Ford Expedition I (1996-2002) yel/lt grn Wiring diagrams

AIR CONDITIONING SYSTEM AUTOLAMP MODULE, INSTRUMENT CLUSTER BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND EPC OSS TP VREF SIG RTN BOO VPWR PWR GND COAST CLUTCH CONTROL CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE DK LT DK PNK WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY PNK BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC TSS RED WIRE RED/LT GRN WIRE SHIFT CONTROL 1 SHIFT CONTROL 2 SPEED CONTROL TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA DLC (-) DLC (+) CCS TCS TFT IAT THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

3 6 11 12 13 15 16 570 237 315 911 107 915 914 PWR GND AIR CONDITIONING SYSTEM AUTOLAMP MODULE BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND EPC OSS TP VREF SIG RTN BOO VPWR PWR GND CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK LT ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY PNK BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC RED WIRE RED/LT GRN WIRE SHIFT SOLENOIDS (SS) SPEED CONTROL TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA DLC (-) DLC (+) TFT IAT THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

0.6 OHMS 2 OHMS 2.7 OHMS 3.8 OHMS 4.6L 5.4L A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT REAR CORNER OF ENGINE COMPARTMENT) A/C CLUTCH DIODE A/C COMPRESSOR CLUTCH SOLENOID (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C PRESSURE CUT-OFF SWITCH (IN RIGHT SIDE OF ENGINE COMPARTMENT) AUXILIARY A/C BLOWER MOTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C BLOWER MOTOR RESISTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C RELAY BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE 114 BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE CONSOLE BLEND DOOR ACTUATOR (INSIDE LEFT CENTER OF FLOOR CONSOLE) CONSOLE BLOWER MOTOR (INSIDE CENTER OF FLOOR CONSOLE) CONSOLE BLOWER MOTOR RESISTOR (IN CENTER OF FLOOR CONSOLE) DK BLU/WHT WIRE DK DK DK GRN/YEL WIRE FRONT BLOWER MOTOR SWITCH GRY/WHT WIRE HOT AT ALL TIMES LOW MED LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT LT MED OFF OFF LOW OFF LOW MED OFF REAR ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE REAR BLOWER MOTOR SWITCH REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RPO RELAY BLOCK 2 (IN FRONT OF LEFT REAR WHEELWELL) VIO WIRE W/O ROOF OPENING PANEL WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 SEAT POSITION SENSOR (+) 1 2 POWER GROUND 1476 1477 (LOWER LEFT INNER KICK PANEL) POWER MIRRORS SYSTEM ADJ. BRAKE PEDAL CIRCUIT ADJ. BRAKE PEDAL CIRCUIT (1998-99) (2000) ADJUSTABLE PEDAL MOTOR (1999-2000 ONLY) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BRN/LT GRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (UNDER CENTER OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DRIVER POWER LUMBER SWITCH (2000 ONLY) DRIVER POWER MOTOR SEAT ASSEMBLY DRIVER POWER SEAT CONTROL SWITCH DRIVER SEAT MODULE (UNDER DRIVER'S SEAT) ENTIRE SEAT FRONT HEIGHT MOTOR FRONT OF SEAT FUSE 20 FUSE 4 FWD/RWD MOTOR GRY WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT FRONT MOTOR LEFT HORIZ MOTOR PEDAL SENSOR PEDAL FORWARD LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MEM 1 MEM 2 MEMORY SEAT SWITCH NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE ORG/WHT WIRE PEDAL, MIRROR MODULE) PNK/BLK WIRE POWER MIRRORS SYSTEM POWER MIRRORS SYSTEM 954 951 REAR HEIGHT MOTOR REAR OF SEAT RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RWD SET- VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLOCK 1 (BEHIND RIGHT SIDE OF DASH) CLIMATE CONTROL SYSTEM DK BLU WIRE DK GRN/ORG WIRE DK/BLU WIRE FUSE 7 HORN RELAY HORN SWITCH HORN- RIGHT HOT AT ALL TIMES NCA WIRE REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND LEFT SIDE OF DASH) RPO RELAY SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPT) STEERING COLUMN ASSEMBLY YEL/LT BLU WIRE YEL/LT GRN WIRE

AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE OF PANEL) AUXILIARY A/C MODE ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK LT GRN/ WIRE BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BRN WIRE BRN/ WHT WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COLD BLEND DOOR POTENT- IOMETER DK GRN/YEL WIRE FUSE 23 FUSE 5 FUSE 7 GRY/ LT BLU WIRE GRY/LT BLU WIRE HOT IN RUN HOT IN RUN CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 22 ILLUMINATION LT BLU GRY/ WIRE LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/WHT WIRE MAX A/C NORM A/C MED HIGH HIGH BLOWER MOTOR SWITCH MED LOW ORG/ BRN WIRE ORG/BLK WIRE PAN, FLR FLOOR FLR, DEF DEF MODE SELECTOR SWITCH PAN/FLR FLOOR DEF/FLR DEF MAX A/C NORM A/C PANEL OFF PANEL OFF PNK WIRE PNK/ LT GRN WIRE PNK/LT GRN WIRE REAR MODE POTENTIOMETER RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/WHT WIRE SOLID STATE SOLID STATE 5 6 7 8 SUPPLEMENTAL RESTRAINTS SYSTEM VIO WIRE VIO/ORG WIRE W/O ROOF OPENING PANEL WARM FUNCTION SELECTOR SWITCH ASSEMBLY WHT BRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

0.6 OHMS 2.7 OHMS 3.8 OHMS 3.8 OHMS 2.7 OHMS 0.6 OHMS 4.6L 5.4L 69 41 331 347 WOT RELAY ACCS A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT REAR CORNER OF ENGINE COMPARTMENT) A/C CLUTCH DIODE A/C COMPRESSOR CLUTCH SOLENOID (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C PRESSURE CUT-OFF SWITCH (IN RIGHT SIDE OF ENGINE COMPARTMENT) AUXILIARY A/C BLOWER MOTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C BLOWER MOTOR RESISTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C RELAY BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK ORG/ WIRE BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CONSOLE BLOWER MOTOR (INSIDE CENTER OF FLOOR CONSOLE) DK BLU/WHT WIRE DK GRN/YEL WIRE FRONT BLOWER MIOTOR SWITCH FUSE 114 FUSE 13 FUSE 23 GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LOW MED LT BLU PNK/ WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE OFF OFF LOW MED OFF REAR ORG RED/ WIRE ORG-LT BLU WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/ WHT WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPARTMENT) REAR BLOWER MOTOR SWITCH REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED ORG/ WIRE RED YEL/ WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RPO RELAY BLOCK 2 (IN FRONT OF LEFT REAR WHEELWELL) VIO WIRE W/O ROOF OPENING PANEL W/ROOF PANEL OPENING WHT LT GRN/ WIRE WHT WIRE WHT/ DK BLU WIRE WHT/LT BLU WIRE WOT RELAY YEL BLK/ WIRE YEL RED/ WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

BATTERY JUNCTION BOX BATTERY SAVER RELAY BLK WIRE BRN WIRE CENTRAL JUNCTION BOX CIRCUIT BREAKER 601 DELAY RELAY FUSE 103 FUSE 14 GENERIC ELEC- TRONIC MODULE GRY WIRE HOT AT ALL TIMES LEFT FRONT POWER WINDOW MOTOR LEFT FRONT POWER WINDOW SWITCH LEFT REAR POWER WINDOW SWITCH LEFT REAR SWITCH LEFT SWITCH LOCK OUT LT BLU WIRE LT GRN WIRE ONE-TOUCH DOWN RELAY ORG/ WIRE OTD SWITCH RED WIRE RIGHT FRONT POWER WINDOW SWITCH RIGHT REAR POWER WINDOW MOTOR RIGHT REAR POWER WINDOW SWITCH DN RIGHT REAR SWITCH RIGHT SWITCH SHUNT (0.015 +/-10%) TAN WIRE UP DN WHT WIRE YEL WIRE YEL/LT GRN WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 15 FUSE 2 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 KS PWR GND IGN COIL 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE WOT RELAY YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 15 FUSE 2 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND IGN COIL 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE TSS VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE WOT RELAY YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE