Ford Explorer II (1994-2003) fuse 19 Wiring diagrams

13 10 2 DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) BACK-UP LAMPS, REAR WINDOW DEFROST RELAY, PARKING AID MODULE BATTERY JUNCTION BOX BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (BEHIND STEERING COLUMN) BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF DASH) DATA DLC (-) DLC (+) PWR GND CASE GND SSA TCS MAF TFT ECT MAF DK BLU/WHT WIRE DK BLU/YEL WIRE ELECTRONIC PRESSURE CONTROL (EPC) SOLENOID ENG CONTROLS, A/C RELAY, FUEL PUMP RLY FUEL INJECTORS FUSE 10 FUSE 13 FUSE 19 FUSE 27 FUSE 6 FUSE 9 GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MASS AIR FLOW SENSOR (RIGHT SIDE OF ENG COMPT) OD OFF ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT REAR OF TRANSMISSION) PASSIVE ANTI-THEFT MODULE PCM POWER DIODE PCM POWER RELAY PNK/ MALFUNCTION INDICATOR LAMP (MIL) (CHECK ENGINE) WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR AXLE SPEED SENSOR (ON AXLE ASSEMBLY) RED WIRE RED/LT GRN WIRE RED/PNK WIRE SHIFT SOLENOIDS (SS) SSA SSB TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (ATTACHED TO THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION CONTROL INDICATOR LAMP (TCIL) TRANSMISSION CONTROL SWITCH (TCS) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

ANTI- THEFT IND ANTI-THEFT TRANSCEIVER MODULE (BEHIND CENTER OF DASH) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BUS (-) BUS (+) GROUND PATS IND CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) ENGINE CONTROL MODUEL DK BLU WIRE DK BLU/LT GRN WIRE DK GRN/WHT WIRE FUSE 19 FUSE 25 GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LT GRN WIRE PASSIVE ANTI-THEFT SYSTEM (PATS) MODULE (BEHIND TOP RIGHT SIDE OF DASH) PNK/ LT BLU WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RF POWER RECEIVE TAN/ORG WIRE TRANSMIT GROUND BATTERY IGNITION W/ EATC W/O EATC WHT WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 STARTER RELAY ANTI- THEFT IND BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/WHT WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (BEHIND CENTER OF DASH) (FRONT LEFT SIDE OF CENTER CONSOLE) DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/WHT WIRE FUSE 19 FUSE 25 GRY/ORG WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER PASSIVE ANTI-THEFT TRANSCEIVER (IN STEERING COLUMN) PASSIVE ANTI-THEFT TRANSCEIVER MODULE (BEHIND TOP RIGHT SIDE OF DASH) PNK/LT BLU WIRE RED/LT GRN WIRE RF, POWER RX, SIGNAL SCP BUS (-) SCP BUS (+) GROUND PATS IND STARTER RELAY TAN/ORG WIRE TX, SIGNAL GROUND BATTERY IGNITION WHT/LT GRN WIRE WHT/YEL WIRE

ANTI- THEFT IND BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE FUSE 19 GRY/ORG WIRE HOT IN RUN OR START INSTRUMENT CLUSTER LT GRN WIRE ORG/ WIRE PASSIVE ANTI-THEFT TRANSCEIVER (IN STEERING COLUMN) POWERTRAIN CONTROL MODULE (MOUNTED THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE STARTER RELAY WHT WIRE WHT/LT GRN WIRE

4.0L 5.0L AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX PCM POWER DIODE BLK WIRE BRAKE PEDAL POSITION SWITCH BRAKE PRESSURE SWITCH BRN WIRE CENTRAL JUNCTION BOX CENTRAL TIMER MODULE/ GENERIC ELECTRONIC MODULE DAY/NIGHT MIRROR/ AUTOLAMP SENSOR DIMMER RELAY FROM MAXI FUSE 1 DIAGRAM 2 OF 5) FROM MAXI FUSE 5 (DIAGRAM 2 OF 5) FROM PCM POWER RELAY (DIAGRAM 2 OF 5) FRONT WASHER PUMP RELAY FUSE 1 FUSE 11 FUSE 12 FUSE 13 FUSE 15 FUSE 16 FUSE 19 FUSE 20 FUSE 25 FUSE 9 GENERIC ELECTRONIC MODULE GRY WIRE IGNITION COIL 1, 2 RADIO NOISE CAPACITOR IGNITION COIL 3, 4 IGNITION SWITCH INSTRUMENT CLUSTER LOCK LOCK OFF LT BLU WIRE LT GRN WIRE MEMORY SEAT SWITCH NCA WIRE OFF ORG/ WIRE ORG/LT GRN WIRE PASSIVE ANTI-THEFT SYSTEM MODULE PNK WIRE POWER ANTENNA MODULE POWER MIRROR SWITCH PPL RADIO NOISE CAPACITOR IGNITION COIL RED WIRE RED/LT GRN WIRE RELAY MODULE (CENTER OF DASH) REMOTE ANTI-THEFT PERSONALITY MODULE RADIO RUN WIRE TAN/BLK WIRE TO FUSE 10 (DIAGRAM 5 OF 5) TO FUSE 21 (DIAGRAM 4 OF 5) TO FUSE 24 (DIAGRAM 4 OF 5) TO FUSE 27 (DIAGRAM 4 OF 5) WHT WIRE WIPER MOTOR LIFTGATE WIPER/ WASHER SWITCH WIPER RUN RELAY WIPER HI-LO RELAY YEL WIRE

ABS CONTROL MODULE RESTRAINTS CONTROL MODULE AUXILIARY RELAY BOX 2 (UNDER LEFT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BELT MINDER MODULE MAIN LIGHT SWITCH BLK WIRE BRAKE FLUID LEVEL SWITCH BRAKE SHIFT INTERLOCK SPEED CONTROL SERVO GENERIC ELECTRONIC MODULE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CLUTCH PEDAL POSITION SWITCH DIGITAL TRANSMISSION RANGE SENSOR FOUR WHEEL DRIVE CONTROL MODULE FROM FUSE 11 (DIAGRAM 1 OF 3) FROM IGNITION SWITCH (DIAGRAM 2 OF 3) FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 12 FUSE 14 FUSE 15 FUSE 11 FUSE 16 FUSE 19 FUSE 20 FUSE 24 FUSE 28 FUSE 6 FUSE 10 GENERIC ELECTRONIC MODULE GENERIC ELECTRONIC MODULE RADIO GRY WIRE IGNITION SWITCH IGNITION TRANSFORMER CAPACITOR 1 IGNITION COIL MODULE INDICATOR FLASHER RELAY INSTRUMENT CLUSTER LOCK OFF LT BLU WIRE LT GRN WIRE M/T A/T ORG/ WIRE OVERHEAD CONSOLE FRONT FUNCTION SELECTOR SWITCH ASSEMBLY PCM POWER DIODE PNK (OR PNK) WIRE PNK PNK WIRE PNK WIRE RADIO REAR WINDOW WIPER/ WASHER SWITCH (SPORT) RED WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE ROOF OPENING PANEL MODULE WINDOW SAFETY RELAY REAR WINDOW MOTOR (SPORT TRAC) RUN WIRE SPORT TAN WIRE TEMPERATURE BLEND DOOR ACTUATOR TO FUSE 16 (CJB) (DIAGRAM 2 OF 3) TO FUSE 27 (CJB) (DIAGRAM 3 OF 3) WHT WIRE WINDSHIELD WIPER MOTOR WIPER RUN/PARK RELAY WIPER HIGH/LOW RELAY HORN RELAY YEL WIRE

AUXILIARY RELAY BOX 2 (UNDER LEFT SIDE OF DASH) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPT) BLK WIRE BRAKE FLUID LEVEL SWITCH BRAKE SHIFT INTERLOCK TEMPERATURE BLEND DOOR ACTUATOR BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CLUTCH PEDAL POSITION SWITCH DIGITAL TRANSMISSION RANGE SENSOR FROM FUSE 11 (DIAGRAM 1 OF 3) FROM IGNITION SWITCH (DIAGRAM 2 OF 3) FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FRONT FUNCTION SELECTOR SWITCH ASSEMBLY OVERHEAD CONSOLE SPEED CONTROL SERVO FUSE 10 FUSE 6 FUSE 11 FUSE 12 FUSE 14 FUSE 15 FUSE 16 FUSE 19 FUSE 20 FUSE 24 FUSE 28 GENERIC ELECTRONIC MODULE RADIO GRY WIRE IGNITION SWITCH IGNITION TRANSFORMER CAPACITOR 1 IGNITION COIL MODULE INDICATOR FLASHER RELAY INSTRUMENT CLUSTER LOCK OFF LT BLU WIRE LT GRN WIRE M/T M/T A/T MAIN LIGHT SWITCH FOUR WHEEL DRIVE CONTROL MODULE ORG/ WIRE PCM POWER DIODE PNK (OR PNK) WIRE PNK PNK WIRE PNK SPORT TRAC SPORT (LEFT KICK PANEL) WIRE PNK WIRE RADIO REAR WINDOW MOTOR REAR WINDOW WIPER/ WASHER SWITCH (SPORT) RED WIRE RESTRAINTS CONTROL MODULE ABS CONTROL MODULE ROOF OPENING PANEL MODULE RUN WIRE TAN WIRE TO FUSE 16 (CJB) (DIAGRAM 2 OF 3) TO FUSE 27 (CJB) (DIAGRAM 3 OF 3) WHT WIRE WINDOW SAFETY RELAY WINDSHIELD WIPER MOTOR WIPER RUN/PARK RELAY HORN RELAY WIPER HIGH/LOW RELAY YEL WIRE

AIR CONDITIONING AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT LEFT FENDER APRON) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU WIRE DK BLU/YEL WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EVR CTRL TACHOMETER FUEL LEVEL IN DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GEM GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL (ABOVE VALVE COVER) INSTRUMENT CLUSTER SYSTEM LT BLU/BLK WIRE LT GRN/RED WIRE MAF SIG RTN TRANS TEMP ECT SENS IAT SENS FUEL PUMP MON A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OSS + PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CASE GND IGN COIL SHIFT SOL A SHIFT SOL D TRANS CTRL SW PWR GND IGN COIL RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT GRN WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

357 1017 360 11 1145 1143 570 96 (2000) AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CRANKSHAFT POSITION SENSOR (LOWER FRONT OF ENGINE COMPT) CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUEL FLOW RATE FUEL GUAGE SEND DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GEM CHK FUEL CAP EVR CTRL TACHOMETER GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL (ABOVE VALVE COVER) INSTRUMENT CLUSTER SYSTEM KNOCK SENS LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE MAF SIG RTN TFT SENS ECT SENS MAF SENS FUEL PUMP REL A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OSS + PCM POWER DIODE PNK/LT BLU WIRE PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CHASSIS GND IGN COIL SHIFT SOL A SHIFT SOL D TCS INPUT PWR GND IGN COIL RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AIR CONDITIONING SYSTEM AIR CONDITIONING SYSTEM (HTR-A/C ASSY) AIR SUSP INPUT BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT, AT LEFT FENDER APRON) BLK WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE CRANKSHAFT POSITION (CKP) SENSOR (LOWER FRONT OF ENGINE COMPT) CRANKSHAFT POSITION SENSOR SHIELD DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) 10 2 DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EVR CTRL TACHOMETER FUEL FLOW RATE FUEL LEVEL IN DATA LINK FUSE 10 FUSE 19 FUSE 27 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION COIL 1, 2 (LEFT FRONT OF ENGINE) IGNITION COIL 3, 4 (RIGHT FRONT OF ENGINE) INSTRUMENT CLUSTER SYSTEM LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE MAF SIG RTN TRANS TEMP ECT SENS MAF SENS FUEL PUMP MON A/C NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) PWR GND CHASSIS GND IGN COIL 1 SHIFT SOL A PWR GND IGN COIL 2 RADIO NOISE CAPACITOR (LEFT OF IGNITION COIL) RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/YEL WIRE SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TAN/YEL WIRE TRANS CTRL SW TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE