Ford Explorer II (1994-2003) solid state Wiring diagrams

360 OHMS 4.0L A/T ACCY DELAY RELAY ANTI-LOCK BRAKES BATTERY JUNCTION BOX BATTERY SAVER RELAY BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) COURTESY LAMPS (INTERIOR LIGHTS SYSTEM) DIGITAL TRANSMISSION RANGE SENSOR (DTR) DK GRN WIRE DK GRN/LT GRN WIRE DRIVER SEAT MODULE, RADIO, POWER ANTENNA MODULE ELECTRONIC SHIFT CONTROL MODULE (BEHIND CENTER OF DASH) ELECTRONIC SHIFT MOTOR TRANSFER CASE FUSE 20 FUSE 26 FUSE 28 FUSE 9 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN ACCY OR RUN INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (INSTRUMENT ILLUMINATION CIRCUIT) LIFTGATE WIPER/ WASHER SWITCH, MULTI-FUNCTION SWITCH LT (NEAR ELECTRONIC TRANSFER CASE) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE M/T MAGNETIC CLUTCH COIL MAXI FUSE 4 MAXI FUSE 6 MEMORY SEAT MODULE MODE MODULE (LEFT SIDE OF ENG COMPT) MOONROOF MOTOR OHMS OHMS ORG/ WIRE ORG/WHT WIRE PNK WIRE PNK/LT BLU WIRE POWER TOPS, POWER WINDOWS SYSTEMS POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENG COMPT) RADIO, REMOTE ANTI-THEFT PERSONALITY MODULE RANGE IND REAR SPEED SENSOR FRONT SPEED SENSOR RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT MOTOR SOLID STATE SPEEDO/ ODOMETER TAN WIRE TAN/YEL WIRE TORQUE ON DEMAND RELAY (BEHIND CENTER OF DASH) VIO/ORG WIRE VIO/YEL WIRE VSS OUT WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/WHT WIRE

360 OHMS 4.0L A/T ACCY DELAY RELAY ANTI-LOCK BRAKES BATTERY JUNCTION BOX BATTERY SAVER RELAY BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) COURTESY LAMPS (INTERIOR LIGHTS SYSTEM) DIGITAL TRANSMISSION RANGE SENSOR (DTR) DK GRN WIRE DK GRN/LT GRN WIRE DRIVER SEAT MODULE, RADIO, POWER ANTENNA MODULE ELECTRONIC SHIFT CONTROL MODULE (BEHIND CENTER OF DASH) ELECTRONIC SHIFT MOTOR TRANSFER CASE FUSE 20 FUSE 26 FUSE 28 FUSE 9 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN ACCY OR RUN INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (INSTRUMENT ILLUMINATION CIRCUIT) LIFTGATE WIPER/ WASHER SWITCH, MULTI-FUNCTION SWITCH LT (NEAR ELECTRONIC TRANSFER CASE) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE M/T MAGNETIC CLUTCH COIL MAXI FUSE 4 MAXI FUSE 6 MEMORY SEAT MODULE MODE MODULE (LEFT SIDE OF ENG COMPT) MOONROOF MOTOR OHMS OHMS ORG/ WIRE ORG/WHT WIRE PNK WIRE PNK/LT BLU WIRE POWER TOPS, POWER WINDOWS SYSTEMS POWERTRAIN CONTROL MODULE (RIGHT SIDE OF ENG COMPT) RADIO, REMOTE ANTI-THEFT PERSONALITY MODULE RANGE IND REAR SPEED SENSOR FRONT SPEED SENSOR RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SHIFT MOTOR SOLID STATE SPEEDO/ ODOMETER TAN WIRE TAN/YEL WIRE TORQUE ON DEMAND RELAY (BEHIND CENTER OF DASH) VIO/ORG WIRE VIO/YEL WIRE VSS OUT WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 15 16 17 18 19 20 DATA (-) BATTERY GROUND INPUT GROUND 130 OHMS 226 OHMS 2940 OHMS CRUISE CONTROL 422 OHMS 931 OHMS AIR BAG SLIDING CONTACT AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROLLER (NEAR BLOWER MOTOR) BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF VEHICLE, BELOW DASH) FUSE 36 CLIMATE CONTROL SWITCH DK BLU/LT GRN WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN FUSE 10 FUSE 2 GRN WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN ILLUMINATION LT (NEAR BREAKOUT TO CENTRAL JUNCTION BOX) (OR LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE MESSAGE CENTER NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/ORG WIRE SOLID STATE SOUND SYSTEMS SPEED CONTROL SERVO (IN RIGHT REAR OF ENGINE COMPARTMENT) SPEED CTRL SW GND TAN/ORG WIRE TEMP VIO WIRE WHT WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE CENTRAL JUNCTION BOX COURTESY LAMPS CIRCUIT DIMMER MODULE (LEFT SIDE OF STEERING COLUMN) DIMMER RELAY DIMMING INDICATORS (POWER) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE FUSE 11 FUSE 26 HEADLAMP RELAY HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT EXTERIOR REAR VIEW MIRROR LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE MAIN LIGHT SWITCH MESSAGE CENTER INSTRUMENT ILLUMINATION MESSAGE CENTER SWITCH ASSEMBLY NCA WIRE NORM OFF ON OFF NORM ORG/ WIRE PARK OFF HEAD PNK WIRE PPL RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY MODULE (BEHIND CENTER OF DASH) RIGHT EXTERIOR REAR VIEW MIRROR SOLID STATE TAN/WHT WIRE TAN/YEL WIRE W/ HIGH SERIES CONSOLE ONLY WHT WIRE WHT/PPL WIRE

.25 OHMS +/- 10% .8 OHMS +/- 10% 2.7 OHMS +/- 10% BLOWER MOTOR RESISTOR (NEAR BLOWER MOTOR) 5.0L A/C COMPRESSOR CLUTCH SOLENOID (LEFT FRONT SIDE OF ENGINE COMPARTMENT) A/C PRESSURE CUTOFF SWITCH (NEAR BREAKOUT TO A/C COMPRESSOR CLUTCH SOLENOID) A/C RELAY (MOUNTED IN BATTERY JUNCTION BOX) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) FUSE 1 BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR RELAY (IN BATTERY JUNCTION BOX) BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 2 FUSE 6 GRN WIRE GRY WIRE HIGH MH ML HIGH SPEED BLOWER RELAY (IN AUXILIARY RELAY BOX 1) HOT AT ALL TIMES HOT IN RUN ILLUMI- NATION LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MED MODE SELECTOR SWITCHES NCA WIRE OFF OFF PANEL PANEL/FLOOR NORM A/C FLOOR MAX A/C DEF/FLR DEFROST ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PANEL/FLOOR PANEL FLOOR NORM A/C DEF/FLR MAX A/C DEFROST PCM POWER RELAY (MOUNTED IN BATTERY JUNCTION BOX AT RIGHT FENDER APRON) PNK PNK WIRE PNK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR BLOWER MOTOR (IN REAR OF CENTER CONSOLE) REAR BLOWER MOTOR RESISTOR (IN CENTER CONSOLE) REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/ORG WIRE RED/YEL WIRE SOLID STATE SUPPLEMENTAL RESTRAINTS SYSTEM TEMPERATURE CONTROL POTENTIOMETER VIO WIRE WARM COLD WHT WIRE YEL WIRE YEL/RED WIRE

BLK WIRE HOT AT ALL TIMES FUSE 1 HOT AT ALL TIMES FUSE 28 JUNCTION FUSE PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) LT BLU WIRE LT GRN WIRE MIRRORS SYSTEM NCA WIRE ORG/ WIRE POWER ANTENNA MODULE/MOTOR (RIGHT FRONT OF VEHICLE) PPL (OR RADIO RED WIRE SOLID STATE YEL WIRE

AUXILIARY RELAY BOX (LEFT SIDE OF REAR CARGO AREA) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/PNK WIRE BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK GRN/WHT WIRE DN UP DN UP LEFT FRONT WINDOW FUSE 12 FUSE 20 FUSE 3 GENERIC ELECTRONIC MODULE (BEHIND CENTER OF DASH) GRY WIRE HOT AT ALL TIMES HOT IN RUN OR ACC LATE PRODUCTION LEFT FRONT POWER WINDOW MOTOR LEFT REAR POWER WINDOW MOTOR LEFT REAR WINDOW LEFT REAR WINDOW ADJUST SWITCH LOCK LT BLU WIRE LT GRN WIRE MASTER WINDOW ADJUST SWITCH ONE-TOUCH WINDOW RELAY OPEN CLOSE ORG/ WIRE PNK WIRE REAR WINDOW ADJUST SWITCH REAR WINDOW MOTOR RED WIRE RIGHT FRONT POWER WINDOW MOTOR RIGHT FRONT WINDOW RIGHT FRONT WINDOW ADJUST SWITCH RIGHT REAR POWER WINDOW MOTOR RIGHT REAR WINDOW ADJUST SWITCH SOLID STATE TAN WIRE TAN/LT BLU WIRE UP RIGHT REAR WINDOW VENT VIO WIRE WHT WIRE WHT/BLK WIRE WINDOW SAFETY RELAY YEL WIRE YEL/RED WIRE

BLK WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 210 FUSE 29 GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN RED/LT GRN WIRE SHIFT LOCK ACTUATOR (IN STEERING COLUMN) SOLID STATE YEL WIRE

A/C RELAY A/C SYS A/C SYSTEM AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPARTMENT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON REAR OF ENGINE) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/ORG WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL PRESSURE FUSE 21 FUSE 9 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES IDLE AIR CONTROL VALVE (TOP LEFT REAR OF ENGINE) LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MASS AIRFLOW SENSOR (RIGHT SIDE OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SOLID STATE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED (TSS) SENSOR VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE

A/C SYS A/C SYSTEM AUTOMATIC TRANSMISSION BATTERY JUNCTION BOX (LEFT REAR OF ENGINE COMPARTMENT) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (BPP) BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON REAR OF ENGINE) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CRUISE CONTRL, INSTRUMENT CLUSTER SYSTEMS DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 FUEL PRESSURE FUSE 21 FUSE 9 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HOT AT ALL TIMES IDLE AIR CONTROL VALVE (ON LEFT OF INTAKE MANIFOLD) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MASS AIRFLOW SENSOR (RIGHT SIDE OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SHIFT SOLENOIDS SOLID STATE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR TURBINE SHAFT SPEED (TSS) SENSOR VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE