Ford Expedition I (1996-2002) red/blk Wiring diagrams

1 2 3 4 5 6 7 8 9 SEAT POSITION SENSOR (+) 1 2 POWER GROUND 1476 1477 (LOWER LEFT INNER KICK PANEL) POWER MIRRORS SYSTEM ADJ. BRAKE PEDAL CIRCUIT ADJ. BRAKE PEDAL CIRCUIT (1998-99) (2000) ADJUSTABLE PEDAL MOTOR (1999-2000 ONLY) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BRN/LT GRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (UNDER CENTER OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DRIVER POWER LUMBER SWITCH (2000 ONLY) DRIVER POWER MOTOR SEAT ASSEMBLY DRIVER POWER SEAT CONTROL SWITCH DRIVER SEAT MODULE (UNDER DRIVER'S SEAT) ENTIRE SEAT FRONT HEIGHT MOTOR FRONT OF SEAT FUSE 20 FUSE 4 FWD/RWD MOTOR GRY WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT FRONT MOTOR LEFT HORIZ MOTOR PEDAL SENSOR PEDAL FORWARD LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MEM 1 MEM 2 MEMORY SEAT SWITCH NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE ORG/WHT WIRE PEDAL, MIRROR MODULE) PNK/BLK WIRE POWER MIRRORS SYSTEM POWER MIRRORS SYSTEM 954 951 REAR HEIGHT MOTOR REAR OF SEAT RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RWD SET- VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

11 12 13 14 15 16 17 18 19 20 GEM INPUT WARNING INDICATOR 1999 ONLY 421 900 57 TRANSMISSION CONTROLS AIR SUSPENSION COMPRESSOR MOTOR AND VENT SOLENOID (RIGHT RADIATOR SUPPORT) AIR SUSPENSION COMPRESSOR RELAY (NEAR RIGHT HEADLAMP) AIR SUSPENSION INDICATOR AIR SUSPENSION SERVICE SWITCH (UNDER RIGHT SIDE OF DASH) AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 109 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (UNDER CENTER OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EVO MODULE FRONT AIR FILL SOLENOID (NEAR TRANS COOLER) FRONT GATE SOLENOID (FRONT OF A/C CONDENSER) FUSE 2 FUSE 20 FUSE 4 FUSE 6 GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LEFT REAR AIR SPRING SOLENOID (IN FRONT OF LEFT REAR WHEEL) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE MEMORY SYSTEMS ORG/BLK WIRE ORG/LT GRN WIRE PNK WIRE REAR AIR FILL SOLENOID REAR HEIGHT SEN BPP SWITCH SERVICE SWITCH STEERING SENSOR POWER (START) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT REAR AIR SPRING SOLENOID (IN FRONT OF RIGHT REAR WHEEL) RUN WIRE SOLID STATE TAN WIRE TAN/WHT WIRE VIO/LT GRN WIRE VIO/ORG WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX BLK WIRE CENTRAL JUNCTION BOX DAYTIME RUNNING LAMPS RELAY 1 DAYTIME RUNNING LAMPS RELAY 2 DAYTIME RUNNING LAMPS RELAY BLOCK (BEHIND RIGHT SIDE OF DASH) DAYTIME RUNNING LAMPS RESISTOR (IN LEFT FRONT OF ENGINE COMPT) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 26 FUSE 27 FUSE 28 FUSE 3 FUSE 5 FUSE 9 GRY WIRE GRY/WHT WIRE HI BEAM INDICATOR HI LO HI PASS LO HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT FOG LAMP LEFT HEADLAMP LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH OFF HEAD PARK ORG/ WIRE ORG/LT GRN WIRE PASS PNK WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT FOG LAMP RIGHT HEADLAMP TAN WIRE WHT WIRE YEL WIRE

BATTERY JUNCTION BOX BLK WIRE CENTRAL JUNCTION BOX DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 26 FUSE 27 FUSE 28 FUSE 3 GRY WIRE GRY/WHT WIRE HI BEAM INDICATOR HI LO HI PASS LO HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX FUSE 9 INSTRUMENT CLUSTER LEFT FOG LAMP LEFT HEADLAMP LT GRN WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH OFF HEAD PARK ORG/ WIRE ORG/BLK WIRE PASS RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT FOG LAMP RIGHT HEADLAMP TAN WIRE WHT WIRE YEL WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENG COMPT) BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COLD DK BLU/ORG WIRE DK GRN/LT GRN WIRE DRIVER'S BACKREST THERMO-ELECTRIC DEVICE DRIVER'S CUSHION THERMO-ELECTRIC DEVICE DRIVER'S SEAT FAN MOTOR DRIVER'S TEMPERATURE CONTROLLED SEAT MODULE (UNDER LEFT FRONT SEAT) DRIVER'S TEMPERATURE CONTROLLED SEAT SWITCH (UNDER LEFT FRONT SEAT) FUSE 110 FUSE 23 GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN HOT OFF LT BLU WIRE LT GRN/ORG WIRE NCA WIRE OFF ON ILLUMINATION ORG/LT BLU WIRE PASSENGER'S BACKREST THERMO-ELECTRIC DEVICE PASSENGER'S CUSHION THERMO-ELECTRIC DEVICE PASSENGER'S SEAT FAN MOTOR PASSENGER'S TEMPERATURE CONTROLLED SEAT MODULE (UNDER RIGHT FRONT SEAT) PASSENGER'S TEMPERATURE CONTROLLED SEAT SWITCH (UNDER RIGHT FRONT SEAT) PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/LT BLU WIRE RUN WIRE TAN/LT BLU WIRE TEMP SENSOR FEED VIO WIRE VIO/LT BLU WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL/LT BLU WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 POWER POWER POWER ANTENNA BLK WIRE BLK/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CONVERTED SPEED DISPLAY GND DISPLAY GROUND DISPLAY ON/OFF DISPLAY SUPPLY DK BLU WIRE DK BLU/WHT WIRE FUSE 18 FUSE 2 FUSE 8 GENERIC ELECTRONIC MODULE GROUND GROUND TRANSMISSION INPUT (REV) CONVERTED SPEED GRY WIRE GRY/BLK WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN PARK OR HEAD INSTRUMENT ILLUMINATION LT BLU/RED WIRE NAVIGATION DISPLAY HOUSING (CENTER OF DASH) NAVIGATION SYSTEM MODULE (BEHIND CENTER OF DASH) NCA WIRE ORG/LT BLU WIRE PNK WIRE POWER PWM DIMMING RED WIRE RED/BLK WIRE RED/WHT WIRE REVERSE LIGHTS SPEAKER VIDEO BLUE VIDEO BLUE GND VIDEO GREEN/CSYNC VIDEO GREEN/CSYNC VIDEO BLUE VIDEO RED GND WIRE VIDEO RED WIRE VIDEO SHIELD VSS WHT WIRE WHT/LT BLU WIRE YEL/BLK WIRE YEL/BLU WIRE

ADJUSTABLE PEDAL SWITCH BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK PNK/ WIRE BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLOWER RELAY BLOWER/ FLASHER RELAY BLOCK CENTRAL JUNCTION BOX CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CIRCUIT BREAKER 601 DAYTIME RUNNING LIGHTS RELAY BLOCK DAYTIME RUNNING LIGHTS 1 RELAY DELAY RELAY DIGITAL TRANSMISSION RANGE (DTR) SENSOR DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DRIVER POWER LUMBAR SWITCH DRIVER POWER SEAT CONTROL SWITCH DRIVER SEAT MODULE DRIVER TEMPERATURE CONTROLLED SEAT MODULE DRIVER HEATED SEAT MODULE FROM FUSE 101 (DIAGRAM 1 OF 4) FRONT WASHER PUMP RELAY FUSE 104 FUSE 108 FUSE 11 FUSE 110 FUSE 111 FUSE 112 FUSE 113 FUSE 105 FUSE 116 FUSE 2 FUSE 10 FUSE 21 FUSE 5 FUSE 6 FUSE 8 GENERIC ELECTRONIC MODULE GRY WIRE GRY YEL/ WIRE GRY/YEL WIRE HEATED GRID RELAY IGNITION SWITCH INSTRUMENT CLUSTER LOCK OFF LT BLU/ORG WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE PARKING AID MODULE (PAM) OVERHEAD TRIP COMPUTER MODULE COMPASS SENSOR PARKING BRAKE RELEASE SWITCH PASSENGER HEATED SEAT MODULE PASSENGER TEMPERATURE CONTROLLED SEAT MODULE PCM POWER RELAY FUEL PUMP RELAY PNK WIRE RADIO (MAIN HARN, IN BREAKOUT TO CENTRAL JUNCTION BOX) REAR WASHER PUMP RELAY WIPER RUN/PARK RELAY WIPER HI/LO RELAY RED WIRE RED/BLK WIRE RED/LT BLU WIRE REMOTE ANTI-THEFT PERSONALITY MODULE CLOCK CELLULAR PHONE SUPPORT ELECTRONICS RUN WIRE SHIFT LOCK ACTUATOR SPEED CONTROL SERVO STEERING WHEEL ROTATION SENSOR TO FUSE 20 (DIAGRAM 3 OF 4) TO FUSE 22 (DIAGRAM 4 OF 4) TO FUSE 29 (DIAGRAM 3 OF 4) TORQUE ON-DEMAND RELAY TRANSFER CASE SHIFT RELAYS TRAILER TOW (BATTERY FEED) W/ MEMORY W/CLIMATE CONTROL W/CLIMATE CONTROL W/O CLIMATE CONTROL W/O CLIMATE CONTROL W/O MEMORY WHT/BLK WIRE WINDSHIELD WIPER MOTOR YEL WIRE YEL/BLK WIRE

ADJUSTABLE PEDAL SWITCH AIR SUSPENSION SERVICE SWITCH AIR SUSPENSION/ EVO STEERING MODULE AUTOLAMP MODULE BATTERY JUNCTION BOX BATTERY SAVER RELAY BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CLOCK POWERTRAIN CONTROL MODULE COIL ON PLUG 1 RADIO NOISE CAPACITOR 1 COIL ON PLUG 2 COIL ON PLUG 3 COIL ON PLUG 4 COIL ON PLUG 5 COIL ON PLUG 6 COIL ON PLUG 7 COIL ON PLUG 8 DIGITAL TRANSMISSION RANGE SENSOR DK BLU WIRE DK BLU/ORG WIRE DRIVER SEAT MODULE DRIVER SEAT MODULE DRIVER POWER SEAT CONTROL SWITCH ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE EXTERIOR REAR VIEW MIRROR SWITCH FROM FUSE 1 (DIAGRAM 1 OF 4) FROM FUSE 21 (DIAGRAM 2 OF 4) FROM IGNITION SWITCH (DIAGRAM 2 OF 4) FUSE 12 FUSE 14 FUSE 2 FUSE 20 FUSE 29 FUSE 30 FUSE 4 GENERIC ELECTRONIC MODULE INSTRUMENT CLUSTER INTERIOR LAMP RELAY LT GRN WIRE MEMORY SET SWITCH NAVIGATION DISPLAY HOUSING NAVIGATION SYSTEM MODULE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE OVERHEAD TRIP COMPUTER MODULE PASSIVE ANTI-THEFT SYSTEM CONTROL MODULE PCM POWER DIODE PCM POWER RELAY RADIO RADIO NOISE CAPACITOR 2 RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REMOTE ANTI-THEFT PERSONALITY MODULE TO FUSE 3 (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH VIO/ORG WIRE WHT WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 15 FUSE 2 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 KS PWR GND IGN COIL 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE WOT RELAY YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 15 FUSE 2 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND IGN COIL 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE TSS VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE WOT RELAY YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE