Ford Explorer II (1994-2003) org/red Wiring diagrams

15 16 41 69 86 DATA - DATA + A/C HPCS INPUT A/C WOT OUTPUT A/C CPS A/C COMPRESSOR CLUTCH SOLENOID (ON LEFT SIDE OF ENGINE COMPARTMENT) A/C PRESSURE CUTOFF SWITCH (NEAR A/C COMPRESSOR CLUTCH SOLENOID) A/C RELAY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF VEHICLE, BELOW DASH) CONTROL MODULE DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) FUSE 1 FUSE 35 GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES LT BLU WIRE LT BLU/ORG WIRE MED NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR BLOWER MOTOR (IN REAR OF CENTER CONSOLE) REAR BLOWER MOTOR RELAY (BEHIND RIGHT SIDE DASH) REAR BLOWER MOTOR RESISTOR (IN DASH CONSOLE) REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/ORG WIRE RED/YEL WIRE TAN/ORG WIRE VIO WIRE WHT WIRE YEL WIRE

21 22 23 24 25 26 AIR SUS ON/OFF SW STEERING SENSOR 27 28 29 30 31 32 REAR GATE SOL 4-WHEEL ANTI- AIR SUSPENSION CONTROL COMPRESSOR ASSEMBLY (AT REAR OF VEHICLE) AIR SUSPENSION CONTROL MODULE (LEFT CENTER OF DASH) AIR SUSPENSION CONTROL RELAY AIR SUSPENSION SWITCH (REAR OF VEHICLE) ARC ACCEL SIG AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (LEFT SIDE OF DASH) DK BLU/YEL WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUSE 8 FUSE 9 GROUND GRY WIRE GRY/BLK WIRE GRY/YEL WIRE HOT AT ALL TIMES ISO LINK VENT SOL OUTPUT PNK WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE NCA WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR FILL SOLENOID AIR SUS CONTROL RED WIRE RED/LT GRN WIRE STEERING RATE SENSOR (IN STEERING COLUMN) SUPPORT) SYSTEM MODULE (LEFT SIDE OF ENGINE COMPT) VIO/ORG WIRE WARNING SIGNAL WHT/ BLK WIRE

BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND STEERING COLUMN) BRN WIRE DK GRN/LT GRN WIRE FUSE 9 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GRY/YEL WIRE HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN RED/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK/WHT WIRE REAR FILL SOLENOID (ON REAR AXLE) REAR GATE SOLENOID (LEFT REAR CORNER OF VEHICLE) REAR HEIGHT SENSOR (LEFT REAR CORNER OF VEHICLE) RED/LT GRN WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (LEFT REAR QUARTER PANEL) RUN WIRE

.25 OHMS +/- 10% .8 OHMS +/- 10% 2.7 OHMS +/- 10% BLOWER MOTOR RESISTOR (NEAR BLOWER MOTOR) 5.0L A/C COMPRESSOR CLUTCH SOLENOID (LEFT FRONT SIDE OF ENGINE COMPARTMENT) A/C PRESSURE CUTOFF SWITCH (NEAR BREAKOUT TO A/C COMPRESSOR CLUTCH SOLENOID) A/C RELAY (MOUNTED IN BATTERY JUNCTION BOX) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) FUSE 1 BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR RELAY (IN BATTERY JUNCTION BOX) BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 2 FUSE 6 GRN WIRE GRY WIRE HIGH MH ML HIGH SPEED BLOWER RELAY (IN AUXILIARY RELAY BOX 1) HOT AT ALL TIMES HOT IN RUN ILLUMI- NATION LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MED MODE SELECTOR SWITCHES NCA WIRE OFF OFF PANEL PANEL/FLOOR NORM A/C FLOOR MAX A/C DEF/FLR DEFROST ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PANEL/FLOOR PANEL FLOOR NORM A/C DEF/FLR MAX A/C DEFROST PCM POWER RELAY (MOUNTED IN BATTERY JUNCTION BOX AT RIGHT FENDER APRON) PNK PNK WIRE PNK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR BLOWER MOTOR (IN REAR OF CENTER CONSOLE) REAR BLOWER MOTOR RESISTOR (IN CENTER CONSOLE) REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/ORG WIRE RED/YEL WIRE SOLID STATE SUPPLEMENTAL RESTRAINTS SYSTEM TEMPERATURE CONTROL POTENTIOMETER VIO WIRE WARM COLD WHT WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 SEAT POSITION SENSOR (+) 1 2 POWER GND BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 36 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) DRIVER SEAT MODULE (DSM) (BELOW LEFT FRONT SEAT) ENTIRE SEAT FRONT HEIGHT MOTOR HALL EFFECT SENSOR FRONT OF SEAT FUSE 1 FUSE 18 FUSE 28 FWD/ RWD MOTOR GRN WIRE HALL EFFECT SENSOR HEADLIGHTS, POWER MIRRORS SYSTEMS HOT AT ALL TIMES HOT IN IGNITION ISO LINK LEFT FRONT POWER SEAT CONTROL SWITCH LEFT FRONT SEAT MOTOR ASSEMBLY LEFT POWER LUMBAR SEAT SWITCH LOGIC GND LOGIC POWER LAMP DRIVE LT BLU WIRE LT BLU YEL/ WIRE LT BLU/WHT WIRE LT GRN RED/ WIRE LT GRN WIRE LT GRN YEL/ WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MEM 1 MEM 2 MEMORY SEAT SW POSIT 2 MEMORY SEAT SW POSIT 1 MEMORY SEAT SW SET MEMORY SEAT SWITCH NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE ORG/WHT WIRE POWER ANTENNA SYSTEM REAR HEIGHT MOTOR REAR OF SEAT REAR TILT MTR UP HORIZ MTR REAR TILT SENSE FRONT TILT SENSE HORIZ SENSE FRONT TILT MTR UP RED WIRE RED/ LT BLU WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (AT LEFT REAR QUARTER PANEL) RWD SET- WHT RED/ WIRE WHT WIRE WHT YEL/ WIRE WHT/ORG WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUMINATION GROUND FUSED IGNITION 1 2 3 4 5 6 7 8 9 10 HIGH MUTE GRD 1 2 3 4 5 6 7 8 RX SIG TX SIG GRD HIGH MUTE ANTENNA AUDIO SYS ON ACP A ACP B B+ TX SIG RX SIG BLK WIRE BLK/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK GRN/ORG WIRE DK GRN/VIO WIRE FUSE 20 FUSE 28 FUSE 29 FUSE 34 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC LEFT FRONT SPEAKER LEFT REAR SPEAKER RIGHT REAR SPEAKER LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE RADIO REAR INTEGRATED CONTROL PANEL (REAR OF CENTER CONSOLE) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER SPORT SUBWOOFER AMPLIFIER (SPORT) (RIGHT REAR OF VEHICLE, ATTACHED TO SIDE WALL) TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE W/ HIGH SERIES CENTER CONSOLE W/0 HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUMINATION GROUND FUSED IGNITION 1 2 3 4 5 6 7 8 9 10 HIGH MUTE GRD 1 2 3 4 5 6 7 8 RX SIG TX SIG GRD HIGH MUTE ANTENNA AUDIO SYS ON ACP A ACP B B+ TX SIG RX SIG BLK WIRE BLK/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK GRN/ORG WIRE DK GRN/VIO WIRE FUSE 20 FUSE 28 FUSE 29 FUSE 34 FUSE 4 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE RADIO REAR INTEGRATED CONTROL PANEL (REAR OF CENTER CONSOLE) RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER SPORT SUBWOOFER AMPLIFIER (SPORT) (RIGHT REAR OF VEHICLE, ATTACHED TO SIDE WALL) TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VIO/LT BLU WIRE W/ HIGH SERIES CENTER CONSOLE W/0 HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION ANTENNA ANTI-LOCK BRAKES SYSTEM AUDIO ON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B AUDIO SYTEM ON POWER BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CD CHANGER CD PLAYER SHIELD CD RIGHT SIG IN CD RIGHT SIG OUT CD LEFT SIG IN CD LEFT SIG OUT DK GRN/ORG WIRE FUSE 20 FUSE 28 FUSE 29 FUSE 34 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GROUND GROUND GROUND ILLUM AMP R REAR (+) AMP L REAR (+) GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LIGHTS LEFT FRONT SPEAKER LEFT SIG (-) LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE POWER PROTOCOL A PROTOCOL A PROTOCOL B PROTOCOL B RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER LEFT REAR SPEAKER RIGHT REAR SPEAKER RIGHT SIG SHIELD TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VEHICLE SPEED SIG VIO WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION 1 2 3 4 5 6 7 8 SUBWOOFER (-) SUBWOOFER (+) AUDIO SHIELD HIGH AUDIO MUTE 1068 797 AUDIO SYTEM ON POWER 235 57 1000 INTERIOR LIGHTS 694 57 235 825 827 GROUND GROUND ILLUM AMP R REAR (+) AMP L REAR (+) 832 833 PROTOCOL A PROTOCOL B AIR BAG SLIDING CONTACT ANTI-LOCK BRAKES SYSTEM AUDIO ON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B AUDIO/ CLIMATE CONTROL SWITCH ASSEMBLY BAND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CD CHANGER CD PLAYER SHIELD CD RIGHT SIG IN CD RIGHT SIG OUT CD LEFT SIG IN CD LEFT SIG OUT DK GRN/ORG WIRE DK GRN/VIO WIRE DOWN FUSE 1 FUSE 20 FUSE 28 FUSE 29 FUSE 34 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) FUSED IGNITION POWER ANTENNA LOGIC GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HIGH AUDIO MUTE GROUND HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LIGHTS LEFT FRONT SPEAKER LEFT REAR SPEAKER RIGHT FRONT SPEAKER LEFT SIG (-) LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MEM MIRRORS SYSTEM NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/RED WIRE POWER POWER ANTENNA POWER ANTENNA MODULE (ON ANTENNA MAST) POWER SUBWOOFER (+) SUBWOOFER (-) PROTOCOL A PROTOCOL B RADIO RADIO CONTROL REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT REAR SPEAKER RIGHT SIG SHIELD SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) SUB SPEAKER (-) SUBWOOFER SUBWOOFER AMPLIFIER TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VEHICLE SPEED SIG VIO WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION ANTENNA ANTI-LOCK BRAKES BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE DK GRN/ORG WIRE FUSE 20 FUSE 29 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) FUSE 28 GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU/WHT WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER TAN/YEL WIRE VEHICLE SPEED VIO WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE