Ford Explorer II (1994-2003) wht Wiring diagrams

13 10 2 DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) 17 17 19 SENS LO SENS HI VS OUT A/C SYSTEM AIR CONDI- TIONING, ENGINE CONTROLS SYSTEMS ANTI-LOCK BRAKES SYSTEM AUTOMATIC TRANSMISSION BACK-UP LAMP SWITCH, DRL MODULE, REAR WINDOW DEFOG RELAY, PARKING AID MODULE BATTERY JUNCTION BOX BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CANISTER VENT SOLENOID CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) FUSE 27 DAY/NIGHT MIRROR DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DIMMER RELAY, INSTRUMENT CLUSTER DK BLU/YEL WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM (IGNITION) ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE LEFT OF THROTTLE BODY) FUSE 11 FUSE 19 FUSE 9 FUSE 6 GRY RED/ WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (HEADLAMP SWITCH) LT BLU WIRE LT BLU/ ORG WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (CHECK ENGINE) MASS AIR FLOW SENSOR (RIGHT SIDE OF ENG COMPT) MAXI FUSE 10 BATTERY JUNCTION BOX FUSE 13 MODULE O/D OFF INDICATOR LAMP (TCIL) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) (SOHC ONLY) PASSIVE ANTI-THEFT SYSTEM MODULE PCM POWER RELAY PCM POWER RELAY DIODE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (THROUGH FIREWALL) REAR AXLE SENSOR RED WIRE RED/LT GRN WIRE RED/PNK WIRE RUN WIRE SHIFT SOLENOID TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSTION SENSOR (ATTACHED TO THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (SOHC) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT DK GRN/ WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

360 OHMS 4.0L A/T ACCY DELAY RELAY ANTI-LOCK BRAKES BATTERY JUNCTION BOX BATTERY SAVER RELAY BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) COURTESY LAMPS (INTERIOR LIGHTS SYSTEM) DIGITAL TRANSMISSION RANGE SENSOR (DTR) DK GRN WIRE DK GRN/LT GRN WIRE DRIVER SEAT MODULE, RADIO, POWER ANTENNA MODULE ELECTRONIC SHIFT CONTROL MODULE (BEHIND CENTER OF DASH) ELECTRONIC SHIFT MOTOR TRANSFER CASE FUSE 20 FUSE 26 FUSE 28 FUSE 9 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN ACCY OR RUN INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (INSTRUMENT ILLUMINATION CIRCUIT) LIFTGATE WIPER/ WASHER SWITCH, MULTI-FUNCTION SWITCH LT (NEAR ELECTRONIC TRANSFER CASE) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE M/T MAGNETIC CLUTCH COIL MAXI FUSE 4 MAXI FUSE 6 MEMORY SEAT MODULE MODE MODULE (LEFT SIDE OF ENG COMPT) MOONROOF MOTOR OHMS OHMS ORG/ WIRE ORG/WHT WIRE PNK WIRE PNK/LT BLU WIRE POWER TOPS, POWER WINDOWS SYSTEMS POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENG COMPT) RADIO, REMOTE ANTI-THEFT PERSONALITY MODULE RANGE IND REAR SPEED SENSOR FRONT SPEED SENSOR RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT MOTOR SOLID STATE SPEEDO/ ODOMETER TAN WIRE TAN/YEL WIRE TORQUE ON DEMAND RELAY (BEHIND CENTER OF DASH) VIO/ORG WIRE VIO/YEL WIRE VSS OUT WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/WHT WIRE

360 OHMS 4.0L A/T ACCY DELAY RELAY ANTI-LOCK BRAKES BATTERY JUNCTION BOX BATTERY SAVER RELAY BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) COURTESY LAMPS (INTERIOR LIGHTS SYSTEM) DIGITAL TRANSMISSION RANGE SENSOR (DTR) DK GRN WIRE DK GRN/LT GRN WIRE DRIVER SEAT MODULE, RADIO, POWER ANTENNA MODULE ELECTRONIC SHIFT CONTROL MODULE (BEHIND CENTER OF DASH) ELECTRONIC SHIFT MOTOR TRANSFER CASE FUSE 20 FUSE 26 FUSE 28 FUSE 9 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN ACCY OR RUN INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (INSTRUMENT ILLUMINATION CIRCUIT) LIFTGATE WIPER/ WASHER SWITCH, MULTI-FUNCTION SWITCH LT (NEAR ELECTRONIC TRANSFER CASE) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE M/T MAGNETIC CLUTCH COIL MAXI FUSE 4 MAXI FUSE 6 MEMORY SEAT MODULE MODE MODULE (LEFT SIDE OF ENG COMPT) MOONROOF MOTOR OHMS OHMS ORG/ WIRE ORG/WHT WIRE PNK WIRE PNK/LT BLU WIRE POWER TOPS, POWER WINDOWS SYSTEMS POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENG COMPT) RADIO, REMOTE ANTI-THEFT PERSONALITY MODULE RANGE IND REAR SPEED SENSOR FRONT SPEED SENSOR RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT MOTOR SOLID STATE SPEEDO/ ODOMETER TAN WIRE TAN/YEL WIRE TORQUE ON DEMAND RELAY (BEHIND CENTER OF DASH) VIO/ORG WIRE VIO/YEL WIRE VSS OUT WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/WHT WIRE

13 10 2 DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) BACK-UP LAMPS, REAR WINDOW DEFROST RELAY, PARKING AID MODULE BATTERY JUNCTION BOX BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (BEHIND STEERING COLUMN) BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) DATA DLC (-) DLC (+) PWR GND CASE GND SSA TCS MAF TFT ECT MAF DK BLU/WHT WIRE DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENG CONTROLS, A/C RELAY, FUEL PUMP RLY FUEL INJECTORS FUSE 10 FUSE 13 FUSE 19 FUSE 27 FUSE 6 FUSE 9 GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MASS AIR FLOW SENSOR (RIGHT SIDE OF ENG COMPT) OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PASSIVE ANTI-THEFT MODULE PCM POWER DIODE PCM POWER RELAY PNK/ MALFUNCTION INDICATOR LAMP (MIL) (CHECK ENGINE) WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR AXLE SPEED SENSOR (ON AXLE ASSEMBLY) RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS (SS) SSA SSB TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (ATTACHED TO THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION CONTROL INDICATOR LAMP (TCIL) TRANSMISSION CONTROL SWITCH (TCS) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DVR UNLOCK 1/2 1/2 3/4 7/8 9/0 3 9 AJAR OUT INT LIGHTS 3/4 5/6 7/8 8 7 DRVR AJAR DOOR AJAR 9/0 999 140 EXTERIOR LIGHTS SYSTEM (BACKUP LAMPS) ALL LOCK/ BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DOOR AJAR REVERSE IN DOOR LOCKS SYSTEM EXTERIOR LIGHTS SYSTEM (PARKLAMP RELAY) FUSE 18 FUSE 20 FUSE 9 GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GRY WIRE GRY/RED WIRE HORN HORN SYSTEM (HORN RELAY) HOT AT ALL TIMES HOT IN RUN OR ACC INT LIGHTS ALL UNLOCK POWER RKE JUMPER GROUND KEYPAD ILL ISO BUS KEYPAD COM KEYPAD SWITCH ASSEMBLY LEFT FRONT DOOR AJAR SWITCH LEFT FRONT POWER DOOR LOCK SWITCH LEFT REAR DOOR AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE PARKLAMPS PNK PNK WIRE PNK WIRE PNK/LT GRN WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (LEFT REAR QUARTER PANEL) RIGHT FRONT DOOR AJAR SWITCH RIGHT FRONT POWER DOOR LOCK SWITCH RKE JUMPER IGNITION BPP SWITCH TAN/LT BLU WIRE UNLOCK LOCK WHT WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DVR UNLOCK 1 20 13 15 16 14 AJAR OUT INT LIGHTS 6 999 140 HORN SYSTEM (HORN RELAY) ALL LOCK/ ALL UNLOCK INT LIGHTS UNLK DOORS POWER GROUND BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) EXTERIOR LIGHTS SYSTEM (PARKLAMP RELAY) FUSE 11 FUSE 18 FUSE 9 GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GROUND KEYPAD COM GRY WIRE GRY/RED WIRE HORN DOOR AJAR REVERSE IN HOT AT ALL TIMES HOT IN RUN OR START IGNITION BPP SWITCH ISO BUS KEYPAD ILL KEYPAD IN KEYPAD IN KEYPAD IN KEYPAD SWITCH ASSEMBLY LEFT FRONT DOOR AJAR SWITCH LEFT FRONT DOOR LOCK ACTUATOR LEFT FRONT POWER DOOR LOCK SWITCH LEFT REAR DOOR AJAR SWITCH LF DOOR AJAR LR DOOR AJAR RR DOOR AJAR RF DOOR AJAR LOCK LOCK DOORS LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE ORG/ WIRE PARKLAMPS PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RIGHT FRONT DOOR AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH RIGHT FRONT DOOR LOCK ACTUATOR RIGHT FRONT POWER DOOR LOCK SWITCH UNLOCK WHT WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

1370 OHMS 1910 OHMS 249 OHMS 2670 OHMS 402 OHMS 634 OHMS 955 OHMS 956 OHMS AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (NEAR LEFT FENDER APRON) BLK WIRE BLK/WHT WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH) CIRCUIT BREAKER DK BLU WIRE DK GRN WIRE FRONT WASHER PUMP RELAY FUSE 12 FUSE 16 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE HI OFF HOT IN ACC OR RUN INT LO 401 OHMS INTERVAL DELAY WASH INPUT INTERVAL SWITCH LIFTGATE WIPER/WASHER SWITCH LT BLU WIRE LT BLU/ORG WIRE MULTI- FUNCTION SWITCH OFF ORG/ WIRE PARK PARK SENSE PNK WIRE PNK/YEL WIRE REAR WASHER CONTROL RELAY RED WIRE RELAY RUN WIRE RUN/PARK RELAY CTRL TAN/RED WIRE WASHER PUMP CTRL WASHER PUMP MOTOR (IN WASHER RESERVOIR) WASHER SWITCH WHT WIRE WHT/BLK WIRE WIPER WIPER HI-LO RELAY WIPER MOTOR WIPER SPEED CTRL WIPER SWITCH WIPER/WASHER INPUT WIPER/WASHER RETURN YEL WIRE YEL/WHT WIRE

41 69 86 A/C DEMAND SIGNAL A/C CLUTCH RELAY CTRL A/C CLUTCH RELAY OUTPUT A/C CLUTCH RELAY A/C CLUTCH SOLENOID (CENTER FRONT OF ENGINE COMPARTMENT) A/C HIGH PRESSURE SWITCH (AT FRONT CENTER OF ENGINE COMPARTMENT) AUXILIARY RELAY BOX 1 (RIGHT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN/YEL WIRE ENGINE CONTROLS SYSTEM FRONT HEATER BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) FUSE GRN/RED WIRE GRY WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN HOT IN RUN OR START LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PCM MODULE POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RUN WIRE VIO WIRE W/HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE WHT WIRE YEL WIRE YEL/BLK WIRE

21 20 12 19 (LATE PRODUCTION) 4 17 (LATE PRODUCTION) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (NEAR LEFT FENDER APRON) BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FRONT WASHER PUMP RELAY FRONT WIPER/WASHER CIRCUIT FUSE 12 FUSE 34 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRN WIRE HOT AT ALL TIMES HOT IN ACC OR RUN ILLUMINATION LATE PRODUCTION LEFT LIFTGATE AJAR SWITCH LIFTGATE DISABLE/AJAR LIFTGATE WIPER DISABLE SWITCH LIFTGATE WIPER MOTOR LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK/BLK WIRE REAR WASHER PUMP RELAY REAR WINDOW WIPER/ WASHER SWITCH REAR WIPER DOWN CONTROL REAR WIPER DOWN RELAY REAR WIPER PARK SENSE REAR WIPER UP CONTROL REAR WIPER UP RELAY RED WIRE RED/BLK WIRE RIGHT LIFTGATE AJAR SWITCH SIGNAL RETURN REAR WIPER MODE SELECT TAN WIRE VIO WIRE VIO/LT GRN WIRE VIO/YEL WIRE WASHER PUMP MOTOR (IN WASHER RESERVOIR) WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE

6 11 14 15 IGN BATTERY IGN IGN BLK WIRE BLK/PNK WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BEHIND CENTER OF DASH) FUSE 10 FUSE 20 FUSE 25 FUSE 28 GRY WIRE GRY/RED WIRE GRY/YEL WIRE HEAD OFF PARK HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR ACC HOT IN START INSTRUMENT CLUSTER KEY WARNING SWITCH LEFT FRONT DOOR AJAR SWITCH LEFT LIFTGATE AJAR SWITCH LEFT REAR DOOR AJAR SWITCH LIFTGATE WIPER DISABLE SWITCH LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE PARK LAMP RELAY (IN RELAY MODULE) PNK WIRE PNK/LT BLU WIRE RED WIRE RED/BLK WIRE RIGHT LIFTGATE AJAR SWITCH RIGHT REAR DOOR AJAR SWITCH RIGHT FRONT DOOR AJAR SWITCH SEAT BELT IND SEAT BELT WARNING SWITCH (IN SEAT BELT BUCKLE) WHT WIRE WHT/BLK WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE