Ford Explorer II (1994-2003) Automatic a/c circuit

1 2 3 4 5 6 7 15 16 17 18 19 20 DATA (-) BATTERY GROUND INPUT GROUND 130 OHMS 226 OHMS 2940 OHMS CRUISE CONTROL 422 OHMS 931 OHMS AIR BAG SLIDING CONTACT AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROLLER (NEAR BLOWER MOTOR) BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF VEHICLE, BELOW DASH) FUSE 36 CLIMATE CONTROL SWITCH DK BLU/LT GRN WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN FUSE 10 FUSE 2 GRN WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN ILLUMINATION LT (NEAR BREAKOUT TO CENTRAL JUNCTION BOX) (OR LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE MESSAGE CENTER NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/ORG WIRE SOLID STATE SOUND SYSTEMS SPEED CONTROL SERVO (IN RIGHT REAR OF ENGINE COMPARTMENT) SPEED CTRL SW GND TAN/ORG WIRE TEMP VIO WIRE WHT WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

15 16 41 69 86 DATA - DATA + A/C HPCS INPUT A/C WOT OUTPUT A/C CPS A/C COMPRESSOR CLUTCH SOLENOID (ON LEFT SIDE OF ENGINE COMPARTMENT) A/C PRESSURE CUTOFF SWITCH (NEAR A/C COMPRESSOR CLUTCH SOLENOID) A/C RELAY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF VEHICLE, BELOW DASH) CONTROL MODULE DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) FUSE 1 FUSE 35 GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES LT BLU WIRE LT BLU/ORG WIRE MED NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR BLOWER MOTOR (IN REAR OF CENTER CONSOLE) REAR BLOWER MOTOR RELAY (BEHIND RIGHT SIDE DASH) REAR BLOWER MOTOR RESISTOR (IN DASH CONSOLE) REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/ORG WIRE RED/YEL WIRE TAN/ORG WIRE VIO WIRE WHT WIRE YEL WIRE