASE FRONT BLOWER MOTOR FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND CENTER OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 16 FUSE 30 FUSE 36 FUSE 37 FUSE 7 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT IN START OR RUN HOT W/ REAR WINDOW DEFROST RELAY ENERGIZED INSTRUMENT CLUSTER J/C 2 LT BLU/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MED 1 LOW HIGH MED 2 MEDIUM MICROPRO- CESSOR MODE SWITCH NCA WIRE OFF FLOOR/VENT FLOOR MIX VENT MAX DEF ORG/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) VIO WIRE VIO/YEL WIRE YEL/BLK WIRE YEL/RED WIRE

A/C CLUTCH RELAY AUTOLAMP HEADLAMP RELAY MAIN LIGHT SWITCH AUXILIARY RELAY BOX 2 (UNDER LEFT SIDE OF DASH, NEAR STEERING COLUMN) BATTERY BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLOWER MOTOR RELAY STARTER RELAY TRAILER TOW RELAY BRAKE PEDAL POSITION SWITCH BRAKE PEDAL POSITION SWITCH SUBWOOFER AMPLIFIER BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY DOOR UNLOCK RELAY MODULE CENTRAL SECURITY MODULE INDICATOR FLASHER RELAY COMPT, AT FENDER APRON) DAYTIME RUNNING LAMPS (DRL) MODULE ABS CONTROL MODULE DK BLU WIRE DK GRN WIRE DOOR LOCK RELAY DRIVER SIDE FRONT SEAT ADJUST SWITCH LEFT FRONT LUMBAR ADJUST SWITCH EXTERIOR REAR VIEW MIRROR SWITCH FOG LAMP RELAY FOUR WHEEL DRIVE CONTROL MODULE FROM FUSE 15 (DIAGRAM 1 OF 2) FROM FUSE 34 (DIAGRAM 1 OF 2) FUEL PUMP RELAY FUSE FUSE 1 FUSE 10 FUSE 11 FUSE 14 FUSE 15 FUSE 20 FUSE 22 FUSE 24 FUSE 26 FUSE 27 FUSE 16 FUSE 18 FUSE 28 FUSE 29 FUSE 31 FUSE 34 FUSE 35 FUSE 5 FUSE 8 FUSE 7 FUSE 23 FUSE 9 FUSE 9 FUSE 13 FUSE FUSE 3 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- FUSIBLE LINK C (18 GA- GENERATOR GRY WIRE HARNESS, NEAR BREAKOUT UNDER DRIVER SEAT) HEATED SEATS RELAY PASSENGER SIDE FRONT SEAT ADJUST SWITCH HORN RELAY LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH AUTOLAMP HEADLAMP RELAY CENTRAL SECURITY MODULE MULTI- FUNCTION SWITCH RIGHT FRONT LUMBAR ADJUST SWITCH NCA WIRE ORG/ WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) REAR POWER POINT (REAR OF VEHICLE, ON LEFT SIDE) REAR WINDOW MOTOR RED WIRE ROOF OPENING PANEL MODULE STARTER MOTOR SUBWOOFER AMPLIFIER TAN WIRE TO FUSE 1 (DIAGRAM 1 OF 2) TO FUSE 14 (DIAGRAM 1 OF 2) TO FUSE 25 (DIAGRAM 2 OF 2) VIO WIRE WHT WIRE WHT/YEL WIRE WINDOW SAFETY RELAY WINDSHIELD WIPER RELAY XLS XLT XLT XLS YEL WIRE YEL/LT BLU WIRE

A/C CLUTCH RELAY ACCESSORY DELAY RELAY AUDIO UNIT BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BRAKE PEDAL RELAY (EARLY PRODUCTION) BRAKE WINDSHIELD WIPER MOTOR PEDAL POSITION SWITCH BRN WIRE DK BLU WIRE DK GRN WIRE DRIVER SEAT MODULE ROOF OPENING PANEL MOTOR ASSEMBLY DVD PLAYER ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE FROM CIRCUIT BREAKER 62 (BJB) (DIAGRAM 1 OF 4) FROM FUSE 1 (BJB) (DIAGRAM 1 OF 4) FROM FUSE 23 (BJB) (DIAGRAM 1 OF 4) FROM IGNITION RELAY (BJB) (DIAGRAM 1 OF 4) FUSE 1 FUSE 10 FUSE 15 FUSE 19 FUSE 21 FUSE 2 FUSE 3 FUSE 22 FUSE 25 FUSE 5 GRY WIRE HIGH BEAM RELAY INDICATOR FLASHER RELAY INSTRUMENT CLUSTER JOINT CONNECTOR 1 LEFT POWER SEAT SWITCH LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH NCA WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) REAR WINDOW DEFROST RED WIRE REDUNDANT PEDAL SWITCH SUBWOOFER AMPLIFIER TO FUSE 11 (CJB) (DIAGRAM 4 OF 4) VEHICLE SECURITY MODULE (VSM) VIO WIRE W/ AUDIOPHILE W/O AUDIOPHILE W/ DVD PLAYER W/ IVD W/ MEMORY W/O MEMORY WHT WIRE YEL WIRE

BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE DK BLU WIRE DOWN/ OPEN FUSE 10 FUSE 39 GND VBATT VREF VREF VPWR HOT AT ALL TIMES HOT WITH WINDOW SAFETY RELAY ENERGIZED LT GRN WIRE RED WIRE ROOF OPENING PANEL MODULE (AT FRONT CENTER OF ROOF) ROOF OPENING PANEL SWITCH UP/ CLOSE VIO WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE

AIR BAG IND CTRL AIR BAG INDICATOR BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA BUS IGNITION PASS AIR BAG 2 PASS AIR BAG 2 DK GRN/WHT WIRE DRIVER 1 SIDE IMPACT SENSOR (AT BOTTOM OF LEFT "B" PILLAR) DRIVER SAFETY BELT BUCKLE SENSOR (NEAR DRIVER SEAT) DVR SIDE IMP 2 + DVR SIDE IMP 2 - PASS SIDE IMP 2 + PASS SIDE IMP 2 - FUSE 10 FUSE 6 FWD CRASH SENS + FWD CRASH SENS - GRN WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN RUN OR START IGNITION TONE REQUEST INSTRUMENT CLUSTER L SIDE AIR BAG + L SIDE AIR BAG - R SIDE AIR BAG + R SIDE AIR BAG - 1 1 1 LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MICROPROCESSOR NCA WIRE ORG/LT GRN WIRE PASS RETRACT PRE + PASS RETRACT PRE - PASSENGER 1 SIDE IMPACT SENSOR (AT BOTTOM OF RIGHT "B" PILLAR) PASSENGER SAFETY BELT BUCKLE SENSOR (NEAR PASSENGER SEAT) PNK/BLK WIRE PNK/ORG WIRE RED WIRE RED/BLK WIRE RED/PNK WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE (BEHIND LOWER CENTER OF DASH) SAFETY BELT INDICATOR SENSOR SIGNAL SHORTING BAR SHORTING BAR TWISTED PAIR VIO WIRE VIO/LT GRN WIRE W/ SIDE AIR CURTAIN WHT WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE