Ford Expedition I (1996-2002) hot in run or start Wiring diagrams

AIR CONDITIONING SYSTEM AUTOLAMP MODULE, INSTRUMENT CLUSTER BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND EPC OSS TP VREF SIG RTN BOO VPWR PWR GND COAST CLUTCH CONTROL CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE DK LT DK PNK WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY PNK BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC TSS RED WIRE RED/LT GRN WIRE SHIFT CONTROL 1 SHIFT CONTROL 2 SPEED CONTROL TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA DLC (-) DLC (+) CCS TCS TFT IAT THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

3 6 11 12 13 15 16 570 237 315 911 107 915 914 PWR GND AIR CONDITIONING SYSTEM AUTOLAMP MODULE BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND EPC OSS TP VREF SIG RTN BOO VPWR PWR GND CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK LT ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY PNK BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC RED WIRE RED/LT GRN WIRE SHIFT SOLENOIDS (SS) SPEED CONTROL TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA DLC (-) DLC (+) TFT IAT THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

8 9 10 11 12 13 14 21 22 23 24 25 26 STEERING WHL SW BLEND DOOR ACT GND A/C PRESS CUTOFF SIG AIR BAG SLIDING CONTACT (AT BASE OF STEERING COLUMN) AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR SPEED CONTROLLER (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 2 DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FUSE 105 FUSE 13 FUSE 22 FUSE 23 HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IN-CAR TEMPERATURE SENSOR (BEHIND CENTER OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE NCA WIRE ORG/ WIRE PNK WIRE PNK/ 1 2 3 4 5 6 7 15 16 17 18 19 20 WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE SOLID STATE SPC (-) BATTERY GROUND SENSOR INPUT GND STEERING COLUMN ASSEMBLY SUNLOAD SENSOR (TOP RIGHT SIDE OF DASH) TAN/ORG WIRE VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

0.6 OHMS 2.7 OHMS 3.8 OHMS 3.8 OHMS 2.7 OHMS 0.6 OHMS 4.6L 5.4L 69 41 331 347 WOT RELAY ACCS A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT REAR CORNER OF ENGINE COMPARTMENT) A/C CLUTCH DIODE A/C COMPRESSOR CLUTCH SOLENOID (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C PRESSURE CUT-OFF SWITCH (IN RIGHT SIDE OF ENGINE COMPARTMENT) AUXILIARY A/C BLOWER MOTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C BLOWER MOTOR RESISTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C RELAY BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK ORG/ WIRE BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CONSOLE BLOWER MOTOR (INSIDE CENTER OF FLOOR CONSOLE) DK BLU/WHT WIRE DK GRN/YEL WIRE FRONT BLOWER MIOTOR SWITCH FUSE 114 FUSE 13 FUSE 23 GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LOW MED LT BLU PNK/ WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE OFF OFF LOW MED OFF REAR ORG RED/ WIRE ORG-LT BLU WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/ WHT WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPARTMENT) REAR BLOWER MOTOR SWITCH REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED ORG/ WIRE RED YEL/ WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RPO RELAY BLOCK 2 (IN FRONT OF LEFT REAR WHEELWELL) VIO WIRE W/O ROOF OPENING PANEL W/ROOF PANEL OPENING WHT LT GRN/ WIRE WHT WIRE WHT/ DK BLU WIRE WHT/LT BLU WIRE WOT RELAY YEL BLK/ WIRE YEL RED/ WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

"ANTI-THEFT" INDICATOR BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FUSE 30 FUSE 6 GRY WIRE GRY/ORG WIRE GRY/YEL WIRE HOT IN HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU WIRE LT GRN WIRE PASSIVE ANTI- THEFT SYSTEM (PATS) TRANS- CEIVER MODULE (BEHIND CENTER OF DASH) PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RUN WIRE TAN/ORG WIRE WHT/LT GRN WIRE YEL WIRE

1 1 PASS SIDE AIR BAG FEED PASS SIDE AIR BAG RETURN 1 2 3 4 5 6 7 8 9 10 11 1 1 DRIVER SIDE AIR BAG FEED DRIVER SIDE AIR BAG RETURN AIR BAG INDICATOR AIR BAG INDICATOR LAMP GROUND AIR BAG SLIDING CONTACT BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/YEL WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER CENTER OF DASH) DRIVER AIR BAG DRIVER SIDE AIR BAG EXPEDITION W/O SIDE AIR BAGS EXPEDITION W/O SIDE AIR BAGS, NAVIGATOR EXPEDITION W/O SIDE AIR BAGS, NAVIGATOR EXPEDITION W/ SIDE AIR BAGS EXPEDITION W/SIDE AIR BAGS FUSE 22 FUSE 30 GENERIC ELECTRONIC MODULE (GEM) (BEHIND LEFT SIDE OF DASH) GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN RUN HOT IN RUN OR START INSTRUMENT CLUSTER LEFT PRIMARY CRASH SENSOR (IN LEFT FRONT OF ENGINE COMPARTMENT) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PASSENGER AIR BAG PASSENGER SIDE AIR BAG PNK WIRE PNK/BLK WIRE RED WIRE RED/LT GRN WIRE RESTRAINTS CONTROL MODULE (RCM) (BEHIND RIGHT SIDE OF DASH) RIGHT PRIMARY CRASH SENSOR (IN RIGHT FRONT OF ENGINE COMPARTMENT) SHORTING BAR TONE REQUEST TONE REQUEST INPUT VIO WIRE VIO/ORG WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE

ACCEL SIG AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BODY COMPUTER SYSTEM BRN WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CKP(+) CKP(-) KS DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS TP OUT PCM DATA OUT IND INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD EVR CTRL JUNCTION BOX KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MAF TFT NCA WIRE NOT USED OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK LT DK WIRE PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RADIO NOISE CAPACITOR 1 (TOP RIGHT SIDE OF ENGINE) RADIO NOISE CAPACITOR 2 (TOP LEFT SIDE OF ENGINE) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL 1 NOY USED PNK WIRE SHIFT SOL 2 TCIL DLC TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

ACCEL SIG CCS CKP(+) CKP(-) AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BODY COMPUTER SYSTEM BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS TP OUT PCM DATA OUT IGNITION COILS IND INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD EVR CTRL JUNCTION BOX KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MAF TFT NCA WIRE NOT USED OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK LT DK WIRE PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RADIO NOISE CAPACITOR 1 (TOP RIGHT SIDE OF ENGINE) RADIO NOISE CAPACITOR 2 (TOP RIGHT SIDE OF ENGINE) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL 1 NOY USED PNK WIRE SHIFT SOL 2 TCIL DLC TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE