Ford Explorer II (1994-2003) hot in run or start Wiring diagrams

13 10 2 DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) 17 17 19 SENS LO SENS HI VS OUT A/C SYSTEM AIR CONDI- TIONING, ENGINE CONTROLS SYSTEMS ANTI-LOCK BRAKES SYSTEM AUTOMATIC TRANSMISSION BACK-UP LAMP SWITCH, DRL MODULE, REAR WINDOW DEFOG RELAY, PARKING AID MODULE BATTERY JUNCTION BOX BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CANISTER VENT SOLENOID CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) FUSE 27 DAY/NIGHT MIRROR DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DIMMER RELAY, INSTRUMENT CLUSTER DK BLU/YEL WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM (IGNITION) ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF ENGINE LEFT OF THROTTLE BODY) FUSE 11 FUSE 19 FUSE 9 FUSE 6 GRY RED/ WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (HEADLAMP SWITCH) LT BLU WIRE LT BLU/ ORG WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP (CHECK ENGINE) MASS AIR FLOW SENSOR (RIGHT SIDE OF ENG COMPT) MAXI FUSE 10 BATTERY JUNCTION BOX FUSE 13 MODULE O/D OFF INDICATOR LAMP (TCIL) ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) (SOHC ONLY) PASSIVE ANTI-THEFT SYSTEM MODULE PCM POWER RELAY PCM POWER RELAY DIODE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (THROUGH FIREWALL) REAR AXLE SENSOR RED WIRE RED/LT GRN WIRE RED/PNK WIRE RUN WIRE SHIFT SOLENOID TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSTION SENSOR (ATTACHED TO THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (SOHC) VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT DK GRN/ WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

1400 OHMS 4-WHEEL ANTI-LOCK BRAKE ABS IND LF SENS LF SENS VSS IGN RR SENS RR SENS ISO LINK GROUND CPU FD ANTI-LOCK BRAKES INDICATOR BATTERY JUNCTION BOX (LEFT REAR OF ENGINE BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BPP SW RF SENS RF SENS BRAKE PEDAL POSITION (BPP) SWITCH (ON PEDAL SUPPORT) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 9 COMPARTMENT) COMPUTER DATA LINES SYSTEM DK GRN WIRE FUSE 11 FUSE 14 FUSE 28 FUSE 6 GROUND GROUND GROUND PUMP FD GRY/BLK (OR BLK) WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NOTE: THERE IS A SHORTING BAR ACROSS PINS 8, 16 POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR AXLE SENSOR (TOP OF REAR DIFFERENTIAL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FRONT WHEEL SPEED SENSOR TAN/BLK WIRE TAN/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK WIRE BLK/PNK WIRE DAY/NIGHT MIRROR/ AUTOLAMP SENSOR (MOUNTED IN REARVIEW MIRROR) DIGITAL TRANSMISSION RANGE SENSOR EXTERIOR LIGHTS SYSTEM (PARK LAMP RELAY) FUSE FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) HOT AT ALL TIMES HOT IN HOT IN RUN OR START LT GRN/YEL WIRE RED/YEL WIRE REVERSING LAMP SWITCH RUN WIRE VIO/ORG WIRE WHT/VIO WIRE

"ANTI-THEFT" INDICATOR "FASTEN SEATBELT" INDICATOR 4.0L OHV, 5.0L 4.0L SOHC AIR BAG INDICATOR HI BEAM LEFT TURN ANTI-LOCK BRAKES SYSTEM ANTI-LOCK INDICATOR ANTI-THEFT SYSTEM BATTERY JUNCTION BOX BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FLUID LEVEL WARNING SWITCH (MOUNTED ON LEFT SIDE OF MASTER CYLINDER) BRAKE INDICATOR BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 11 CHARGE INDICATOR CHECK FUEL CAP INDICATOR CHECK GAUGE CRUISE CONTROL SYSTEM DAYTIME RUNNING LAMPS (DRL) MODULE (LEFT FRONT CORNER OF ENG COMPT) DC OUT DIMMER MODULE (LEFT SIDE OF STEERING COLUMN) DIMMER RELAY (IN RELAY MODULE) DK BLU/LT GRN WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR AJAR INDICATOR DRL DIODE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE ENGINE OIL PRESSURE SWITCH (ON ENGINE, NEXT TO POWER STEERING PUMP) EXCEPT 4.0L SOHC 4.0L SOHC FUEL GUAGE FUEL TANK ASSEMBLY FUSE 11 FUSE 15 FUSE 25 GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEAD OFF HEADLAMP SWITCH HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HOT AT ALL TIMES HOT IN RUN OR START IGNITION SWITCH ILLUMINATION LAMPS INDICATOR (HI-RANGE) INSTRUMENT CLUSTER LOCK OFF LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PARK PARKING BRAKE SWITCH (ON RIGHT SIDE OF PARKING BRAKE LEVER) PNK/LT GRN WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN RUN WIRE SLOSH MODULE SPEED CONTROL INDICATOR SPEEDOMETER/ ODOMETER STARTING/ CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACHOMETER TACHOMETER DATA LINK CONNECTOR (RIGHT REAR CORNER OF ENGINE COMPT) TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE TRANSMISSION CONTROL INDICATOR (TCIL) VIO WIRE VIO/WHT WIRE VOLTMETER W/DRL W/O DRL WARNING SYSTEM WARNING SYSTEMS EXTERIOR LIGHTS SYSTEM WHT DK GRN/ WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BRN WIRE CENTRAL JUNCTION BOX COURTESY LAMPS CIRCUIT DIMMER MODULE (LEFT SIDE OF STEERING COLUMN) DIMMER RELAY DIMMING INDICATORS (POWER) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE FUSE 11 FUSE 26 HEADLAMP RELAY HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT EXTERIOR REAR VIEW MIRROR LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE MAIN LIGHT SWITCH MESSAGE CENTER INSTRUMENT ILLUMINATION MESSAGE CENTER SWITCH ASSEMBLY NCA WIRE NORM OFF ON OFF NORM ORG/ WIRE PARK OFF HEAD PNK WIRE PPL RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RED/YEL WIRE RELAY MODULE (BEHIND CENTER OF DASH) RIGHT EXTERIOR REAR VIEW MIRROR SOLID STATE TAN/WHT WIRE TAN/YEL WIRE W/ HIGH SERIES CONSOLE ONLY WHT WIRE WHT/PPL WIRE

ANTI- THEFT IND ANTI-THEFT TRANSCEIVER MODULE (BEHIND CENTER OF DASH) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BUS (-) BUS (+) GROUND PATS IND CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) ENGINE CONTROL MODUEL DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE FUSE 19 FUSE 25 GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT GRN WIRE PASSIVE ANTI-THEFT SYSTEM (PATS) MODULE (BEHIND TOP RIGHT SIDE OF DASH) PNK/ LT BLU WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RF POWER RECEIVE TAN/ORG WIRE TRANSMIT GROUND BATTERY IGNITION W/ EATC W/O EATC WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE

1 1 PASS SIDE AIR BAG FEED PASS SIDE AIR BAG RETURN 1 2 3 4 5 6 7 8 9 10 11 1 1 DRIVER SIDE AIR BAG FEED DRIVER SIDE AIR BAG RETURN AIR BAG AIR BAG INDICATOR CTRL AIR BAG DEDICATED GROUND AIR BAG SLIDING CONTACT AIR BAG TONE DRIVER BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) DRIVER AIR BAG MODULE EXCEPT SPORT GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GROUND GROUND GROUND GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN RUN HOT IN RUN OR START INSTRUMENT CLUSTER LATE PRODUCTION OTHER LEFT SIDE AIR BAG MODULE LEFT SIDE AIR BAG SENSOR (W/SPORT MODEL) (AT BASE OF LEFT "B" PILLAR) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PASSENGER AIR BAG MODULE PNK WIRE PNK/BLK WIRE RED WIRE RED/YEL WIRE RESISTOR A (BENEATH DRIVER'S SEAT) RESISTOR B (W/SPORT MODEL) (BENEATH PASSENGER'S SEAT) RESTRAINTS CONTROL MODULE (RCM) (BEHIND LOWER CENTER OF DASH) RIGHT SIDE AIR BAG MODULE (W/SPORT MODEL) RIGHT SIDE AIR BAG SENSOR (W/SPORT MODEL) (AT BASE OF RIGHT "B" PILLAR) SHORTING BAR SHORTING BAR SHORTING BAR SOLID STATE (LATE PRODUCTION) (OTHER) SPORT MODEL W/O SIDE AIR BAGS W/SIDE AIR BAGS WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE

AIR CONDITIONING AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT LEFT FENDER APRON) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU WIRE DK BLU/YEL WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EVR CTRL TACHOMETER FUEL LEVEL IN DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GEM GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL (ABOVE VALVE COVER) INSTRUMENT CLUSTER SYSTEM LT BLU/BLK WIRE LT GRN/RED WIRE MAF SIG RTN TRANS TEMP ECT SENS IAT SENS FUEL PUMP MON A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OSS + PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CASE GND IGN COIL SHIFT SOL A SHIFT SOL D TRANS CTRL SW PWR GND IGN COIL RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT GRN WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

357 1017 360 11 1145 1143 570 96 (2000) AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION SENSOR (LOWER FRONT OF ENGINE COMPT) CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUEL FLOW RATE FUEL GUAGE SEND DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GEM CHK FUEL CAP EVR CTRL TACHOMETER GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL (ABOVE VALVE COVER) INSTRUMENT CLUSTER SYSTEM KNOCK SENS LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE MAF SIG RTN TFT SENS ECT SENS MAF SENS FUEL PUMP REL A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OSS + PCM POWER DIODE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CHASSIS GND IGN COIL SHIFT SOL A SHIFT SOL D TCS INPUT PWR GND IGN COIL RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT, AT LEFT FENDER APRON) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE CRANKSHAFT POSITION (CKP) SENSOR (LOWER FRONT OF ENGINE COMPT) CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EVR CTRL TACHOMETER FUEL FLOW RATE FUEL LEVEL IN DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL 1, 2 (LEFT FRONT OF ENGINE) IGNITION COIL 3, 4 (RIGHT FRONT OF ENGINE) INSTRUMENT CLUSTER SYSTEM LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE MAF SIG RTN TRANS TEMP ECT SENS MAF SENS FUEL PUMP MON A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CHASSIS GND IGN COIL 1 SHIFT SOL A PWR GND IGN COIL 2 RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS CTRL SW TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE