Ford Explorer II (1994-2003) tan/lt blu Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 1 1 CURRENT SENSE LOW DOWN IN ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM DK BLU/ORG WIRE DK GRN/VIO WIRE DOOR LOCKS SYSTEM FUSE 10 FUSE 20 FUSE 25 FUSE 28 GENERIC ELECTRONIC MODULE ONLY GENERIC ELECTRONIC MODULE/ CENTRAL TIMER MODULE (BEHIND CENTER OF DASH) GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN HOT IN ACC OR RUN INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTS SYSTEM ANTI-LOCK BRAKES SYSTEM INTERIOR LIGHTS SYSTEM ENGINE CONTROLS SYSTEM LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE ORG/WHT WIRE ORG/YEL WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWER WINDOW SYSTEM RED WIRE RED/BLK WIRE RUN WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/ORG WIRE WARNING SYSTEM WHT WIRE WHT/BLK WIRE WHT/VIO WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM (FRONT) WIPER/WASHER SYSTEM (FRONT-REAR) YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 3 4 5 6 INDICATOR CONTROL 1000 OHMS 2200 OHMS 680 OHMS 120 OHMS A/T AIR BAG SLIDING CONTACT (IN STEERING COLUMN) BACK LIGHT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ABOVE BRAKE PEDAL) BRAKE PRESS INPUT GROUND BRAKE PRESSURE SWITCH (LEFT REAR CORNER OF ENGINE COMPT) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (ABOVE CLUTCH PEDAL) COAST DK GRN/ORG WIRE EARLY PRODUCTION FUSE FUSE 10 GRY WIRE GRY/BLK WIRE GRY/YEL WIRE HORN RELAY (IN BATTERY JUNCTION BOX) HORN SWITCHES HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LATE PRODUCTION LT BLU WIRE LT BLU/BLK WIRE LT GRN/RED WIRE M/T NCA WIRE OFF ORG/ WIRE ORG/LT BLU WIRE POWERTRAIN CONTROL MODULE (MOUNTED THROUGH FIREWALL) RED/ LT GRN (OR TAN/LT BLU) WIRE RED/ LT GRN WIRE RED/BLK WIRE RED/LT GRN WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BELOW CENTER OF REAR WINDOW) RESUME SET/ ACCEL SPEED CONT SW IN SPEED CONT SW GND IGNITION SPEED CONTROL SERVO (IN RIGHT REAR OF ENGINE COMPARTMENT) TAN/LT BLU WIRE VEHICLE SPEED INPUT BRAKE APPLIED IN YEL/ LT GRN WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE

AIR CONDITIONING AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT LEFT FENDER APRON) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU WIRE DK BLU/YEL WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EVR CTRL TACHOMETER FUEL LEVEL IN DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GEM GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL (ABOVE VALVE COVER) INSTRUMENT CLUSTER SYSTEM LT BLU/BLK WIRE LT GRN/RED WIRE MAF SIG RTN TRANS TEMP ECT SENS IAT SENS FUEL PUMP MON A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OSS + PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CASE GND IGN COIL SHIFT SOL A SHIFT SOL D TRANS CTRL SW PWR GND IGN COIL RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT GRN WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

"LOW RANGE" IND INPUT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE DIFFERENTIAL PRESSURE FEEDBACK EGR (DPFE) SENSOR (REAR OF ENGINE COMPT) DK BLU/YEL WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR (BEHIND GENERATOR BRACKET) FUEL PUMP FUEL PUMP RELAY FUEL TANK ASSEMBLY FUSE 9 GRY WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER LT BLU/BLK WIRE LT BLU/ORG WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR INPUT MESSAGE CENTER NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (LEFT REAR OF TRANSMISSION) PNK/BLK WIRE PNK/LT GRN WIRE PRESSURE TRANSDUCER FUEL TANK ASSEMBLY RED WIRE RED/LT GRN WIRE RED/PNK WIRE SENSOR TACH INPUT TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/YEL WIRE TCIL GROUND INPUT THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TO DTR SENSOR (DIAGRAM 4 OF 4) VIO/ORG WIRE WHT/BLK WIRE WHT/LT GRN WIRE YEL/BLK WIRE

BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE CANISTER VENT SOLENOID (ABOVE SPARE TIRE) DK GRN/WHT WIRE EGR VACUUM REGULATOR (EVR) SOLENOID (LEFT SIDE OF ENGINE) ELECTRONIC PRESSURE CONTROL SOLENOID EVAP CANISTER PURGE VALVE (LEFT FRONT CORNER OF ENGINE COMPT) FUEL INJECTORS GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (LEFT SIDE OF INTAKE MANIFOLD) LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS SSA SSD SSB SSC TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE

270 OHMS 4-WHEEL ANTI-LOCK BRAKE SYSTEM A/T AIR CONDITIONING SYSTEM (A/C PRESS SW) AIR CONDITIONING SYSTEM (A/C RELAY) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) FUSE 6 BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (REAR OF ENGINE) CAMSHAFT POSITION SENSOR SHIELD CAN VENT SOL CPP SWITCH DPFE SENS DK BLU/ORG WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 2 OF 4) FT PRESS SENS FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 13 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HEATER CTRL HOT AT ALL TIMES HOT AT ALL TIMES FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) FUSE 9 IAC SOL TSS CAM POS IN A/C PRESS LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MAF SENS IN TP SENS IN REF VOLT SIG RTN BPP SWITCH MASS AIRFLOW (MAF) SENSOR (RIGHT SIDE CORNER OF ENGINE COMPT) HEATED OXYGEN NCA WIRE ORG/ WIRE PNK/BLK WIRE PNK/YEL WIRE POWER POWER GND POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR AXLE SENSOR (ON AXLE ASSEMBLY) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR VSS WAC WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE

357 1017 360 11 1145 1143 570 96 (2000) AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION SENSOR (LOWER FRONT OF ENGINE COMPT) CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUEL FLOW RATE FUEL GUAGE SEND DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GEM CHK FUEL CAP EVR CTRL TACHOMETER GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL (ABOVE VALVE COVER) INSTRUMENT CLUSTER SYSTEM KNOCK SENS LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE MAF SIG RTN TFT SENS ECT SENS MAF SENS FUEL PUMP REL A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OSS + PCM POWER DIODE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CHASSIS GND IGN COIL SHIFT SOL A SHIFT SOL D TCS INPUT PWR GND IGN COIL RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

"LOW RANGE" INDICATOR BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE CHECK FUEL CAP INDICATOR MAL- FUNCTION INDICATOR TACH INPUT DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR (LEFT OF THROTTLE BODY) FUEL FLOW RATE INPUT FUEL PUMP FUEL PUMP RELAY FUEL TANK ASSEMBLY FUSE 9 GRY WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER KNOCK SENSOR (NEAR INTAKE MANIFOLD) LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT GRN/RED WIRE MESSAGE CENTER NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (LEFT REAR OF TRANSMISSION) PNK/BLK WIRE PNK/LT GRN WIRE PRESSURE TRANSDUCER FUEL TANK ASSEMBLY RED WIRE RED/LT BLU WIRE RED/PNK WIRE TACH INPUT TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/YEL WIRE TCIL GROUND INPUT VIO/ORG WIRE WHT/LT GRN WIRE YEL/RED WIRE

AIR CONDITIONING SYSTEM (A/C RELAY) BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE CANISTER VENT SOLENOID (ABOVE SPARE TIRE) DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID EVAP CANISTER PURGE VALVE (LEFT FRONT OF ENGINE COMPT) FUEL INJECTORS GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE REAR OF ENGINE COMPT) RED WIRE RED/LT BLU WIRE RED/PNK WIRE SHIFT SOLENOIDS SSA SSD SSB SSC TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/RED WIRE

1999, EARLY PRODUCTION 2000, 2001 270 OHMS 4-WHEEL ANTI-LOCK BRAKE SYSTEM AIR CONDITIONING SYSTEM (A/C PRESS SW) AIR CONDITIONING SYSTEM (A/C RELAY) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) FUSE 6 BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (REAR OF ENGINE) CAN VENT SOL DK BLU/ORG WIRE DK GRN/WHT WIRE DPFE SENS FROM DTR SENSOR (DIAGRAM 1 OF 4) FT PRESS SENS FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUSE 13 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) FUSE 9 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HEATED OXYGEN (LEFT RADIATOR SUPPORT) HEATER CTRL HOT AT ALL TIMES IAC SOL TSS CMP SENS A/C PRESS LATE PRODUCTION 2000, 2001 LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN REF VOLT SIG RTN BPP SWITCH MASS AIRFLOW (MAF) SENSOR (RIGHT SIDE OF ENGINE COMPT) NCA WIRE ORG/ WIRE PNK/BLK WIRE PNK/YEL WIRE POWER POWER GND POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR AXLE SENSOR (ON AXLE ASSEMBLY) RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR WAC WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE