Ford Explorer III (2001-2006) brn Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 CAN BUS- GROUND VPWR 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SIGNAL RTN 1 2 3 4 5 6 GROUND A/C CLUTCH RELAY A/C INDICATOR DIODE AUTOLAMP/ SUNLOAD SENSOR (BEHIND GLOVE BOX) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE CAN-BUS COMPUTER DATA LINES SYSTEM CTRL VALVE DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DRIVER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FEEDBACK VOLTAGE SIG RTN VREF FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR SPEED CONTROLLER (BEHIND CENTER OF DASH) FUSE 10 FUSE 15 FUSE 20 FUSE 30 FUSE 36 FUSE 37 GROUND GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED SIGNAL HOT AT ALL TIMES HOT IN RUN OR START HOT IN START OR RUN ILLUMINATION IN-VEHICLE TEMPERATURE SENSOR INSTRUMENT CLUSTER J/C 1 J/C 2 LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MICROPRO- CESSOR ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PASSENGER TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) PNK/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE PWR RED/BLK WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE SOLENOID ASSEMBLY (BEHIND CENTER OF DASH) SEATS SYSTEM TAN/YEL WIRE TWISTED PAIR VAR SPEED SIGNAL RIGHT VREF LEFT VPWR VREF VBATT VEHICLE SECURITY MODULE (VSM) (ABOVE RIGHT REAR WHEELWELL) VIO/YEL WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL/BLK WIRE

0) OFF 1) LOW 2) MED LOW 3) MED HIGH 4) HIGH 5) CEILING 6) FLOOR 0) OFF 1) REAR 2) LOW 3) MED LOW 4) MED HIGH 5) CEILING 6) FLOOR A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) AIR BAG SLIDING CONTACT (AT TOP OF STEERING COLUMN) AUDIO/ CLIMATE CONTROL SWITCH AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) COOL CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/YEL WIRE FAN UP TEMP UP FAN DN FUSE 25 FUSE 33 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR MODE DOOR ACTUATOR (BEHIND REAR SEATS) RED WIRE RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMP DN TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WARM WHT WIRE YEL WIRE YEL/BLK WIRE

ABS CONTROL MODULE AUTO BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRAKE PEDAL RELAY (EARLY PRODUCTION) BRN WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE FUSE 21 FUSE 25 FUSE 16 FUSE 5 HAZARD HEAD PARK OFF HIGH MOUNTED STOPLAMP HOT AT ALL TIMES HOT IN RUN OR START INDICATOR FLASHER RELAY INSTRUMENT CLUSTER J/C 4 LEFT FRONT PARK/ TURN LAMP LEFT LICENSE PLATE LAMP LEFT REAR PARK/ STOP/ TURN LAMP LEFT TURN LEFT TURN SIGNAL IND RIGHT TURN SIGNAL IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAIN LIGHT SWITCH MICRO- PROCESSOR MULTI- FUNCTION SWITCH NCA WIRE ORG/ WIRE PARKING LAMP TRAILER TOW RELAY PWR REAR AUXILIARY JUNCTION BOX (AJB) (AT RIGHT "D" PILLAR) REAR AUXILIARY JUNCTION BOX (AJB) (AT RIGHT "D" PILLAR) J/C 3 RED/LT GRN WIRE RIGHT FRONT PARK/ TURN LAMP RIGHT LICENSE PLATE LAMP RIGHT REAR PARK/ STOP/ TURN LAMP RIGHT TURN RIGHT TURN TRAILER TOW RELAY LEFT TURN TRAILER TOW RELAY TAN WIRE TAN/WHT WIRE TRAILER ELECTRONIC BRAKE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) VEHICLE SECURITY MODULE(VSM) (ABOVE RIGHT REAR WHEELWELL) VIO/WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WIPER MOTOR

BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE FUSE 16 FUSE 21 FUSE 25 FUSE 5 HAZARD HEAD HIGH MOUNTED STOPLAMP HOT AT ALL TIMES HOT IN RUN OR START INDICATOR FLASHER RELAY INSTRUMENT CLUSTER J/C 4 JUNCTION BOX LEFT FRONT PARK/ TURN LAMP LEFT LICENSE PLATE LAMP LEFT REAR PARK/ STOP/ TURN LAMP LEFT TURN LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAIN LIGHT SWITCH MICRO- PROCESSOR MULTI- FUNCTION SWITCH NCA WIRE PARK AUTO OFF PARKING LAMP TRAILER TOW RELAY PWR REAR AUXILIARY JUNCTION BOX (AJB) (AT RIGHT "D" PILLAR) REAR AUXILIARY JUNCTION BOX (AJB) (AT RIGHT "D" PILLAR) J/C 3 RIGHT FRONT PARK/ TURN LAMP RIGHT LICENSE PLATE LAMP RIGHT REAR PARK/ STOP/ TURN LAMP RIGHT TURN RIGHT TURN SIGNAL IND LEFT TURN SIGNAL IND RIGHT TURN TRAILER TOW RELAY LEFT TURN TRAILER TOW RELAY SWITCH ASSEMBLY TAN/BLK WIRE TAN/WHT WIRE TRAILER ELECTRONIC BRAKE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) VEHICLE SECURITY MODULE(VSM) (ABOVE RIGHT REAR WHEELWELL) VIO/WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DRV UNLOCK 1 640 810 HORNS SYSTEM 1/2 14 195 7 EXTERIOR LIGHTS SYSTEM 3/4 5/6 6 999 140 460 57 124 HORNS SYSTEM 7/8 9/0 AJAR SWITCH (IN REAR TOP OF PASSENGER DOOR) ALL LOCK/ ALL UNLOCK ILLUM UNLK DOORS POWER GROUND BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) FUSE 35 BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 14 CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) DK BLU WIRE DOOR AJAR IND DOOR AJAR SWITCH (IN TOP REAR OF RIGHT REAR DOOR) DRIVER SIDE DOOR LOCK ACTUATOR (IN REAR BOTTOM OF DRIVER DOOR) DRIVER SIDE DOOR LOCK SWITCH LOCK DRIVER SIDE FRONT DOOR AJAR SWITCH (IN REAR TOP OF DRIVER DOOR) DRIVER SIDE REAR DOOR AJAR SWITCH (IN TOP REAR OF LEFT REAR DOOR) FOUR-WHEEL DRIVE CONTROL MODULE (AT RIGHT KICK PANEL) FUSE 26 FUSE 5 FUSE 9 GRY WIRE GRY/RED WIRE HORN DOOR AJAR REVERSE IN VBATT GROUND KEY PAD COM HORN VPWR BPP SWITCH HOT AT ALL TIMES HOT IN START OR RUN ILLUM INSTRUMENT CLUSTER ISO BUS KEY PAD ILL KEY PAD IN KEY PAD IN KEY PAD IN KEY PAD SWITCH ASSEMBLY LEFT REAR DOOR LOCK ACTUATOR (IN BOTTOM REAR OF LEFT REAR DOOR) LOCK LOCK DOORS LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MICRO- PROCESSOR ORG/ WIRE PASS- ENGER SIDE REAR PASSENGER SIDE DOOR LOCK ACTUATOR (IN BOTTOM REAR OF PASSENGER DOOR) PASSENGER SIDE DOOR LOCK SWITCH UNLK PASSENGER SIDE FRONT DOOR PNK WIRE PNK/BLK WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RIGHT REAR DOOR LOCK ACTUATOR (IN BOTTOM REAR OF RIGHT REAR DOOR) TAN WIRE TAN/WHT WIRE UNLK VBATT PARK LAMPS WHT WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

3 7 8 BLEND DR OUTPUT VPWR GROUND A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) A/C INDICATOR DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BLOWER MOTOR SWITCH ILLUMINATION VPWR VBATT EXTERIOR LIGHTS INPUT GROUND BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE COOLANT TEMPERATURE SENSOR (ECT) EXCEPT BASE FRONT BLOWER MOTOR (BEHIND CENTER OF DASH) FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND CENTER OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 16 FUSE 30 FUSE 36 FUSE 37 FUSE 7 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT IN START OR RUN HOT W/ REAR WINDOW DEFROST RELAY ENERGIZED INSTRUMENT CLUSTER J/C 2 LT BLU/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MED 1 LOW HIGH MED 2 MEDIUM MICROPRO- CESSOR MODE SWITCH NCA WIRE OFF FLOOR/VENT FLOOR MIX VENT MAX DEF ORG/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) VIO WIRE VIO/YEL WIRE YEL/BLK WIRE YEL/RED WIRE

0) OFF 1) LOW 2) MED LOW 3) MED HIGH 4) HIGH 5) CEILING 6) FLOOR 0) OFF 1) REAR 2) LOW 3) MED LOW 4) MED HIGH 5) CEILING 6) FLOOR AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 25 COOL DK GRN/YEL WIRE FUSE 33 GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU/ORG WIRE LT GRN WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR MODE DOOR ACTUATOR (LEFT SIDE OF CARGO AREA, BEHIND REAR SEATS) RED/BLK WIRE RED/ORG WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WARM WHT WIRE YEL WIRE YEL/BLK WIRE

3 7 8 BLEND DR OUTPUT VPWR GROUND A/C CLUTCH CYCLING PRESSURE SWITCH (RIGHT SIDE OF ENGINE COMPT) A/C CLUTCH RELAY A/C CLUTCH SOLENOID (AT LEFT SIDE OF ENGINE) A/C HIGH PRESSURE SWITCH (LEFT FRONT OF ENGINE COMPT) A/C INDICATOR DIODE BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BLOWER MOTOR SWITCH ILLUMINATION VPWR VBATT EXTERIOR LIGHTS INPUT GROUND BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ENGINE COOLANT TEMPERATURE SENSOR (ECT) EXCEPT BASE FRONT BLOWER MOTOR FRONT BLOWER MOTOR RESISTOR ASSEMBLY (BEHIND CENTER OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 16 FUSE 30 FUSE 36 FUSE 37 FUSE 7 GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT IN START OR RUN HOT W/ REAR WINDOW DEFROST RELAY ENERGIZED INSTRUMENT CLUSTER J/C 2 LT BLU/ORG WIRE LT GRN/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MED 1 LOW HIGH MED 2 MEDIUM MICROPRO- CESSOR MODE SWITCH NCA WIRE OFF FLOOR/VENT FLOOR MIX VENT MAX DEF ORG/BLK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (AT RIGHT SIDE ENGINE BULKHEAD) RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) VIO WIRE VIO/YEL WIRE YEL/BLK WIRE YEL/RED WIRE

0) OFF 1) REAR 2) LOW 3) MED LOW 4) MED HIGH 5) CEILING 6) FLOOR 1) CEILING 2) FLOOR AUXILIARY A/C RELAY (BEHIND LEFT SIDE OF REAR SEATS) AUXILIARY BLOWER MOTOR (LEFT SIDE OF CARGO AREA) AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (IN LEFT REAR CARGO AREA) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 25 COOL FUSE 33 GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU/ORG WIRE LT GRN WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE REAR A/C CONTROL MODULE (FRONT) (IN ROOF PANEL) REAR A/C CONTROL MODULE (REAR) (IN ROOF PANEL) REAR MODE DOOR ACTUATOR (LEFT SIDE OF CARGO AREA, BEHIND REAR SEATS) RED/BLK WIRE RED/ORG WIRE TEMPERATURE BLEND DOOR ACTUATOR (BELOW LEFT REAR CARGO AREA WINDOW) WARM WHT WIRE YEL WIRE YEL/BLK WIRE

ABS CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BEHIND LEFT SIDE OF DASH) BLK/YEL WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE 25 GRY/RED WIRE HOT AT ALL TIMES ISS J/C 2 (IN BATTERY JUNCTION BOX) LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/YEL WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE ORG/YEL WIRE OSS + PCS A PCS B PCS C PNK/BLK WIRE POWERTRAIN CONTROL MODULE (AT RIGHT SIDE ENGINE BULKHEAD) PRESS CTRL SOL B PRESS CTRL SOL A PRESS CTRL SOL C RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE REDUNDANT PEDAL SWITCH (UNDER LEFT SIDE OF DASH) SHIFT SOL SHIFT SOL SHIFT SOL SHIFT SOL TCC SOL SIG RTN SS A SS B SS C SS D TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TCC SOL TRANSMISSION CONTROL SWITCH TRANSMISSION CONTROLS SYSTEM TRANSMISSION FLUID TEMPERATURE SENSOR TSS TURBINE SHAFT SPEED (TSS) SENSOR (A/T) (TOP LEFT OF TRANS) VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE VREF W/ IVD WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/WHT WIRE