Ford Explorer III (2001-2006) can-bus Wiring diagrams

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ABS IND. ABS TEST CONNECTOR (AT LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE FLUID LEVEL SWITCH (MOUNTED ON SIDE OF MASTER CYLINDER) BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CAN (+) CAN BUS- GND CAN-BUS CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM ELECTRONIC THROTTLE CONTROL INDICATOR FUSE 10 FUSE 22 FUSE 21 FUSE 25 FUSE 45 FUSE 5 GRN WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (AT LEFT FRONT WHEEL) LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE LT LT NEAR BREAKOUT TO A/C CLUTCH CYCLING PRESSURE SWITCH) ORG/ WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE REAR AXLE SPEED SENSOR (ON REAR DIFFERENTIAL) RED WIRE RED/YEL WIRE RIGHT FRONT WHEEL SPEED SENSOR (AT RIGHT FRONT WHEEL) TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/YEL WIRE TWISTED PAIR VBATT VIO/WHT WIRE VPWR VPWR VPWR WHT WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 CAN BUS- GROUND VPWR 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SIGNAL RTN 1 2 3 4 5 6 GROUND A/C CLUTCH RELAY A/C INDICATOR DIODE AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CAN-BUS COMPUTER DATA LINES SYSTEM CTRL VALVE DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FEEDBACK VOLTAGE SIG RTN VREF FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 20 FUSE 30 FUSE 36 FUSE 37 GROUND GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED SIGNAL HOT AT ALL TIMES HOT IN RUN OR START HOT IN START OR RUN ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR INSTRUMENT CLUSTER J/C 1 J/C 2 LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MICROPRO- CESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) PNK/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE PWR RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SEATS SYSTEM TAN/YEL WIRE TWISTED PAIR VAR SPEED SIGNAL RIGHT VREF LEFT VPWR VREF VBATT VEHICLE SECURITY MODULE (VSM) (ABOVE RIGHT REAR WHEELWELL) VIO/YEL WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/BLK WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM AUDIO/ CLIMATE CONTROL SWITCH BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CAN-BUS COMPUTER DATA LINES SYSTEM DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (AT TOP OF ENGINE) ENGINE CONTROLS SYSTEM ETC MOTOR, +/- FUSE GRY/RED WIRE GRY/WHT WIRE HORN SWITCH HOT AT ALL TIMES INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN BATTERY JUNCTION BOX (BJB)) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR ORG/ WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE DASH PANEL) RES ON SENSOR (A/T: LEFT REAR OF AUTOMATIC TRANSMISSION) SET- SIG SIG RTN SPEED CONTROL INDICATOR SPEED CONTROL SWITCH TAN WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF THROTTLE BODY) TWISTED PAIR VREF WHT WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM AUDIO/ CLIMATE CONTROL SWITCH BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (MOUNTED ON MASTER CYLINDER) CAN-BUS COMPUTER DATA LINES SYSTEM DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE ELECTRONIC THROTTLE CONTROL (ETC) MOTOR (AT TOP OF ENGINE) ENGINE CONTROLS SYSTEM ETC MOTOR, +/- FUSE GRY/RED WIRE GRY/WHT WIRE HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN BATTERY JUNCTION BOX (BJB)) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MICROPROCESSOR ORG/ WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE RES ON SENSOR (A/T: LEFT REAR OF AUTOMATIC TRANSMISSION) SET- SIG SIG RTN SPEED CONTROL INDICATOR SPEED CONTROL SWITCH TAN WIRE TAN/YEL WIRE THROTTLE POSITION SENSOR (TPS) (ON TOP OF THROTTLE BODY) TWISTED PAIR VREF WHT WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE