Ford Expedition I (1996-2002) instrument cluster Wiring diagrams

1400 OHM 4-WHEEL ANTI-LOCK BRAKE 820 OHM ANTI- LOCK IND BIAS CKT BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE 102 BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BRAKE FLUID LEVEL INDICATOR SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DIFFERENTIAL SPEED SENSOR (DSS) (ON REAR AXLE) DK GRN WIRE DK GRN/YEL WIRE FUSE 15 FUSE 23 FUSE 6 GENERIC ELECTRONIC MODULE (GEM) GROUND POWER INPUT GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN IGNITION FEED INSTRUMENT CLUSTER LEFT FRONT LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE ORG/YEL WIRE PROCESSOR MICRO- RED/LT GRN WIRE RED/PNK WIRE RIGHT FRONT SENSOR (AT WHEEL) TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE WHT WIRE WHT/ORG WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/RED WIRE

4-WHEEL ANTI-LOCK BRAKE SYSTEM AIR SUSPENSION/EVO STEERING MODULE (BEHIND CENTER OF DASH) BLK WIRE BLK/WHT WIRE DRIVER SEAT MODULE (UNDER DRIVER SEAT) (W/MEMORY SEAT) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE GENERIC ELECTRONIC MODULE (GEM) (BEHIND LEFT SIDE OF DASH) HOT AT ALL TIMES CENTRAL JUNCTION BOX FUSE 3 INSTRUMENT CLUSTER INSTRUMENT CLUSTER (XLT) LT BLU WIRE LT BLU/WHT WIRE PARKING AID MODULE (RIGHT REAR OF VEHICLE) PNK WIRE PNK/ LT BLU WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE RESTRAINTS CONTROL MODULE (RCM) (BEHIND RIGHT SIDE OF DASH) TAN/ORG WIRE VIO WIRE WHT WIRE

11 12 13 14 15 16 17 18 19 20 GEM INPUT WARNING INDICATOR 1999 ONLY 421 900 57 TRANSMISSION CONTROLS AIR SUSPENSION COMPRESSOR MOTOR AND VENT SOLENOID (RIGHT RADIATOR SUPPORT) AIR SUSPENSION COMPRESSOR RELAY (NEAR RIGHT HEADLAMP) AIR SUSPENSION INDICATOR AIR SUSPENSION SERVICE SWITCH (UNDER RIGHT SIDE OF DASH) AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 109 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (UNDER CENTER OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EVO MODULE FRONT AIR FILL SOLENOID (NEAR TRANS COOLER) FRONT GATE SOLENOID (FRONT OF A/C CONDENSER) FUSE 2 FUSE 20 FUSE 4 FUSE 6 GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LEFT REAR AIR SPRING SOLENOID (IN FRONT OF LEFT REAR WHEEL) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE MEMORY SYSTEMS ORG/BLK WIRE ORG/LT GRN WIRE PNK WIRE REAR AIR FILL SOLENOID REAR HEIGHT SEN BPP SWITCH SERVICE SWITCH STEERING SENSOR POWER (START) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT REAR AIR SPRING SOLENOID (IN FRONT OF RIGHT REAR WHEEL) RUN WIRE SOLID STATE TAN WIRE TAN/WHT WIRE VIO/LT GRN WIRE VIO/ORG WIRE YEL/BLK WIRE

BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC VARIABLE ORIFICE (EVO) ACTUATOR (LEFT SIDE OF ENGINE COMPT) ELECTRONIC VARIABLE ORIFICE (EVO) DIAGNOSTIC CONNECTOR (UNDER LEFT SIDE OF DASH) EXPEDITION ONLY FRONT HEIGHT SENSOR (BEHIND LEFT RUNNING BOARD) FUSE 11 GENERIC ELECTRONIC (GEM) MODULE (BEHIND LEFT SIDE OF DASH) GENERIC ELECTRONIC MODULE (GEM) GRY/BLK WIRE GRY/YEL WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER LT BLU/BLK WIRE LT BLU/WHT WIRE NCA WIRE ORG/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) REAR HEIGHT SENSOR (REAR FLOOR PANEL) RED WIRE RED/LT GRN WIRE RED/YEL WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPT) STEERING WHEEL ROTATION SENSOR (BEHIND STEERING WHEEL, IN DASH) TAN WIRE VIO/LT GRN WIRE WHT/YEL WIRE

AUTOLAMP MODULE (BEHIND CENTER OF DASH) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLOWER/ FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FLASHER RELAY FUSE 1 FUSE 13 FUSE 23 FUSE 6 HAZARD HEAD OFF HIGH MOUNT STOP LAMP 1 HIGH MOUNT STOP LAMP 2 HIGH MOUNT STOP LAMP 3 HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT LEFT EXTERIOR REAR VIEW MIRROR LEFT FRONT PARK/ TURN LAMP LEFT STOP/ PARK/ TURN LAMP LEFT TURN INDICATOR LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH NCA WIRE NORMAL ORG/ WIRE ORG/LT BLU WIRE PARK PARK LAMP RELAY (W/ AUTO LAMPS) RED WIRE RIGHT RIGHT EXTERIOR REAR VIEW MIRROR RIGHT LICENSE LAMP LEFT LICENSE LAMP RIGHT STOP/ PARK/ TURN LAMP RIGHT TURN INDICATOR RIGHT FRONT PARK/ TURN LAMP RPO RELAY BLOCK 1 (BEHIND RIGHT SIDE OF DASH, ABOVE PASSENGER AIR BAG) TAN WIRE TRAILER/ CAMPER ADAPTER CIRCUIT WHT WIRE YEL WIRE

4 WHEEL DRIVE MODE SWITCH AIR BAG SLIDING CONTACT 4.6L, 5.4L 4V 5.4L 2V A/C CLUTCH DIODE A/C COMPRESSOR CLUTCH SOLENOID ADJUSTABLE PEDAL SWITCH AIR SUSPENSION/ EVO STEERING MODULE ASHTRAY ILLUM- INATION GLOVE COMPT LAMP AUTOLAMP MODULE AUXILIARY A/C RELAY BATTERY BATTERY JUNCTION BOX BLK WIRE BLOWER MOTOR SPEED CONTROLLER BLOWER MOTOR RESISTOR BLOWER/FLASHER RELAY BLOCK CD CHANGER CELLULAR PHONE SUPPORT ELECTRONICS REAR INTEGRATED CONTROL PANEL CLOCK CRANKSHAFT POSITION SENSOR SHIELD DATA LINK CONNECTOR DAYTIME RUNNING LAMPS RELAY 2 DAYTIME RUNNING LAMPS RELAY 1 DAYTIME RUNNING LAMPS RELAY BLOCK DIGITAL TRANSMISSION RANGE SENSOR ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE ELECTRONIC VARIABLE ORIFICE MODULE FLASHER RELAY BLOWER RELAY FUNCTION SELECTOR SWITCH ASSEMBLY GRN WIRE INSTRUMENT CLUSTER LT BLU WIRE LT LT LT LT LT MAIN LIGHT SWITCH MASS AIRFLOW SENSOR POWERTRAIN CONTROL MODULE RADIO REAR WINDOW DEFROST SWITCH REAR WIPER UP RELAY RPO RELAY BLOCK 2 SHIFT LOCK ACTUATOR SPEED CONTROL SERVO ENGINE COMPARTMENT LAMP WINDSHIELD WIPER MOTOR SUBWOOFER AMPLIFIER RADIO TORQUE ON DEMAND RELAY BLEND DOOR ACTUATOR TRAILER TOW TRAILER TOW BRAKE CONTROL TRANSFER CASE SHIFT RELAYS W/O MEMORY WHT WIRE YEL WIRE

BATTERY JUNCTION BOX BLK WIRE CENTRAL JUNCTION BOX DAYTIME RUNNING LAMPS RELAY 1 DAYTIME RUNNING LAMPS RELAY 2 DAYTIME RUNNING LAMPS RELAY BLOCK (BEHIND RIGHT SIDE OF DASH) DAYTIME RUNNING LAMPS RESISTOR (IN LEFT FRONT OF ENGINE COMPT) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 26 FUSE 27 FUSE 28 FUSE 3 FUSE 5 FUSE 9 GRY WIRE GRY/WHT WIRE HI BEAM INDICATOR HI LO HI PASS LO HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT FOG LAMP LEFT HEADLAMP LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH OFF HEAD PARK ORG/ WIRE ORG/LT GRN WIRE PASS PNK WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT FOG LAMP RIGHT HEADLAMP TAN WIRE WHT WIRE YEL WIRE

BATTERY JUNCTION BOX BLK WIRE CENTRAL JUNCTION BOX DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 26 FUSE 27 FUSE 28 FUSE 3 GRY WIRE GRY/WHT WIRE HI BEAM INDICATOR HI LO HI PASS LO HOT AT ALL TIMES HOT AT ALL TIMES BATTERY JUNCTION BOX FUSE 9 INSTRUMENT CLUSTER LEFT FOG LAMP LEFT HEADLAMP LT GRN WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH OFF HEAD PARK ORG/ WIRE ORG/BLK WIRE PASS RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT FOG LAMP RIGHT HEADLAMP TAN WIRE WHT WIRE YEL WIRE

4 WHEEL ANTI- LOCK BRAKE SYSTEM MODULE (ON LEFT SIDE OF ENGINE COMPT) 820 OHMS AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) AIRBAG IND ANTI-LOCK BRAKES SYSTEM ANTI-LOCK IND BELT MINDER MODULE (BEHIND CENTER OF DASH) (2001) BIAS CKT BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE FLUID LEVEL INDICATOR SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE IND CENTRAL JUNCTION BOX CHARGE IND CHECK SUSPENSION IND CLOCK COMPUTER DATA LINES SYSTEM CONN A CONN B CRUISE CONTROL IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE DOOR AJAR IND ENGINE OIL PRESSURE SWITCH (ON LEFT FRONT OF ENGINE, NEXT TO P/S PUMP) FASTEN SAFETY BELT IND FUEL PUMP ASSEMBLY (UNDER VEHICLE, AT FUEL TANK) FUEL PUMP MODULE FUSE 18 FUSE 2 FUSE 30 FUSE 6 FUSE 8 GENERIC ELECTRONIC MODULE (BEHIND LEFT SIDE OF DASH) GRY WIRE GRY/ORG WIRE GRY/WHT WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN PARK OR HEAD HOT IN RUN HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LEFT TURN IND LOW FUEL IND LOW OIL/HIGH COOLANT IND LOW WASHER FLUID IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION INDICATOR MICRO- PROCESSOR MICROPROCESSOR NCA WIRE ORG/LT BLU WIRE OVERHEAD TRIP COMPUTER MODULE (IN FRONT OF OVERHEAD CONSOLE) PARKING BRAKE SWITCH (ON RIGHT SIDE OF PARK BRAKE LEVER) PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER MODULE (BEHIND CENTER OF DASH) PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) RIGHT TURN IND RX INPUT TX INPUT SHIFT INTERLOCK SYSTEM SPEED CONTROL SERVO (LEFT SIDE OF ENG COMPT) STARTING/CHARGING SYSTEM TAN/LT GRN WIRE TAN/ORG WIRE THEFT INDICATOR MICRO CLUSTER WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

"ANTI-THEFT" INDICATOR BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FUSE 30 FUSE 6 GRY WIRE GRY/ORG WIRE GRY/YEL WIRE HOT IN HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU WIRE LT GRN WIRE PASSIVE ANTI- THEFT SYSTEM (PATS) TRANS- CEIVER MODULE (BEHIND CENTER OF DASH) PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RUN WIRE TAN/ORG WIRE WHT/LT GRN WIRE YEL WIRE