Ford Expedition II (2002-2006) red/blk Wiring diagrams

19 20 21 22 +/- +/- AIR BAG SLIDING CONTACT (BEHIND LEFT SIDE OF DASH) ATC SOLENOID, MANIFOLD ASSEMBLY (BEHIND CENTER OF DASH) AUTOLAMP/ SUNLOAD SENSOR (AT TOP OF DASH) AUXILIARY AIR CONDITIONER HEATER CIRCUIT BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DEFOGGER SYSTEM DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (IN CENTER OF DASH) EXPEDITION W/ DUAL ZONE EATC NAVIGATOR W/ DUAL ZONE EATC FRONT BLOWER MOTOR RELAY FUSE 116 FUSE 13 FUSE 5 HEATER BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) HOT AT ALL TIMES HOT IN RUN IN-VEHICLE TEMPERATURE/ HUMIDITY SENSOR (IN LEFT SIDE OF DASH) LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE MICROPROCESSOR NAVIGATOR 1 2 3 NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PATE IND PNK PNK WIRE PNK/BLK WIRE PWR PWR PWR PWR RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE SIG RTN- SIG RTN- TAN WIRE TAN/ORG WIRE VBATT VEHICLE SECURITY MODULE (VSM) (UNDER RIGHT SIDE OF DASH) VIO WIRE VIO/WHT WIRE VPWR VREF VREF PWR PWR PWR VREF VREF WHT WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/LT GRN WIRE

1 2 3 4 5 6 VPWR SIG C SIG B SIG A SIG VPWR 12 24 35 26 37 17 SCS SIG C SCS SIG B SCS SIG A SCS SIG VREF CTRL SW GND 25 27 OSS SENSOR SIG RTN 40 32 44 15 VBATT SCP (+) SCP (-) VPWR 41 12 14 BPP SW OUTPUT SCP (+) SCP (-) 8 9 SCP (+) SCP (-) ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) AIR BAG SLIDING CONTACT (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION SWITCH (ON BRAKE PEDAL SUPPORT) BRN/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM DEACTIVATOR SWITCH (ON BRAKE PEDAL SUPPORT) DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE EXPEDITION (EXCEPT EDDIE BAUER) EXPEDITION EDDIE BAUER, NAVIGATOR FUSE 12 FUSE 15 FUSE 28 FUSE 5 GRY/RED WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR START HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE NCA WIRE OFF OUTPUT SHAFT SPEED (OSS) SENSOR PCM POWER DIODE PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RESUME SET- SPEED CONTROL IND SPEED CONTROL RELAY SPEED CONTROL SERVO (ON LEFT SIDE OF ENGINE COMPT) STEERING WHEEL RADIO SWITCH STEERING WHEEL/SPEED CONTROL SWITCH TAN WIRE TAN/ORG WIRE TRANSMISSION VIO/YEL WIRE WHT WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 SOL - SOL + 1 2 PNK WIRE AIR SUSPENSION COMPRESSOR ASSEMBLY (AT RIGHT FRONT OF ENGINE COMPT) AIR SUSPENSION COMPRESSOR RELAY (AT RIGHT FRONT OF ENGINE COMPT) AIR SUSPENSION MODULE (UNDER LEFT SIDE OF DASH) AIR SUSPENSION SERVICE SWITCH (AT LEFT REAR CORNER OF VEHICLE) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BRN/BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/YEL WIRE ELECTRONIC POWER STEERING SYSTEM FOUR WHEEL DRIVE CONTROL MODULE (AT LEFT "B" PILLAR) FUSE 11 FUSE 111 FUSE 20 FUSE 27 GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LEFT FRONT HEIGHT SENSOR (AT LEFT FRONT SHOCK TOWER) LEFT FRONT SHOCK ABSORBER SOLENOID VALVE (ON LEFT FRONT SHOCK TOWER) LEFT REAR SHOCK ABSORBER SOLENOID VALVE (ON LEFT REAR SHOCK TOWER) LR SOL VLV RR SOL VLV LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/LT BLU WIRE ORG/RED WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE(PCM) (ON RIGHT SIDE OF FIREWALL) REAR HEIGHT SENSOR (UNDER REAR OF VEHICLE, NEAR AXLE) RED/BLK WIRE RIGHT FRONT HEIGHT SENSOR (AT RIGHT FRONT SHOCK TOWER) RIGHT FRONT SHOCK ABSORBER SOLENOID VALVE (ON RIGHT FRONT SHOCK TOWER) RIGHT REAR SHOCK ABSORBER SOLENOID VALVE (ON RIGHT REAR SHOCK TOWER) SERVICE SWITCH UBP BUS HEIGHT SENS FEED HEIGHT SENS SIG HEIGHT SENS RTN TAN WIRE VIO WIRE VIO/LT GRN WIRE VIO/WHT WIRE VSS

1 1 2 3 4 UPB BUS VPWR GROUND VBATT 1 2 3 4 HEATER + HEATER - MOTOR - PWR 1 2 3 4 UPB BUS VPWR GROUND VBATT 2 4 5 HEAT 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 PWR SWITCH SENS TEMP + 9 7 COOL BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM COOL IND DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DRIVER SIDE CLIMATE CONTROLLED SEAT BACKREST ELEMENT (UNDER DRIVER SEAT) DRIVER SIDE CLIMATE CONTROLLED SEAT CUSHION ELEMENT (UNDER DRIVER SEAT) DRIVER SIDE CLIMATE CONTROLLED SEAT FAN (UNDER DRIVER SEAT) DRIVER SIDE CLIMATE CONTROLLED SEAT MODULE (UNDER DRIVER SEAT) DRIVER SIDE CLIMATE CONTROLLED SEAT SWITCH FUSE 118 FUSE 18 GRY/LT BLU WIRE HEAT IND HOT AT ALL TIMES HOT IN START OR RUN ILLUMINATION LT BLU RED/ WIRE LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE NCA WIRE PASSENGER SIDE CLIMATE CONTROLLED SEAT BACKREST ELEMENT (UNDER PASSENGER SEAT) PASSENGER SIDE CLIMATE CONTROLLED SEAT CUSHION ELEMENT PASSENGER SIDE CLIMATE CONTROLLED SEAT FAN PASSENGER SIDE CLIMATE CONTROLLED SEAT MODULE (UNDER PASSENGER SEAT) PASSENGER SIDE CLIMATE CONTROLLED SEAT SWITCH RED WIRE RED/BLK WIRE RED/LT BLU WIRE TAN/LT BLU WIRE TEMP TEMP SENSOR RTN SIG VIO WIRE VIO/LT BLU WIRE VIO/WHT WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE YEL/LT BLU WIRE

ACCESSORY DELAY RELAY AIR BAG SLIDING CONTACT AIR BAG SLIDING CONTACT (BEHIND LEFT SIDE OF DASH) ASHTRAY ILLUMINATION LAMP AUTO HEAD OFF PARK BLK WIRE BLK/LT BLU WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) CIRCUIT BREAKER 401 DK GRN WIRE DK GRN/ORG WIRE DRIVER SIDE CLIMATE CONTROLLED SEAT SWITCH DRIVER SIDE DOOR LOCK SWITCH DVD PLAYER (W/ DVD PLAYER) FRONT AUXILIARY FUNCTION SELECTOR SWITCH ASSEMBLY EDDIE BAUER EXCEPT EDDIE BAUER FRONT FUNCTION SELECTOR SWITCH ASSEMBLY (MANUAL A/C) FUSE 22 FUSE 6 HORNS SYSTEM (IN CONSOLE PANEL HARNESS, NEAR BREAKOUT TO CONSOLE 2 POWER POINT) HOT AT ALL TIMES ILLUMINATION INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MAIN LIGHT SWITCH MASTER WINDOW ADJUST SWITCH MESSAGE CENTER SWITCH NCA WIRE ORG/ WIRE PASSENGER SIDE CLIMATE CONTROLLED SEAT SWITCH TRACTION CONTROL PASSENGER SIDE DOOR LOCK SWITCH ROOF OPENING PANEL SWITCH PNK PNK WIRE PNK WIRE POWER WINDOWS SYSTEM PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PULSE WIDTH MODULE RADIO FOUR-WHEEL DRIVE SWITCH REAR AUXILIARY FUNCTION SELECTOR SWITCH ASSEMBLY REAR INTEGRATED CONTROL PANEL (RICP) RED WIRE RED/BLK WIRE STEERING WHEEL RADIO SWITCH STEERING WHEEL/ SPEED CONTROL SWITCH STEERING WHEEL/ SPEED CONTROL SWITCH SWITCH TAN/WHT WIRE W/ AUXILIARY A/C W/ CENTER CONSOLE

1 2 3 4 5 6 7 8 9 10 11 12 PROTOCOL A 1 2 3 4 5 6 7 8 9 10 AUDIO MUTE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER (-) SUBWOOFER (+) SHIELD MUTE 1 2 3 4 5 6 7 VBATT ILLUM GROUND PNK ACC RELAY ILLUM PWR WIRE 140 595 EXTERIOR LIGHTS SYSTEM ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) AIR BAG SLIDING CONTACT (BEHIND LEFT SIDE OF DASH) ANTENNA AUDIO GROUND BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ELECTRONIC HIDDEN ANTENNA MODULE (EHAM) (ABOVE RIGHT REAR FUSE 22 FUSE 31 FUSE 4 FUSE 7 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT W/ ACCESSORY DELAY RELAY ENERGIZED L AUDIO OUT + R AUDIO OUT + PROTOCOL B AUDIO SYS ON LF SENS SIG VPWR LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE NCA WIRE NEXT MEDIA ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK VPWR WIRE PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) QUARTERPANEL WINDOW) RADIO RED WIRE RED/BLK WIRE RED/YEL WIRE REVERSE VOLTAGE SW SIG SHIELD L AUDIO OUT - R AUDIO OUT - SIG RTN STEERING WHEEL RADIO SWITCH SUBWOOFER (-) SUBWOOFER (+) SHIELD SUBWOOFER AMPLIFIER (AT LEFT SIDE OF CARGO AREA, BEHIND TRIM) TAN WIRE TAN/YEL WIRE TWISTED PAIR VBATT VIO WIRE VOL VOL WHT WIRE WHT/LT GRN WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 PROTOCOL A 1 2 3 4 5 6 7 8 9 10 AUDIO MUTE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER (-) SUBWOOFER (+) SHIELD MUTE 1 2 3 4 5 6 7 VBATT ILLUM GROUND PNK ACC RELAY ILLUM PWR WIRE 140 595 EXTERIOR LIGHTS SYSTEM ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) AIR BAG SLIDING CONTACT (BEHIND LEFT SIDE OF DASH) ANTENNA AUDIO GROUND BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/BLK WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE ELECTRONIC HIDDEN ANTENNA MODULE (EHAM) (ABOVE RIGHT REAR FUSE 22 FUSE 31 FUSE 4 FUSE 7 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT W/ ACCESSORY DELAY RELAY ENERGIZED L AUDIO OUT + R AUDIO OUT + PROTOCOL B AUDIO SYS ON LF SENS SIG VPWR LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE NCA WIRE NEXT MEDIA ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK VPWR WIRE PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) QUARTERPANEL WINDOW) RADIO RED WIRE RED/BLK WIRE RED/YEL WIRE REVERSE VOLTAGE SW SIG SHIELD L AUDIO OUT - R AUDIO OUT - SIG RTN STEERING WHEEL RADIO SWITCH SUBWOOFER (-) SUBWOOFER (+) SHIELD SUBWOOFER AMPLIFIER (AT LEFT SIDE OF CARGO AREA, BEHIND TRIM) TAN WIRE TAN/YEL WIRE TWISTED PAIR VBATT VIO WIRE VOL VOL WHT WIRE WHT/LT GRN WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LEFT DVD SIG + LEFT DVD SIG - SHIELD 1 2 3 4 5 6 7 8 9 10 MUTE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER (+) SUBWOOFER (-) SHIELD SUBWOOFER MUTE AIR BAG SLIDING CONTACT (BEHIND LEFT SIDE OF DASH) ANTENNA AUDIO SYS ON PROTOCOL A PROTOCOL B RIGHT DVD SIG + RIGHT DVD SIG - BASE BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) FUSE 4 (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DVD PLAYER FUSE 22 FUSE 31 FUSE 7 GRN WIRE GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT W/ ACCESSORY DELAY RELAY ENERGIZED LEFT FRONT SPEAKER LEFT REAR SPEAKER LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE MUTE SIGNAL LF SPEAKER - LR SPEAKER - RR SPEAKER - NAVIGATION SYSTEM 813 801 803 NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK PROTOCOL A PROTOCOL B GROUND GROUND LEFT SIG - RIGHT SIG - WIRE PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PREMIUM RADIO RADIO SIGNAL REAR INTEGRATED CONTROL PANEL (RICP) RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RR SPEAKER (+) STEERING WHEEL RADIO SWITCH SUBWOOFER (-) SUBWOOFER (+) SHIELD TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE TWISTED PAIR VBATT VIO WIRE VOL(-) VOL(+) NEXT MEDIA WHT WIRE WHT/LT GRN WIRE YEL WIRE

4.6L 5.4L BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT OF LEFT CYL HEAD) COP 8 CTRL COP 7 CTRL IMRC MODULE INJ 1 CTRL INJ 2 CTRL DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE INPUT COP 5 CTRL COP 1 CTRL REFERENCE VOLTAGE EARLY PRODUCTION EPC SOL CTRL EVR CTRL COP 4 CTRL COP 3 CTRL SIGNAL RETURN GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR KS 2 + KS 1 + CKP + CMP INPUT KS 2 - KS 1 - CKP - LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE NEAR BREAKOUT TO ORG/BLK WIRE ORG/YEL WIRE OSS SENSOR PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF FIREWALL) RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIGNAL RETURN TFT INPUT TAN WIRE TAN/BLK WIRE TAN/RED WIRE TAN/YEL WIRE TCC SOLENOID SHIFT SOL A SHIFT SOL B TPS INPUT CYL HEAD TMP SNS COP 6 CTRL VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

4.6L 5.4L BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT OF LEFT CYL HEAD) COP 8 CTRL COP 7 CTRL IMRC MODULE INJ 1 CTRL INJ 2 CTRL DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE INPUT COP 5 CTRL COP 1 CTRL REFERENCE VOLTAGE EARLY PRODUCTION EPC SOL CTRL EVR CTRL COP 4 CTRL COP 3 CTRL SIGNAL RETURN GRY WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR KS 2 + KS 1 + CKP + CMP INPUT KS 2 - KS 1 - CKP - LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE NEAR BREAKOUT TO ORG/BLK WIRE ORG/YEL WIRE OSS SENSOR PNK/LT BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF FIREWALL) RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIGNAL RETURN TFT INPUT TAN WIRE TAN/BLK WIRE TAN/RED WIRE TAN/YEL WIRE TCC SOLENOID SHIFT SOL A SHIFT SOL B TPS INPUT CYL HEAD TMP SNS COP 6 CTRL VIO/LT GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/PNK WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE