Ford Expedition II (2002-2006) gry/yel Wiring diagrams

AIR SUSPENSION MODULE, BRAKE SHIFT INTERLOCK, ELECTRONIC COMPASS BLK WIRE BLK/WHT WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (RIGHT KICK PANEL) DIFFERENTIAL PRESSURE FEEDBACK EGR SENSOR ENGINE CONTROLS SYSTEM FOUR WHEEL DRIVE CONTROL MODULE (AT LEFT "P" PILLAR) FUSE 28 FUSE 27 FUSE 32 FUSE 34 GROUND GRY WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HEATED OXYGEN SENSORS, TURBINE SHAFT SPEED SENSOR, IDLE AIR CONTROL MODULE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT INTAKE AIR TEMPERATURE (IAT) SENSOR (IN INTAKE SYSTEM) LT BLU/RED WIRE LT BLU/YEL WIRE MAF OUTPUT MAF SIG RTN MASS AIRFLOW (MAF) SENSOR (IN INTAKE SYSTEM) NCA WIRE OD CANCEL SW OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/ORG WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF FIREWALL) POWERTRAIN CONTROL MODULE, FUEL INJECTORS RED WIRE TAN/LT BLU WIRE TAN/WHT WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TPS SIGNAL VIO/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 LEFT FRONT MOTOR 1 2 POWER GROUND 1474 1490 1471 1489 447 1466 1465 1464 444 ADJUSTABLE PEDAL CIRCUIT 956 1906 268 267 270 875 1491 1493 1492 272 COMPUTER DATA LINES SYSTEM ADJUSTABLE PEDAL CIRCUIT ADJUSTABLE PEDAL MEMORY POTENTIOMETER (ON ACCELERATOR PEDAL SUPPORT) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) FUSE 3 DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DRIVER MEMORY SEAT FRONT HEIGHT SENSOR (UNDER DRIVER SEAT) DRIVER MEMORY SEAT HORIZONTAL SENSOR (UNDER DRIVER SEAT) DRIVER MEMORY SEAT REAR HEIGHT SENSOR (UNDER DRIVER SEAT) DRIVER SEAT FRONT HEIGHT MOTOR DRIVER SEAT HORIZONTAL MOTOR (UNDER DRIVER SEAT) DRIVER SEAT MODULE DRIVER SEAT MODULE (UNDER DRIVER'S SEAT) DRIVER SEAT REAR HEIGHT MOTOR (UNDER DRIVER SEAT) ENTIRE SEAT FRONT OF SEAT FUSE 109 GRN WIRE GRY WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT FRONT LUMBAR ADJUST SWITCH LEFT HORIZ MOTOR LEFT REAR MOTOR LEFT FRONT MOTOR LEFT POWER SEAT SWITCH LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MEMORY MIRRORS CIRCUIT MEMORY SET SWITCH NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE ORG/WHT WIRE PNK/BLK WIRE PNK/ORG WIRE REAR OF SEAT RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RIGHT MIRR L/R POSIT SENS RIGHT MIRR U/D POSIT SENS MIRR POSIT SENSOR FEED RWD SEAT POSITION SENSOR SET 1 SET 2 SET- VIO WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

1 3 4 15 19 VBATT SPEED SENSOR VBATT VBATT GROUND AIR SUSPENSION MODULE (UNDER LEFT SIDE OF DASH) BLK/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM DK BLU WIRE FUSE 20 FUSE 27 GRY/BLK WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/LT BLU WIRE POWER STEERING VALVE SOLENOID (ON FRONT OF ENGINE) POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) TWISTED PAIR UBP BUS VIO WIRE VSS

1 2 3 4 5 6 7 8 9 10 11 12 13 SOL - SOL + 1 2 PNK WIRE AIR SUSPENSION COMPRESSOR ASSEMBLY (AT RIGHT FRONT OF ENGINE COMPT) AIR SUSPENSION COMPRESSOR RELAY (AT RIGHT FRONT OF ENGINE COMPT) AIR SUSPENSION MODULE (UNDER LEFT SIDE OF DASH) AIR SUSPENSION SERVICE SWITCH (AT LEFT REAR CORNER OF VEHICLE) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BRN/BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/YEL WIRE ELECTRONIC POWER STEERING SYSTEM FOUR WHEEL DRIVE CONTROL MODULE (AT LEFT "B" PILLAR) FUSE 11 FUSE 111 FUSE 20 FUSE 27 GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR RUN LEFT FRONT HEIGHT SENSOR (AT LEFT FRONT SHOCK TOWER) LEFT FRONT SHOCK ABSORBER SOLENOID VALVE (ON LEFT FRONT SHOCK TOWER) LEFT REAR SHOCK ABSORBER SOLENOID VALVE (ON LEFT REAR SHOCK TOWER) LR SOL VLV RR SOL VLV LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/LT BLU WIRE ORG/RED WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE(PCM) (ON RIGHT SIDE OF FIREWALL) REAR HEIGHT SENSOR (UNDER REAR OF VEHICLE, NEAR AXLE) RED/BLK WIRE RIGHT FRONT HEIGHT SENSOR (AT RIGHT FRONT SHOCK TOWER) RIGHT FRONT SHOCK ABSORBER SOLENOID VALVE (ON RIGHT FRONT SHOCK TOWER) RIGHT REAR SHOCK ABSORBER SOLENOID VALVE (ON RIGHT REAR SHOCK TOWER) SERVICE SWITCH UBP BUS HEIGHT SENS FEED HEIGHT SENS SIG HEIGHT SENS RTN TAN WIRE VIO WIRE VIO/LT GRN WIRE VIO/WHT WIRE VSS

12 6 11 5 4 VREF VREF VREF VREF VREF 19 (OR 505) HEADLIGHTS SYSTEM 1718 1436 158 703 702 1002 4 3 2 1 GND VPWR 470 (OR 1794) ABS IND. AIR BAG IND AMBIENT AIR TEMPERATURE SENSOR (BEHIND RADIATOR GRILLE) AUTO PARK BRAKE RELEASE SOLENOID (AT DRIVER'S FOOTWELL) AUXILIARY RELAY BOX 3 (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) CHARGE IND CHECK ENGINE IND CHECK SUSPENSION IND CLOCK (NAVIGATOR) COMPUTER DATA LINES SYSTEM DEFOGGER SYSTEM EXTERIOR LIGHTS SYSTEM DK BLU/ORG WIRE DK GRN WIRE DOOR AJAR IND ELECTRONIC COMPASS ELECTRONIC PARK BRAKE RELEASE RELAY ELECTRONIC PARK BRAKE RESET RELAY ESP IND FUEL TANK UNIT (IN FUEL TANK) FUSE 1 FUSE 15 FUSE 18 FUSE 21 FUSE 27 FUSE 5 GRY (OR DK GRN/VIO) WIRE GRY WIRE GRY/ORG WIRE GRY/YEL WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN INSTRUMENT CLUSTER INTERIOR LAMP RELAY INTERIOR LIGHTS SYSTEM (BEHIND RIGHT KICK PANEL) LATE PRODUCTION EARLY PRODUCTION LCD DISPLAY IND LEFT FRONT DOOR AJAR SWITCH (AT REAR OF LEFT FRONT DOOR) LEFT TURN SIGNAL IND LIFTGATE AJAR SWITCH (IN CENTER BOTTOM OF LIFTGATE) LIFTGATE GLASS ACTUATOR (IN LIFTGATE) LOW BRAKE FLUID LEVEL/PARK BRAKE IND LOW FUEL IND LOW OIL PRESSURE IND LOW OIL PRESSURE/HIGH COOLANT TEMPERATURE IND LOW WASHER FLUID IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MESSAGE CENTER SWITCH MICROPROCESSOR NAVIGATION SYSTEM NAVIGATION SYSTEM WARNING SYSTEM NCA WIRE O/D OFF IND ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE ORG/YEL WIRE PARKING BRAKE SWITCH (ABOVE LEFT KICK PANEL) PASSENGER SIDE REAR DOOR AJAR SWITCH (AT REAR OF RIGHT REAR DOOR) PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE POWER LIFTGATE MODULE (AT LEFT SIDE OF CARGO AREA, BEHIND TRIM) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN SIGNAL IND SAFETY BELT IND SIDE OF DASH) SPEED CONTROL IND SUPPLEMENTAL RESTRAINTS SYSTEM TAN/ORG WIRE TRACTION CONTROL IND UBP BUS VEHICLE SECURITY MODULE (VSM) (UNDER RIGHT VIO WIRE VIO/ORG WIRE VIO/WHT WIRE W/O POWER LIFTGATE W/ POWER LIFTGATE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM DEFOGGER SYSTEM POWER WINDOWS SYSTEM INTERIOR LIGHTS SYSTEM YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 VPWR BLK/LT BLU WIRE BLK/PNK WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) COMPUTER DATA LINES SYSTEM CTRL DK BLU WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSE 27 GRY/YEL WIRE HOT IN START OR RUN INNER RIGHT PARKING AID SENSOR (AT RIGHT REAR SIDE OF VEHICLE) INPUT INPUT INSTRUMENT CLUSTER ISO BUS LT BLU/WHT WIRE OUTER RIGHT PARKING AID SENSOR (AT RIGHT REAR OF VEHICLE) PARKING AID MODULE (PAM) (AT LEFT SIDE OF CARGO AREA, BEHIND TRIM) PARKING AID SPEAKER RADIO REVERSE SIG INPUT INPUT SIG SPEAKER (+) VREF SIG RTN SPEAKER (-) SWITCH SIG VIO/ORG WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE

BLK WIRE BRAKE PEDAL POSITION SWITCH (ON BRAKE PEDAL SUPPORT) BRAKE SHIFT INTERLOCK (NEAR STEERING COLUMN) CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) DK BLU WIRE FUSE GRY/YEL WIRE HOT AT ALL TIMES IGNITION SWITCH KEY REMOVAL INHIBIT SOLENOID LOCK LT GRN WIRE MICROPROCESSOR NCA WIRE OFF PARK RED WIRE RED/WHT WIRE RUN WIRE VIO WIRE YEL WIRE

1 2 3 4 GND PWR GND PWR 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 UPB BUS 4 3 2 1 GND PWR 4 3 2 1 PWR PWR GND VBATT BLK WIRE BRN WIRE BRN/LT BLU WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND RIGHT KICK PANEL) FUSE 110 COMPUTER DATA LINES SYSTEM DEPLOYED SENSOR DK GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FLOOR SHIFTER FUSE 105 FUSE 5 GND VPWR GRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES LEFT LIFTGATE OBSTACLE DETECTION STRIP (AT LOWER LEFT SIDE OF CARGO AREA) LIFTGATE CHIME MODULE LIFTGATE CINCHING MOTOR (IN RIGHT SIDE OF LIFTGATE) LIFTGATE FORK BOLT/DETENT SWITCH (AT CENTER BOTTOM OF LIFTGATE) LIFTGATE GLASS ACTUATOR (IN LIFTGATE) LIFTGATE HOME POSITION SWITCH (IN RIGHT SIDE OF LIFTGATE) LIFTGATE UNLATCH MOTOR (IN RIGHT SIDE OF LIFTGATE) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MICROPROCESSOR MOTOR NCA WIRE OPTICAL SENSOR LEFT LIFTGATE DRIVE MOTOR ASSEMBLY (AT REAR OF ROOF) ORG/LT BLU WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER LIFTGATE OPEN/CLOSE SWITCH RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE RIGHT LIFTGATE DRIVE MOTOR ASSEMBLY (AT REAR OF ROOF) RIGHT LIFTGATE OBSTACLE DETECTION STRIP (AT LOWER RIGHT SIDE OF CARGO AREA) SHIFT INTERLOCK SYSTEM SIG RTN STOWED SENSOR TAN/LT BLU WIRE VBATT VEHICLE SECURITY MODULE (VSM) (UNDER RIGHT SIDE OF DASH) VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VPWR VPWR VPWR GND VPWR +/- VREF PWR VREF VREF VREF VREF VREF VREF VBATT VREF W/ POWER FOLDING SEATS WHT WIRE WHT/PNK WIRE WHT/VIO WIRE WHT/YEL WIRE WIPER/ WASHER SYSTEM YEL WIRE

A/C SYSTEM ANTI-THEFT SYSTEM A/C SYSTEM TRANSMISSION SYSTEM STARTING SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (RIGHT KICK PANEL) CHARGING SYSTEM CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (UNDER DRIVER SIDE DASH PANEL) DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUEL PUMP ASSEMBLY (FUEL TANK) FUEL PUMP RELAY FUEL TANK PRESSURE TRANSDUCER SENSOR (IN FUEL TANK) FUSE 28 FUSE 27 FUSE 32 FUSE 34 FUSE 33 FUSE 5 FUSE 9 GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT SW POWER OUT IGNITION SWITCH INERTIA FUEL SHUT-OFF SWITCH (LEFT REAR CORNER OF CARGO AREA) INSTRUMENT CLUSTER SYSTEM LOCK OFF LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE NCA WIRE OD CANCEL SW GROUND SERVO SIG B ORG/LT BLU WIRE ORG/RED WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SERVO COMMON F PUMP RLY CTRL ST WHL CTRL GND TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE VIO WIRE VIO/WHT WIRE VIO/YEL WIRE WHT/LT GRN WIRE YEL/WHT WIRE

A/C SYSTEM ANTI-THEFT SYSTEM A/C SYSTEM TRANSMISSION SYSTEM STARTING SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (RIGHT KICK PANEL) CHARGING SYSTEM CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (UNDER DRIVER SIDE DASH PANEL) DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUEL PUMP ASSEMBLY (FUEL TANK) FUEL PUMP RELAY FUEL TANK PRESSURE TRANSDUCER SENSOR (IN FUEL TANK) FUSE 28 FUSE 27 FUSE 32 FUSE 34 FUSE 33 FUSE 5 FUSE 9 GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT SW POWER OUT IGNITION SWITCH INERTIA FUEL SHUT-OFF SWITCH (LEFT REAR CORNER OF CARGO AREA) INSTRUMENT CLUSTER SYSTEM LOCK OFF LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE NCA WIRE OD CANCEL SW GROUND SERVO SIG B ORG/LT BLU WIRE ORG/RED WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SERVO COMMON F PUMP RLY CTRL ST WHL CTRL GND TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE VIO WIRE VIO/WHT WIRE VIO/YEL WIRE WHT/LT GRN WIRE YEL/WHT WIRE