Ford Explorer II (1994-2003) tan Wiring diagrams

360 OHMS 4.0L A/T ACCY DELAY RELAY ANTI-LOCK BRAKES BATTERY JUNCTION BOX BATTERY SAVER RELAY BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) COURTESY LAMPS (INTERIOR LIGHTS SYSTEM) DIGITAL TRANSMISSION RANGE SENSOR (DTR) DK GRN WIRE DK GRN/LT GRN WIRE DRIVER SEAT MODULE, RADIO, POWER ANTENNA MODULE ELECTRONIC SHIFT CONTROL MODULE (BEHIND CENTER OF DASH) ELECTRONIC SHIFT MOTOR TRANSFER CASE FUSE 20 FUSE 26 FUSE 28 FUSE 9 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN ACCY OR RUN INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (INSTRUMENT ILLUMINATION CIRCUIT) LIFTGATE WIPER/ WASHER SWITCH, MULTI-FUNCTION SWITCH LT (NEAR ELECTRONIC TRANSFER CASE) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE M/T MAGNETIC CLUTCH COIL MAXI FUSE 4 MAXI FUSE 6 MEMORY SEAT MODULE MODE MODULE (LEFT SIDE OF ENG COMPT) MOONROOF MOTOR OHMS OHMS ORG/ WIRE ORG/WHT WIRE PNK WIRE PNK/LT BLU WIRE POWER TOPS, POWER WINDOWS SYSTEMS POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENG COMPT) RADIO, REMOTE ANTI-THEFT PERSONALITY MODULE RANGE IND REAR SPEED SENSOR FRONT SPEED SENSOR RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT MOTOR SOLID STATE SPEEDO/ ODOMETER TAN WIRE TAN/YEL WIRE TORQUE ON DEMAND RELAY (BEHIND CENTER OF DASH) VIO/ORG WIRE VIO/YEL WIRE VSS OUT WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/WHT WIRE

360 OHMS 4.0L A/T ACCY DELAY RELAY ANTI-LOCK BRAKES BATTERY JUNCTION BOX BATTERY SAVER RELAY BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) COURTESY LAMPS (INTERIOR LIGHTS SYSTEM) DIGITAL TRANSMISSION RANGE SENSOR (DTR) DK GRN WIRE DK GRN/LT GRN WIRE DRIVER SEAT MODULE, RADIO, POWER ANTENNA MODULE ELECTRONIC SHIFT CONTROL MODULE (BEHIND CENTER OF DASH) ELECTRONIC SHIFT MOTOR TRANSFER CASE FUSE 20 FUSE 26 FUSE 28 FUSE 9 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN ACCY OR RUN INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (INSTRUMENT ILLUMINATION CIRCUIT) LIFTGATE WIPER/ WASHER SWITCH, MULTI-FUNCTION SWITCH LT (NEAR ELECTRONIC TRANSFER CASE) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE M/T MAGNETIC CLUTCH COIL MAXI FUSE 4 MAXI FUSE 6 MEMORY SEAT MODULE MODE MODULE (LEFT SIDE OF ENG COMPT) MOONROOF MOTOR OHMS OHMS ORG/ WIRE ORG/WHT WIRE PNK WIRE PNK/LT BLU WIRE POWER TOPS, POWER WINDOWS SYSTEMS POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENG COMPT) RADIO, REMOTE ANTI-THEFT PERSONALITY MODULE RANGE IND REAR SPEED SENSOR FRONT SPEED SENSOR RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT MOTOR SOLID STATE SPEEDO/ ODOMETER TAN WIRE TAN/YEL WIRE TORQUE ON DEMAND RELAY (BEHIND CENTER OF DASH) VIO/ORG WIRE VIO/YEL WIRE VSS OUT WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/WHT WIRE

13 10 2 DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) BACK-UP LAMPS, REAR WINDOW DEFROST RELAY, PARKING AID MODULE BATTERY JUNCTION BOX BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (BEHIND STEERING COLUMN) BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) DATA DLC (-) DLC (+) PWR GND CASE GND SSA TCS MAF TFT ECT MAF DK BLU/WHT WIRE DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENG CONTROLS, A/C RELAY, FUEL PUMP RLY FUEL INJECTORS FUSE 10 FUSE 13 FUSE 19 FUSE 27 FUSE 6 FUSE 9 GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MASS AIR FLOW SENSOR (RIGHT SIDE OF ENG COMPT) OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PASSIVE ANTI-THEFT MODULE PCM POWER DIODE PCM POWER RELAY PNK/ MALFUNCTION INDICATOR LAMP (MIL) (CHECK ENGINE) WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR AXLE SPEED SENSOR (ON AXLE ASSEMBLY) RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS (SS) SSA SSB TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (ATTACHED TO THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION CONTROL INDICATOR LAMP (TCIL) TRANSMISSION CONTROL SWITCH (TCS) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

AIR BAG SLIDING CONTACT CLOCK SPRING ANTI-THEFT SYSTEM ASHTRAY ILLUM- INATION BLK WIRE BRN WIRE CLOCK- SPRING COMPASS/OUTSIDE AIR TEMPERATURE MODULE DAY/NIGHT MIRROR/ AUTOLAMP SENSOR RELAY CTRL ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE FRONT PANEL ILLUMINATION FOG LAMP SWITCH LIFTGATE WIPER/ WASHER SWITCH FUNCTION SELECTOR SWITCH ASSEMBLY HEAD PARK HEADLAMP RELAY HEATED REAR WINDOW SWITCH HOT AT ALL TIMES BATTERY JUNCTION BOX FUSE 11 ILLUMINATION ILLUMINATION (2) INSTRUMENT CLUSTER LEFT FRONT POWER DOOR LOCK SWITCH LEFT FRONT POWER WINDOW SWITCH MAIN LIGHT SWITCH MODE SWITCH NCA WIRE OFF PARK LAMP RELAY PARKING AID DISABLE SWITCH PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RELAY MODULE (BEHIND CENTER OF DASH) RIGHT FRONT POWER DOOR LOCK SWITCH RIGHT FRONT POWER WINDOW SWITCH TAN WIRE TAN/WHT WIRE W/O EATC W/O HIGH SERIES CONSOLE WHT WIRE WHT/PPL WIRE

4 WHEEL ANTI- LOCK BRAKE SYSTEM MODULE A/C RELAY AIR SUSPENSION SWITCH AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLOWER MOTOR RELAY DAYTIME RUNNING LAMPS MODULE DK BLU WIRE DK GRN WIRE FOG LAMP RELAY AIR SUSPENSION CONTROL RELAY FROM FUSE 1 (DIAGRAM 1 OF 5) FROM FUSE 12 (DIAGRAM 1 OF 5) FUEL PUMP RELAY FUSE 1 FUSE 10 FUSE 11 MAXI FUSE 4 FUSE 14 FUSE 3 FUSE 12 FUSE 4 MAXI FUSE 9 FUSE 5 (NOT USED) FUSE 6 FUSE 7 FUSE 8 REAR WIPER UP RELAY FUSE 9 GENERATOR HEADLAMP RELAY HEADLAMP RELAY ACCY DELAY RELAY LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH DIMMER RELAY MAXI FUSE 2 MAXI FUSE 3 HORN RELAY MAXI FUSE 6 MAXI FUSE 8 MEGA FUSE MOONROOF MOTOR ELECTRIC SHIFT CONTROL MODULE MULTI- FUNCTION SWITCH ORG/ WIRE PARK LAMP RELAY PNK WIRE POWERTRAIN CONTROL MODULE PPL PPL PPL REAR WINDOW DEFROST RELAY MAIN LIGHT SWITCH REAR WIPER DOWN RELAY RED WIRE RELAY MODULE (BEHIND CENTER OF DASH) REMOTE ANTI-THEFT PERSONALITY MODULE STARTER MOTOR TAN WIRE TO FUSE 10 (DIAGRAM 1 OF 5) TO FUSE 5 (DIAGRAM 2 OF 5) TO FUSE 9 (DIAGRAM 1 OF 5) WHT WIRE YEL WIRE

4.0L SOHC V6 4.0L OHV V6 5.0L V8 BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE CANISTER VENT SOLENOID EGR VACUUM REGULATOR SOLENOID EVAP CANISTER PURGE VALVE FROM FUSE 8 (DIAGRAM 1 OF 4) FROM PCM POWER RELAY (4.0L EI V6) (DIAGRAM 2 OF 5) FROM PCM POWER RELAY (4.0L SOHC V6) (DIAGRAM 2 OF 5) FROM PCM POWER RELAY (5.0L V8) (DIAGRAM 2 OF 5) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 5 FUEL INJECTOR 4 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 FUEL PUMP RELAY A/C RELAY FUSE 13 HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HEATED OXYGEN SENSOR 22 IDLE AIR CONTROL VALVE IDLE AIR CONTROL VALVE MASS AIRFLOW SENSOR LT BLU/ ORG WIRE LT BLU/ORG WIRE MASS AIRFLOW SENSOR MASS AIRFLOW SENSOR IDLE AIR CONTROL VALVE MAXI FUSE 1 MAXI FUSE 10 MAXI FUSE 5 NCA WIRE PCM POWER RELAY POWER- TRAIN CONTROL MODULE (4.0L OHV) POWER- TRAIN CONTROL MODULE (4.0L SOHC) POWER- TRAIN CONTROL MODULE (5.0L V8) REAR OF ENGINE COMPT) RED WIRE STARTER MOTOR RELAY TAN WIRE TO FUEL INJECTORS (DIAGRAM 2 OF 5) TO FUSE 9 (DIAGRAM 3 OF 5) TO IGNITION SWITCH (DIAGRAM 3 OF 5) TO PCM POWER DIODE (DIAGRAM 3 OF 5) TRANS- MISSION TRANSMISSION W/ A/T W/ A/T WHT WIRE YEL WIRE

4 WHEEL ANTI- LOCK BRAKE SYSTEM MODULE AIR SUSPENSION CONTROL MODULE SPEED CONTROL SERVO AUXILIARY POWER AUXILIARY RELAY BOX 2 (LEFT REAR OF VEHICLE, ABOVE WHEELWELL) BATTERY SAVER RELAY BLEND DOOR ACTUATOR BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR RELAY BRN WIRE CENTRAL JUNCTION BOX COMPASS/ OUTSIDE AIR TEMPERATURE MODULE DK GRN WIRE DRIVER SEAT MODULE DAY/ NIGHT MIRROR/ AUTOLAMP SENSOR FROM FUSE 18 (DIAGRAM 3 OF 5) FROM IGNITION FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 14 FUSE 2 FUSE 22 FUSE 26 FUSE 30 FUSE 35 FUSE 36 FUSE 6 GENERIC ELECTRONIC MODULE GRY WIRE GRY/YEL WIRE LEFT FRONT HEATED SEAT MODULE LEFT FRONT HEATED SEAT SWITCH LT BLU WIRE LT GRN WIRE MESSAGE CENTER NCA WIRE ORG/ WIRE PNK WIRE REAR BLOWER MOTOR REAR BLOWER MOTOR RELAY REAR BLOWER RELAY RELAY MODULE (CENTER OF DASH) RESTRAINTS CONTROL MODULE RIGHT FRONT HEATED SEAT MODULE RIGHT FRONT HEATED SEAT SWITCH SHIFT LOCK ACTUATOR STEERING RATE SENSOR TAN WIRE TAN/BLK WIRE TRAILER TOW PARK LAMP RELAY TURN/ HAZARD FLASHER W/ EATC W/ MEMORY SEAT W/O EATC W/O MEMORY SEAT WHT WIRE YEL WIRE

AUXILIARY RELAY BOX (LEFT SIDE OF REAR CARGO AREA) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/PNK WIRE BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK GRN/WHT WIRE DN UP DN UP LEFT FRONT WINDOW FUSE 12 FUSE 20 FUSE 3 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRY WIRE HOT AT ALL TIMES HOT IN RUN OR ACC LATE PRODUCTION LEFT FRONT POWER WINDOW MOTOR LEFT REAR POWER WINDOW MOTOR LEFT REAR WINDOW LEFT REAR WINDOW ADJUST SWITCH LOCK LT BLU WIRE LT GRN WIRE MASTER WINDOW ADJUST SWITCH ONE-TOUCH WINDOW RELAY OPEN CLOSE ORG/ WIRE PNK WIRE REAR WINDOW ADJUST SWITCH REAR WINDOW MOTOR RED WIRE RIGHT FRONT POWER WINDOW MOTOR RIGHT FRONT WINDOW RIGHT FRONT WINDOW ADJUST SWITCH RIGHT REAR POWER WINDOW MOTOR RIGHT REAR WINDOW ADJUST SWITCH SOLID STATE TAN WIRE TAN/LT BLU WIRE UP RIGHT REAR WINDOW VENT VIO WIRE WHT WIRE WHT/BLK WIRE WINDOW SAFETY RELAY YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION ANTENNA ANTI-LOCK BRAKES SYSTEM AUDIO ON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B AUDIO SYTEM ON POWER BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CD CHANGER CD PLAYER SHIELD CD RIGHT SIG IN CD RIGHT SIG OUT CD LEFT SIG IN CD LEFT SIG OUT DK GRN/ORG WIRE FUSE 20 FUSE 28 FUSE 29 FUSE 34 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GROUND GROUND GROUND ILLUM AMP R REAR (+) AMP L REAR (+) GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LIGHTS LEFT FRONT SPEAKER LEFT SIG (-) LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE POWER PROTOCOL A PROTOCOL A PROTOCOL B PROTOCOL B RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER LEFT REAR SPEAKER RIGHT REAR SPEAKER RIGHT SIG SHIELD TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VEHICLE SPEED SIG VIO WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION 1 2 3 4 5 6 7 8 SUBWOOFER (-) SUBWOOFER (+) AUDIO SHIELD HIGH AUDIO MUTE 1068 797 AUDIO SYTEM ON POWER 235 57 1000 INTERIOR LIGHTS 694 57 235 825 827 GROUND GROUND ILLUM AMP R REAR (+) AMP L REAR (+) 832 833 PROTOCOL A PROTOCOL B AIR BAG SLIDING CONTACT ANTI-LOCK BRAKES SYSTEM AUDIO ON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B AUDIO/ CLIMATE CONTROL SWITCH ASSEMBLY BAND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CD CHANGER CD PLAYER SHIELD CD RIGHT SIG IN CD RIGHT SIG OUT CD LEFT SIG IN CD LEFT SIG OUT DK GRN/ORG WIRE DK GRN/VIO WIRE DOWN FUSE 1 FUSE 20 FUSE 28 FUSE 29 FUSE 34 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) FUSED IGNITION POWER ANTENNA LOGIC GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HIGH AUDIO MUTE GROUND HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LIGHTS LEFT FRONT SPEAKER LEFT REAR SPEAKER RIGHT FRONT SPEAKER LEFT SIG (-) LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MEM MIRRORS SYSTEM NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/RED WIRE POWER POWER ANTENNA POWER ANTENNA MODULE (ON ANTENNA MAST) POWER SUBWOOFER (+) SUBWOOFER (-) PROTOCOL A PROTOCOL B RADIO RADIO CONTROL REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT REAR SPEAKER RIGHT SIG SHIELD SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) SUB SPEAKER (-) SUBWOOFER SUBWOOFER AMPLIFIER TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VEHICLE SPEED SIG VIO WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE