Automatic a/c circuit for Ford Expedition I (1996-2002)

8 9 10 11 12 13 14 21 22 23 24 25 26 STEERING WHL SW BLEND DOOR ACT GND A/C PRESS CUTOFF SIG AIR BAG SLIDING CONTACT (AT BASE OF STEERING COLUMN) AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR SPEED CONTROLLER (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 2 DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FUSE 105 FUSE 13 FUSE 22 FUSE 23 HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IN-CAR TEMPERATURE SENSOR (BEHIND CENTER OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE NCA WIRE ORG/ WIRE PNK WIRE PNK/ 1 2 3 4 5 6 7 15 16 17 18 19 20 WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE SOLID STATE SPC (-) BATTERY GROUND SENSOR INPUT GND STEERING COLUMN ASSEMBLY SUNLOAD SENSOR (TOP RIGHT SIDE OF DASH) TAN/ORG WIRE VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

ANTI-LOCK BRAKES SYSTEM AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CONSOLE BLOWER RELAY DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER CENTER OF DASH) DK GRN/YEL WIRE FUSE 23 FUSE 7 GRY WIRE GRY/LT BLU WIRE GRY/WHT WIRE HOT IN RUN INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT GRN WIRE PNK WIRE PNK/ (MAIN HARNESS, NEAR BREAKOUT TO PASSENGER AIR BAG) WIRE PNK/ 15 16 41 69 WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPARTMENT) REAR MODE POTENTIOMETER RED WIRE RED/YEL WIRE RPO RELAY BLOCK 1 (BEHIND RIGHT SIDE OF DASH, ABOVE PASSENGER AIR BAG) SOLID STATE TAN WIRE TAN/ORG WIRE VIO WIRE W/O ROOF OPENING PANEL WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE WOT RELAY YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

0.6 OHMS 2 OHMS 2.7 OHMS 3.8 OHMS 4.6L 5.4L A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT REAR CORNER OF ENGINE COMPARTMENT) A/C CLUTCH DIODE A/C COMPRESSOR CLUTCH SOLENOID (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C PRESSURE CUT-OFF SWITCH (IN RIGHT SIDE OF ENGINE COMPARTMENT) AUXILIARY A/C BLOWER MOTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C BLOWER MOTOR RESISTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C RELAY BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE 114 BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE CONSOLE BLEND DOOR ACTUATOR (INSIDE LEFT CENTER OF FLOOR CONSOLE) CONSOLE BLOWER MOTOR (INSIDE CENTER OF FLOOR CONSOLE) CONSOLE BLOWER MOTOR RESISTOR (IN CENTER OF FLOOR CONSOLE) DK BLU/WHT WIRE DK DK DK GRN/YEL WIRE FRONT BLOWER MOTOR SWITCH GRY/WHT WIRE HOT AT ALL TIMES LOW MED LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT LT MED OFF OFF LOW OFF LOW MED OFF REAR ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE REAR BLOWER MOTOR SWITCH REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RPO RELAY BLOCK 2 (IN FRONT OF LEFT REAR WHEELWELL) VIO WIRE W/O ROOF OPENING PANEL WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE