Ford Explorer II (1994-2003) air bag sliding contact Wiring diagrams

1 2 3 4 5 6 7 15 16 17 18 19 20 DATA (-) BATTERY GROUND INPUT GROUND 130 OHMS 226 OHMS 2940 OHMS CRUISE CONTROL 422 OHMS 931 OHMS AIR BAG SLIDING CONTACT AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR RELAY BLOWER MOTOR SPEED CONTROLLER (NEAR BLOWER MOTOR) BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (LEFT SIDE OF VEHICLE, BELOW DASH) FUSE 36 CLIMATE CONTROL SWITCH DK BLU/LT GRN WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN FUSE 10 FUSE 2 GRN WIRE GRY WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN ILLUMINATION LT (NEAR BREAKOUT TO CENTRAL JUNCTION BOX) (OR LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/YEL WIRE MESSAGE CENTER NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/ORG WIRE SOLID STATE SOUND SYSTEMS SPEED CONTROL SERVO (IN RIGHT REAR OF ENGINE COMPARTMENT) SPEED CTRL SW GND TAN/ORG WIRE TEMP VIO WIRE WHT WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE

AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/WHT WIRE CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE OF DASH) COMPT) DK BLU WIRE EARLY PRODUCTION FUSE 22 GRN WIRE HORN (RIGHT FRONT OF ENGINE HORN RELAY HORN SWITCH HOT AT ALL TIMES LATE PRODUCTION LT BLU WIRE NCA WIRE STEERING WHEEL/ SPEED CONTROL SWITCH W/ ANT- THEFT W/ CRUISE CONTROL W/O ANTI- THEFT W/O CRUISE CONTROL YEL WIRE YEL/GRN WIRE

AIR BAG SLIDING CONTACT AUXILIARY RELAY BOX 2 (UNDER LEFT SIDE OF DASH) BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT) PARK LAMP RELAY BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT) W/0 CONVENIENCE GROUP BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY SAVER RELAY BLK WIRE BLK/PNK WIRE BRN WIRE CENTER OF REAR WINDOW) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) COURTESY LAMPS CIRCUIT FOG LAMP ISOLATION RELAY FOG LAMP SWITCH FOUR- WHEEL DRIVE SWITCH OVERHEAD CONSOLE ASHTRAY ILLUM- INATION LAMP FRONT FUNCTION SELECTOR SWITCH ASSEMBLY MAIN LIGHT SWITCH FUSE 26 GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT) FUSE 33 INSTRUMENT CLUSTER INSTRUMENT PANEL DIMMING MODULE (LEFT SIDE OF STEERING COLUMN) LT GRN WIRE LT GRN/ORG WIRE MAIN LIGHT SWITCH NCA WIRE NORM OFF HEAD PARK ON OFF NORM ORG/ WIRE REAR INTEGRATED CONTROL PANEL RADIO REAR WINDOW ADJUST SWITCH RED WIRE REMOTE ANTI-THEFT PERSONALITY MODULE (BELOW SOLID STATE OFF STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE W/ CONVENIENCE GROUP W/ CONVENIENCE GROUP ONLY W/ CONVENIENCE GROUP ONLY W/O CONVENIENCE GROUP ONLY W/ FOG LAMPS W/O FOG LAMPS W/ HIGH SERIES CENTER CONSOLE WHT WIRE

AIR BAG SLIDING CONTACT AUXILIARY RELAY BOX 2 (UNDER LEFT SIDE OF DASH) BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT) PARK LAMP RELAY BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT) W/0 CONVENIENCE GROUP BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BATTERY SAVER RELAY BLK WIRE BLK/PNK WIRE BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CENTRAL SECURITY MODULE (BEHIND TOP RIGHT SIDE COURTESY LAMPS CIRCUIT FOG LAMP ISOLATION RELAY FOG LAMP SWITCH FOUR- WHEEL DRIVE SWITCH OVERHEAD CONSOLE ASHTRAY ILLUM- INATION LAMP FRONT FUNCTION SELECTOR SWITCH ASSEMBLY MAIN LIGHT SWITCH FUSE 26 GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX (LEFT SIDE OF ENG COMPT) FUSE 33 INSTRUMENT CLUSTER INSTRUMENT PANEL DIMMING MODULE (LEFT SIDE OF STEERING COLUMN) LT GRN WIRE LT GRN/ORG WIRE MAIN LIGHT SWITCH NCA WIRE NORM OF DASH) OFF HEAD PARK ON OFF NORM ORG/ WIRE REAR INTEGRATED CONTROL PANEL RADIO REAR WINDOW ADJUST SWITCH RED WIRE SOLID STATE OFF STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE W/ CONVENIENCE GROUP W/ CONVENIENCE GROUP ONLY W/ CONVENIENCE GROUP ONLY W/O CONVENIENCE GROUP ONLY W/ FOG LAMPS W/O FOG LAMPS W/ HIGH SERIES CENTER CONSOLE WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM RETURN GROUND FUSED IGNITION 1 2 3 4 5 6 7 8 SUBWOOFER (-) SUBWOOFER (+) AUDIO SHIELD HIGH AUDIO MUTE 1068 797 AUDIO SYTEM ON POWER 235 57 1000 INTERIOR LIGHTS 694 57 235 825 827 GROUND GROUND ILLUM AMP R REAR (+) AMP L REAR (+) 832 833 PROTOCOL A PROTOCOL B AIR BAG SLIDING CONTACT ANTI-LOCK BRAKES SYSTEM AUDIO ON AUDIO SYSTEM ON PROTOCOL A PROTOCOL B AUDIO/ CLIMATE CONTROL SWITCH ASSEMBLY BAND BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CD CHANGER CD PLAYER SHIELD CD RIGHT SIG IN CD RIGHT SIG OUT CD LEFT SIG IN CD LEFT SIG OUT DK GRN/ORG WIRE DK GRN/VIO WIRE DOWN FUSE 1 FUSE 20 FUSE 28 FUSE 29 FUSE 34 FUSE JUNCTION PANEL (LEFT SIDE OF VEHICLE, BELOW DASH) FUSED IGNITION POWER ANTENNA LOGIC GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE HIGH AUDIO MUTE GROUND HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LIGHTS LEFT FRONT SPEAKER LEFT REAR SPEAKER RIGHT FRONT SPEAKER LEFT SIG (-) LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MEM MIRRORS SYSTEM NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/RED WIRE POWER POWER ANTENNA POWER ANTENNA MODULE (ON ANTENNA MAST) POWER SUBWOOFER (+) SUBWOOFER (-) PROTOCOL A PROTOCOL B RADIO RADIO CONTROL REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT REAR SPEAKER RIGHT SIG SHIELD SPEED CONTROL SERVO (RIGHT REAR OF ENGINE COMPT) SUB SPEAKER (-) SUBWOOFER SUBWOOFER AMPLIFIER TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VEHICLE SPEED SIG VIO WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

1 1 PASS SIDE AIR BAG FEED PASS SIDE AIR BAG RETURN 1 2 3 4 5 6 7 8 9 10 11 1 1 DRIVER SIDE AIR BAG FEED DRIVER SIDE AIR BAG RETURN AIR BAG AIR BAG INDICATOR CTRL AIR BAG DEDICATED GROUND AIR BAG SLIDING CONTACT AIR BAG TONE DRIVER BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) DRIVER AIR BAG MODULE EXCEPT SPORT GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GROUND GROUND GROUND GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN RUN HOT IN RUN OR START INSTRUMENT CLUSTER LATE PRODUCTION OTHER LEFT SIDE AIR BAG MODULE LEFT SIDE AIR BAG SENSOR (W/SPORT MODEL) (AT BASE OF LEFT "B" PILLAR) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PASSENGER AIR BAG MODULE PNK WIRE PNK/BLK WIRE RED WIRE RED/YEL WIRE RESISTOR A (BENEATH DRIVER'S SEAT) RESISTOR B (W/SPORT MODEL) (BENEATH PASSENGER'S SEAT) RESTRAINTS CONTROL MODULE (RCM) (BEHIND LOWER CENTER OF DASH) RIGHT SIDE AIR BAG MODULE (W/SPORT MODEL) RIGHT SIDE AIR BAG SENSOR (W/SPORT MODEL) (AT BASE OF RIGHT "B" PILLAR) SHORTING BAR SHORTING BAR SHORTING BAR SOLID STATE (LATE PRODUCTION) (OTHER) SPORT MODEL W/O SIDE AIR BAGS W/SIDE AIR BAGS WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE

AIR BAG INDICATOR AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BELT MINDER MODULE (BEHIND CENTER OF DASH) BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DOOR AJAR INDICATOR DRIVER SIDE FRONT DOOR AJAR SWITCH PASS- ENGER SIDE FRONT DOOR AJAR SWITCH FUSE 10 FUSE 11 FUSE 20 FUSE 25 FUSE 28 FUSE 33 FUSE 5 FUSE 6 GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HEAD HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR ACC HOT IN START HOT IN START OR RUN IGNITION KEY SWITCH INSTRUMENT CLUSTER LEFT LIFTGATE AJAR SWITCH (LEFT SIDE OF LIFTGATE) LT BLU/BLK WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE OFF PARK ORG/ WIRE PASS- ENGER SIDE FRONT DOOR AJAR SWITCH PASS- ENGER SIDE REAR DOOR AJAR SWITCH DRIVER SIDE REAR DOOR AJAR SWITCH PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR WINDOW WIPER DISABLE SWITCH RED WIRE RED/BLK WIRE RED/YEL WIRE RETRAINTS CONTROL MODULE (RCM) (BEHIND LOWER CENTER OF DASH) RIGHT LIFTGATE AJAR SWITCH (RIGHT SIDE OF LIFTGATE) SAFETY BELT BUCKLE SWITCH SAFETY BELT INDICATOR SPORT SPORT TRAC TAN WIRE TAN/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

1 2 SPORT SPORT TRAC AIR BAG INDICATOR AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT, AT FENDER APRON) BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DOOR AJAR INDICATOR DRIVER SIDE FRONT DOOR AJAR SWITCH PASS- ENGER SIDE FRONT DOOR AJAR SWITCH DRIVER SIDE REAR DOOR AJAR SWITCH FUSE 11 FUSE 20 FUSE 25 FUSE 33 FUSE 6 GENERIC ELECTRONIC MODULE (GEM) (BEHIND CENTER OF DASH) GRY/BLK WIRE GRY/RED WIRE HEAD HOT AT ALL TIMES HOT AT ALL TIMES FUSE 5 HOT IN RUN HOT IN RUN OR ACC HOT IN START OR RUN IGNITION KEY SWITCH INSTRUMENT CLUSTER LEFT LIFTGATE AJAR SWITCH (LEFT SIDE OF LIFTGATE) LT BLU/BLK WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE OFF PARK ORG/ WIRE PASS- ENGER SIDE REAR DOOR AJAR SWITCH PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR WINDOW WIPER DISABLE SWITCH RED WIRE RED/YEL WIRE RETRAINTS CONTROL MODULE (RCM) (BEHIND LOWER CENTER OF DASH) RIGHT LIFTGATE AJAR SWITCH (RIGHT SIDE OF LIFTGATE) SAFETY BELT BUCKLE SWITCH SAFETY BELT INDICATOR SPORT SPORT TRAC TAN WIRE TAN/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE