Ford Expedition I (1996-2002) wht/vio Wiring diagrams

8 9 10 11 12 13 14 21 22 23 24 25 26 STEERING WHL SW BLEND DOOR ACT GND A/C PRESS CUTOFF SIG AIR BAG SLIDING CONTACT (AT BASE OF STEERING COLUMN) AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR SPEED CONTROLLER (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 2 DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FUSE 105 FUSE 13 FUSE 22 FUSE 23 HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IN-CAR TEMPERATURE SENSOR (BEHIND CENTER OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE NCA WIRE ORG/ WIRE PNK WIRE PNK/ 1 2 3 4 5 6 7 15 16 17 18 19 20 WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE SOLID STATE SPC (-) BATTERY GROUND SENSOR INPUT GND STEERING COLUMN ASSEMBLY SUNLOAD SENSOR (TOP RIGHT SIDE OF DASH) TAN/ORG WIRE VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

ANTI-LOCK BRAKES SYSTEM AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CONSOLE BLOWER RELAY DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER CENTER OF DASH) DK GRN/YEL WIRE FUSE 23 FUSE 7 GRY WIRE GRY/LT BLU WIRE GRY/WHT WIRE HOT IN RUN INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT GRN WIRE PNK WIRE PNK/ (MAIN HARNESS, NEAR BREAKOUT TO PASSENGER AIR BAG) WIRE PNK/ 15 16 41 69 WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPARTMENT) REAR MODE POTENTIOMETER RED WIRE RED/YEL WIRE RPO RELAY BLOCK 1 (BEHIND RIGHT SIDE OF DASH, ABOVE PASSENGER AIR BAG) SOLID STATE TAN WIRE TAN/ORG WIRE VIO WIRE W/O ROOF OPENING PANEL WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE WOT RELAY YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ABS ACTIVE IN AIR SUSPENSION OUT TRANSFER CASE RETURN BRAKE PEDAL POSITION SWITCH ANTI-LOCK BRAKES SYSTEM (ABS CONTROL MODULE) ANTI-THEFT SYSTEM (RAP MODULE) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE DEFOGGER SYSTEM (REAR DEFOGGER SWITCH) DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DOOR AJAR OUT GENERIC ELECTRONIC MODULE (GEM) (BEHIND LEFT SIDE OF DASH) GRY/LT BLU WIRE LOW WASHER FLUID OUT REAR WASHER PUMP RELAY OUT WASHER FLUID LEVEL SWITCH IN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PNK/BLK WIRE PNK/YEL WIRE REAR SHAFT SPEED SENSOR IN FRONT SHAFT SPEED SENSOR IN REAR WIPER SWITCH IN RED/LT GRN WIRE RED/WHT WIRE TAN WIRE TAN/RED WIRE TAN/YEL WIRE TRANSMISSION CONTROLS SYSTEM (TRANSFER CASE ASSEMBLY) VIO/YEL WIRE WHT WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM (MULTI-FUNCTION SWITCH) YEL/LT BLU WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 SEAT POSITION SENSOR (+) 1 2 POWER GROUND 1476 1477 (LOWER LEFT INNER KICK PANEL) POWER MIRRORS SYSTEM ADJ. BRAKE PEDAL CIRCUIT ADJ. BRAKE PEDAL CIRCUIT (1998-99) (2000) ADJUSTABLE PEDAL MOTOR (1999-2000 ONLY) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BRN/LT GRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (UNDER CENTER OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DRIVER POWER LUMBER SWITCH (2000 ONLY) DRIVER POWER MOTOR SEAT ASSEMBLY DRIVER POWER SEAT CONTROL SWITCH DRIVER SEAT MODULE (UNDER DRIVER'S SEAT) ENTIRE SEAT FRONT HEIGHT MOTOR FRONT OF SEAT FUSE 20 FUSE 4 FWD/RWD MOTOR GRY WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT FRONT MOTOR LEFT HORIZ MOTOR PEDAL SENSOR PEDAL FORWARD LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MEM 1 MEM 2 MEMORY SEAT SWITCH NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE ORG/WHT WIRE PEDAL, MIRROR MODULE) PNK/BLK WIRE POWER MIRRORS SYSTEM POWER MIRRORS SYSTEM 954 951 REAR HEIGHT MOTOR REAR OF SEAT RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RWD SET- VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE OF PANEL) AUXILIARY A/C MODE ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK LT GRN/ WIRE BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BRN WIRE BRN/ WHT WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COLD BLEND DOOR POTENT- IOMETER DK GRN/YEL WIRE FUSE 23 FUSE 5 FUSE 7 GRY/ LT BLU WIRE GRY/LT BLU WIRE HOT IN RUN HOT IN RUN CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 22 ILLUMINATION LT BLU GRY/ WIRE LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/WHT WIRE MAX A/C NORM A/C MED HIGH HIGH BLOWER MOTOR SWITCH MED LOW ORG/ BRN WIRE ORG/BLK WIRE PAN, FLR FLOOR FLR, DEF DEF MODE SELECTOR SWITCH PAN/FLR FLOOR DEF/FLR DEF MAX A/C NORM A/C PANEL OFF PANEL OFF PNK WIRE PNK/ LT GRN WIRE PNK/LT GRN WIRE REAR MODE POTENTIOMETER RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/WHT WIRE SOLID STATE SOLID STATE 5 6 7 8 SUPPLEMENTAL RESTRAINTS SYSTEM VIO WIRE VIO/ORG WIRE W/O ROOF OPENING PANEL WARM FUNCTION SELECTOR SWITCH ASSEMBLY WHT BRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

1999 ONLY BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (UNDER CENTER OF DASH) DEFOGGER SYSTEM DIRECT- TIONAL SWITCH DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DRIVER SEAT MODULE (UNDER DRIVER'S SEAT) FUSE 4 GRY WIRE GRY/RED WIRE HORIZ HORIZ MTR HOT AT ALL TIMES LEFT EXTERIOR REAR VIEW MIRROR LEFT HEATED MIRROR LEFT/RIGHT MIRROR SELECT SWITCH LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE POWER MIRROR SWITCH RED WIRE RED/ORG WIRE RED/WHT WIRE RIGHT EXTERIOR REAR VIEW MIRROR RIGHT HEATED MIRROR VERT VERT MTR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/RED WIRE

AIR SUSPENSION COMPRESSOR RELAY 4 WHEEL ANTI-LOCK BRAKE SYSTEM ALL LOCK RELAY ALL UNLOCK RELAY AUXILIARY A/C RELAY AUXILIARY POWER SOCKET BATTERY BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BRN/WHT WIRE CD CHANGER REAR INTEGRATED CONTROL PANEL CELLULAR TELEPHONE SUPPORT ELECTRONICS RADIO SUBWOOFER AMPLIFIER CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CONSOLE AUXILIARY POWER SOCKET DK BLU/ORG WIRE DK GRN/YEL WIRE DRIVER'S UNLOCK RELAY FOG LAMP RELAY DAYTIME RUNNING LAMPS RESISTOR FROM FUSE 8 (DIAGRAM 1 OF 4) FUSE 1 FUSE 101 FUSE 103 FUSE 107 FUSE 11 FUSE 114 FUSE 109 FUSE 102 FUSE 12 FUSE 13 FUSE 31 FUSE 4 FUSE 3 FUSE 5 FUSE 6 FUSE 7 FUSE 8 FUSE 9 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- GENERATOR GRY WIRE HEADLAMP RELAY HORN RELAY LOCK RELAY BLOCK LT BLU WIRE LT BLU/PNK WIRE LT GRN/VIO WIRE MAIN LIGHT SWITCH MODULE NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE PARK LAMP RELAY PASSENGER POWER SEAT CONTROL SWITCH PASSENGER POWER LUMBAR SWITCH PNK/LT BLU WIRE PNK/WHT WIRE REAR WIPER DOWN RELAY REAR WIPER UP RELAY RED WIRE RED/ WHT WIRE RPO RELAY BLOCK 1 RPO RELAY BLOCK 2 MULTI- FUNCTION SWITCH STARTER MOTOR STARTER MOTOR RELAY TAN/BLK WIRE TAN/WHT WIRE TO FUSE 103 (DIAGRAM 1 OF 4) TO FUSE 104 (DIAGRAM 2 OF 4) TO FUSE 2 (DIAGRAM 3 OF 4) TRAILER TOW BACK-UP LAMP RELAY TRAILER TOW BATTERY CHARGE RELAY TRAILER TOW RUNNING LAMP RELAY VIO/ORG WIRE W/O LUMBAR WHT RED/ WIRE WHT/VIO WIRE WOT RELAY YEL WIRE YEL/LT BLU WIRE

13 10 2 2 (OTHERS) 4-WHEEL ANTI-LOCK BRAKE SYSTEM AUXILIARY A/C BLEND ACTAUTOR AUXILIARY A/C CONTROL MODULE AUXILIARY A/C MODE ACTUATOR AUXILIARY A/C RELAY BATTERY JUNCTION BOX BLOWER/ FLASHER RELAY BLOCK BLK WIRE BLOWER RELAY BLOWER/ FLASHER RELAY BLOCK BRAKE PEDAL POSITION SWITCH BRAKE PRESSURE SWITCH CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CIGAR LIGHTER CONSOLE BLOWER RELAY DATA LINK CONNECTOR DRIVER HEATED SEAT MODULE DRIVER HEATED SEAT SWITCH DRIVER TEMPERATURE CONTROLLED SEAT MODULE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE ELECTRONIC DAY/ NIGHT MIRROR FLASHER RELAY FROM FUSE 4 (DIAGRAM 3 OF 4) FROM IGNITION SWITCH (DIAGRAM 2 OF 4) FUSE 13 FUSE 15 FUSE 22 FUSE 23 FUSE 3 FUSE 7 GENERIC ELECTRONIC MODULE GRY WIRE LT BLU WIRE LT BLU/WHT WIRE LT GRN/RED WIRE MODE SWITCH NCA WIRE OVERHEAD CONSOLE PASSENGER HEATED SEAT MODULE PASSENGER HEATED SEAT SWITCH FUNCTION SELECTOR SWITCH ASSEMBLY PASSENGER TEMPERATURE CONTROLLED SEAT MODULE PNK/LT BLU WIRE REAR INTEGRATED CONTROL PANEL RED WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE RPO RELAY BLOCK 1 RPO RELAY BLOCK 2 TAN/RED WIRE TORQUE ON-DEMAND (TOD) RELAY TRAILER TOW BATTERY CHARGE RELAY FLASHER RELAY VIO WIRE VIO/ORG WIRE W/CLIMATE CONTROLLED SEATS W/HEATED SEATS W/O EATC WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND GROUND 1 2 3 4 5 6 7 8 9 10 HIGH AUDIO MUTE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER (-) SUBWOOFER (+) AUDIO SHIELD HIGH AUDIO MUTE 19 57 694 INTERIOR LIGHTS 434 57 1000 57 802 803 805 811 797 1499 694 800 801 804 813 694 INTERIOR LIGHTS AIR BAG SLIDING CONTACT AMP L REAR (+) AMP R REAR (+) AUDIO ON AUDIO SYSTEM ON AUDIO NETWORK AUDIO NETWORK AUDIO/ CLIMATE CONTROL SWITCH ASSEMBLY BAND MEM UP DWN BARE BLK WIRE BLK/LT GRN WIRE BODY COMPUTER BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CD CHANGER CELLULAR PHONE WIRING CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK GRN/ORG WIRE DK GRN/VIO WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE (BEHIND CENTER OF DASH) FUSE 1 FUSE 20 FUSE 31 GENERIC ELECTRONIC MODULE GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN LEFT FRONT SPEAKER LEFT REAR SPEAKER LEFT SIG (-) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK/LT GRN WIRE POWER POWER SUBWOOFER (+) SUBWOOFER (-) PROTOCOL A PROTOCOL B PROTOCOL B PROTOCOL A R REAR SIG (-) R REAR SIG (+) L REAR SIG (-) L REAR SIG (+) POWER AUDIO SYTEM ON RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT SIG SHIELD SUB SPEAKER (-) SUBWOOFER SUBWOOFER AMPLIFIER TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VSS WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND GROUND 19 57 694 INTERIOR LIGHTS AMP L REAR (+) AMP R REAR (+) ANTENNA AUDIO ON AUDIO SYSTEM ON AUDIO NETWORK AUDIO NETWORK BARE BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN/PNK WIRE CD CHANGER CELLULAR PHONE WIRING CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK GRN/ORG WIRE FUSE 1 FUSE 20 FUSE 31 FUSE 8 GENERIC ELECTRONIC MODULE GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LIGHTS LEFT FRONT SPEAKER LEFT REAR SPEAKER LEFT SIG (-) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWER PROTOCOL A PROTOCOL B PROTOCOL B PROTOCOL A R REAR SIG (-) R REAR SIG (+) L REAR SIG (-) L REAR SIG (+) POWER AUDIO SYTEM ON RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT SIG SHIELD TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VEHICLE SPEED SIG CELL PHONE CELL PHONE (-) CELL PHONE (+) CELL PHONE SHIELD VIO WIRE VSS WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE