Ford Explorer II (1994-2003) yel Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 REAR DEFROST SW IN ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM (INTERIOR LIGHTS CONTROL) BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DK BLU/ORG WIRE DOOR AJAR SIGNAL LIFTGATE WIPER PARK IN FUSE 10 FUSE 20 FUSE 25 FUSE 28 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN HOT IN ACC OR RUN IGNITION (START) IGNITION (ACC/RUN) DEFROST RELAY CTRL LIFTGATE AJAR SWITCH LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/ORG WIRE ORG/WHT WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/YEL WIRE POWER WINDOW SYSTEM REAR WIPER UP RELAY ILLUMINATION SIGNAL REAR WIPER DOWN RELAY REAR WIPER/WASHER SWITCH RED WIRE RED/BLK WIRE RUN WIRE TAN WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/ORG WIRE VIO/YEL WIRE WARNING SYSTEM WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/VIO WIRE WHT/YEL WIRE WINDOW MOTOR DOWN WINDOW SWITCH DOWN WIPER SPEED CTRL WIPER RUN/PARK RELAY CTRL AIR BAG TONE IN WIPER/WASHER SYSTEM (FRONT) WIPER/WASHER SYSTEM (REAR) WIPER/WASHER SYSTEM (REAR) WIPER/WASHER SYSTEM (FRONT) YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 POWER-BATTERY GROUND ISO BUS ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM WIPER/WASHER SYSTEM (FRONT) DK BLU/ORG WIRE FUSE 11 FUSE 20 FUSE 25 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN RUN OR START IGNITION (ACC/RUN) KEY IN IGNITION SW ILLUMINATION SIGNAL INSTRUMENT CLUSTER SYSTEM LIFTGATE AJAR SWITCH TRAILER TOW RELAY AIR BAG TONE IN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/ORG WIRE ORG/WHT WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/YEL WIRE POWER WINDOWS SYSTEM REAR WIPER/WASHER SWITCH MULTIFUNCTION SW SIGNAL RED WIRE RED/YEL WIRE TAN WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/ORG WIRE VIO/YEL WIRE WARNING SYSTEM WARNING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ANTI-THEFT SYSTEM WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/VIO WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM (FRONT) WIPER/WASHER SYSTEM (REAR) YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DVR UNLOCK 1/2 1/2 3/4 7/8 9/0 3 9 AJAR OUT INT LIGHTS 3/4 5/6 7/8 8 7 DRVR AJAR DOOR AJAR 9/0 999 140 EXTERIOR LIGHTS SYSTEM (BACKUP LAMPS) ALL LOCK/ BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DOOR AJAR REVERSE IN DOOR LOCKS SYSTEM EXTERIOR LIGHTS SYSTEM (PARKLAMP RELAY) FUSE 18 FUSE 20 FUSE 9 GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GRY WIRE GRY/RED WIRE HORN HORN SYSTEM (HORN RELAY) HOT AT ALL TIMES HOT IN RUN OR ACC INT LIGHTS ALL UNLOCK POWER RKE JUMPER GROUND KEYPAD ILL ISO BUS KEYPAD COM KEYPAD SWITCH ASSEMBLY LEFT FRONT DOOR AJAR SWITCH LEFT FRONT POWER DOOR LOCK SWITCH LEFT REAR DOOR AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE PARKLAMPS PNK PNK WIRE PNK WIRE PNK/LT GRN WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (LEFT REAR QUARTER PANEL) RIGHT FRONT DOOR AJAR SWITCH RIGHT FRONT POWER DOOR LOCK SWITCH RKE JUMPER IGNITION BPP SWITCH TAN/LT BLU WIRE UNLOCK LOCK WHT WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DVR UNLOCK 1 20 13 15 16 14 AJAR OUT INT LIGHTS 6 999 140 HORN SYSTEM (HORN RELAY) ALL LOCK/ ALL UNLOCK INT LIGHTS UNLK DOORS POWER GROUND BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) EXTERIOR LIGHTS SYSTEM (PARKLAMP RELAY) FUSE 11 FUSE 18 FUSE 9 GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GROUND KEYPAD COM GRY WIRE GRY/RED WIRE HORN DOOR AJAR REVERSE IN HOT AT ALL TIMES HOT IN RUN OR START IGNITION BPP SWITCH ISO BUS KEYPAD ILL KEYPAD IN KEYPAD IN KEYPAD IN KEYPAD SWITCH ASSEMBLY LEFT FRONT DOOR AJAR SWITCH LEFT FRONT DOOR LOCK ACTUATOR LEFT FRONT POWER DOOR LOCK SWITCH LEFT REAR DOOR AJAR SWITCH LF DOOR AJAR LR DOOR AJAR RR DOOR AJAR RF DOOR AJAR LOCK LOCK DOORS LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE ORG/ WIRE PARKLAMPS PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RIGHT FRONT DOOR AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH RIGHT FRONT DOOR LOCK ACTUATOR RIGHT FRONT POWER DOOR LOCK SWITCH UNLOCK WHT WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

1370 OHMS 1910 OHMS 249 OHMS 2670 OHMS 402 OHMS 634 OHMS 955 OHMS 956 OHMS AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (NEAR LEFT FENDER APRON) BLK WIRE BLK/WHT WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH) CIRCUIT BREAKER DK BLU WIRE DK GRN WIRE FRONT WASHER PUMP RELAY FUSE 12 FUSE 16 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE HI OFF HOT IN ACC OR RUN INT LO 401 OHMS INTERVAL DELAY WASH INPUT INTERVAL SWITCH LIFTGATE WIPER/WASHER SWITCH LT BLU WIRE LT BLU/ORG WIRE MULTI- FUNCTION SWITCH OFF ORG/ WIRE PARK PARK SENSE PNK WIRE PNK/YEL WIRE REAR WASHER CONTROL RELAY RED WIRE RELAY RUN WIRE RUN/PARK RELAY CTRL TAN/RED WIRE WASHER PUMP CTRL WASHER PUMP MOTOR (IN WASHER RESERVOIR) WASHER SWITCH WHT WIRE WHT/BLK WIRE WIPER WIPER HI-LO RELAY WIPER MOTOR WIPER SPEED CTRL WIPER SWITCH WIPER/WASHER INPUT WIPER/WASHER RETURN YEL WIRE YEL/WHT WIRE

41 69 86 A/C DEMAND SIGNAL A/C CLUTCH RELAY CTRL A/C CLUTCH RELAY OUTPUT A/C CLUTCH RELAY A/C CLUTCH SOLENOID (CENTER FRONT OF ENGINE COMPARTMENT) A/C HIGH PRESSURE SWITCH (AT FRONT CENTER OF ENGINE COMPARTMENT) AUXILIARY RELAY BOX 1 (RIGHT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN/YEL WIRE ENGINE CONTROLS SYSTEM FRONT HEATER BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) FUSE GRN/RED WIRE GRY WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN HOT IN RUN OR START LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PCM MODULE POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RUN WIRE VIO WIRE W/HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE WHT WIRE YEL WIRE YEL/BLK WIRE

AIR TEMP DR RESISTOR - IGNITION GROUND AIR TEMP DR RESISTOR WIPER AIR TEMP DR RESISTOR + BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DEFROST MAX FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE GRN/RED WIRE GRY/YEL WIRE HIGH MEDIUM HIGH BLOWER MOTOR SWITCH HOT IN ILLUMINATION INTERIOR LIGHTS SYSTEMS LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MAX DEFROST MEDIUM LOW MEDIUM LOW LOW MIX NORMAL FLOOR VENT OFF MODE SWITCH OFF OFF FLOOR VENT NORMAL MIX ORG/ WIRE ORG/BLK WIRE REAR FUNCTION SELECTOR SWITCH ASSEMBLY (W/HIGH SERIES CENTER CONSOLE) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RUN WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) TEMPERATURE CONTROL POTENTIOMETER VIO WIRE W/HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE

6 11 14 15 IGN BATTERY IGN IGN BLK WIRE BLK/PNK WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BEHIND CENTER OF DASH) FUSE 10 FUSE 20 FUSE 25 FUSE 28 GRY WIRE GRY/RED WIRE GRY/YEL WIRE HEAD OFF PARK HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR ACC HOT IN START INSTRUMENT CLUSTER KEY WARNING SWITCH LEFT FRONT DOOR AJAR SWITCH LEFT LIFTGATE AJAR SWITCH LEFT REAR DOOR AJAR SWITCH LIFTGATE WIPER DISABLE SWITCH LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE PARK LAMP RELAY (IN RELAY MODULE) PNK WIRE PNK/LT BLU WIRE RED WIRE RED/BLK WIRE RIGHT LIFTGATE AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH RIGHT FRONT DOOR AJAR SWITCH SEAT BELT IND SEAT BELT WARNING SWITCH (IN SEAT BELT BUCKLE) WHT WIRE WHT/BLK WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION (CKP) SENSOR (LOWER FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR DK BLU WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DLC BUS (-) DLC BUS (+) EGR INPUT TACHOMETER FUEL GAUGE EPROM POWER FUSE 11 FUSE 7 GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN OR START CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 19 IGNITION COIL (CENTER REAR OF ENGINE COMPT) IGNITION TRANSFORMER CAPACITOR (CENTER REAR OF ENGINE COMPARTMENT) INSTRUMENT CLUSTER MALFUNCTION INDICATOR LAMP (MIL) KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE ORG/BLK WIRE ORG/YEL WIRE OSS SENSOR PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

A/C RELAY A/C SYS A/C SYSTEM AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON REAR OF ENGINE) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL PRESSURE FUSE 21 FUSE 9 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES IDLE AIR CONTROL VALVE (TOP LEFT REAR OF ENGINE) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MASS AIRFLOW SENSOR (RIGHT SIDE OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SOLID STATE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED (TSS) SENSOR VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE