Ford Expedition I (1996-2002) hot in run Wiring diagrams

1400 OHM 4-WHEEL ANTI-LOCK BRAKE 820 OHM ANTI- LOCK IND BIAS CKT BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE 102 BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BRAKE FLUID LEVEL INDICATOR SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DIFFERENTIAL SPEED SENSOR (DSS) (ON REAR AXLE) DK GRN WIRE DK GRN/YEL WIRE FUSE 15 FUSE 23 FUSE 6 GENERIC ELECTRONIC MODULE (GEM) GROUND POWER INPUT GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN IGNITION FEED INSTRUMENT CLUSTER LEFT FRONT LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE ORG/YEL WIRE PROCESSOR MICRO- RED/LT GRN WIRE RED/PNK WIRE RIGHT FRONT SENSOR (AT WHEEL) TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE WHT WIRE WHT/ORG WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/RED WIRE

8 9 10 11 12 13 14 21 22 23 24 25 26 STEERING WHL SW BLEND DOOR ACT GND A/C PRESS CUTOFF SIG AIR BAG SLIDING CONTACT (AT BASE OF STEERING COLUMN) AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR SPEED CONTROLLER (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 2 DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FUSE 105 FUSE 13 FUSE 22 FUSE 23 HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IN-CAR TEMPERATURE SENSOR (BEHIND CENTER OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE NCA WIRE ORG/ WIRE PNK WIRE PNK/ 1 2 3 4 5 6 7 15 16 17 18 19 20 WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE SOLID STATE SPC (-) BATTERY GROUND SENSOR INPUT GND STEERING COLUMN ASSEMBLY SUNLOAD SENSOR (TOP RIGHT SIDE OF DASH) TAN/ORG WIRE VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

ANTI-LOCK BRAKES SYSTEM AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CONSOLE BLOWER RELAY DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER CENTER OF DASH) DK GRN/YEL WIRE FUSE 23 FUSE 7 GRY WIRE GRY/LT BLU WIRE GRY/WHT WIRE HOT IN RUN INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT GRN WIRE PNK WIRE PNK/ (MAIN HARNESS, NEAR BREAKOUT TO PASSENGER AIR BAG) WIRE PNK/ 15 16 41 69 WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPARTMENT) REAR MODE POTENTIOMETER RED WIRE RED/YEL WIRE RPO RELAY BLOCK 1 (BEHIND RIGHT SIDE OF DASH, ABOVE PASSENGER AIR BAG) SOLID STATE TAN WIRE TAN/ORG WIRE VIO WIRE W/O ROOF OPENING PANEL WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE WOT RELAY YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

BLK WIRE BLK/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF AUTOMATIC TRANSMISSION) EXTERIOR LAMPS (TRAILER TOW BACK-UP LAMP RELAY) FUSE 5 HOT IN RUN LT BLU WIRE MIRRORS SYSTEM (W ELECTRO- CHROMIC REAR VIEW ONLY) PNK LEFT REVERSING LAMP WIRE PNK RIGHT REVERSING LAMP WIRE PNK WIRE REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND LEFT SIDE OF DASH)

120 OHMS 2200 OHMS 24 10 BATTERY HORN SWITCH IN 68 91 84 VEHICLE SPEED OUT SIGNAL RETURN OSS SENSOR AIR BAG SLIDING CONTACT (TOP OF STEERING COLUMN) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENG COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER LEFT SIDE OF DASH) BRAKE PRESS IN GROUND BRAKE PRESSURE SWITCH (LEFT REAR CORNER OF ENGINE COMPT) BRN/LT GRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 15 CENTRAL SECURITY MODULE (BEHIND LEFT SIDE OF DASH) COAST CONTROL SW IN CONTROL SW GND IGN DK BLU WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE FUSE 13 FUSE 5 FUSE 7 GRY/BLK WIRE GRY/RED WIRE HORN SWITCH HOT AT ALL TIMES HOT IN RUN LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE NCA WIRE OHMS ON OFF OUTPUT SHAFT SPEED (OSS) SENSOR (ON LEFT SIDE OF TRANSMISSION) PNK/BLK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF ENGINE COMPARTMENT) RED/LT GRN WIRE RESUME SET/ ACCEL SPEED CONTROL SERVO (IN LEFT SIDE OF ENGINE COMPT) SPEED CONTROL SWITCH ASSEMBLY STEERING COLUMN ASSEMBLY VEHICLE SPEED INPUT BRAKE APPLIED IN YEL/LT BLU WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENG COMPT) BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DEFROST SWITCH INPUT DK BLU WIRE DK GRN WIRE DK GRN/VIO WIRE FUSE 116 FUSE 17 FUSE 6 GENERIC ELECTRONIC MODULE (UNDER LEFT SIDE OF DASH) DEFROST RELAY CONTROL HEATED GRID RELAY HOT AT ALL TIMES HOT IN RUN LEFT POWER/ HEATED MIRROR RIGHT POWER/ HEATED MIRROR LT BLU WIRE NCA WIRE ON INDICATOR ON/OFF SWITCH ORG/ WIRE REAR HEATED WINDOW SWITCH REAR WINDOW DEFROST GRID RED WIRE SWITCH ILLUM. VIO WIRE

2 3 4 ROTATION RATE INPUT VEHICLE SIGNAL INPUT IGNITION AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) ENGINE CONTROL SYSTEM EVO ACT OUTPUT EVO ACTUATOR (LEFT SIDE OF ENGINE COMPT) FUSE 6 GENERIC ELECTRONIC MODULE GROUND GRY/BLK WIRE GRY/YEL WIRE HOT IN RUN NCA WIRE ORG/ WIRE RED WIRE RED/YEL WIRE ROTATION RATE INPUT SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPARTMENT) STEERING WHEEL ROTATION SENSOR (BEHIND STEERING WHEEL, IN DASH) YEL WIRE

5 4 2 EVO DIAGNOSTIC CONNECTOR (LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPARTMENT) ELECTRONIC VARIABLE ORIFICE (EVO) MODULE (BEHIND CENTER OF DASH) ENGINE CONTROL SYSTEM EVO ACT OUTPUT EVO ACT OUTPUT EVO ACTUATOR (LEFT SIDE OF OF ENGINE FUSE 6 FUSE 5 GENERIC ELECTRONIC MODULE GRY/BLK WIRE GRY/YEL WIRE HOT IN RUN LT BLU/PNK WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK/ORG WIRE RED WIRE RED/YEL WIRE SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPARTMENT) STEERING WHEEL ROTATION SENSOR (BEHIND STEERING WHEEL, IN DASH) YEL WIRE

AUTOLAMP MODULE (BEHIND CENTER OF DASH) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLOWER/ FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FLASHER RELAY FUSE 1 FUSE 13 FUSE 23 FUSE 6 HAZARD HEAD OFF HIGH MOUNT STOP LAMP 1 HIGH MOUNT STOP LAMP 2 HIGH MOUNT STOP LAMP 3 HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT LEFT EXTERIOR REAR VIEW MIRROR LEFT FRONT PARK/ TURN LAMP LEFT STOP/ PARK/ TURN LAMP LEFT TURN INDICATOR LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH NCA WIRE NORMAL ORG/ WIRE ORG/LT BLU WIRE PARK PARK LAMP RELAY (W/ AUTO LAMPS) RED WIRE RIGHT RIGHT EXTERIOR REAR VIEW MIRROR RIGHT LICENSE LAMP LEFT LICENSE LAMP RIGHT STOP/ PARK/ TURN LAMP RIGHT TURN INDICATOR RIGHT FRONT PARK/ TURN LAMP RPO RELAY BLOCK 1 (BEHIND RIGHT SIDE OF DASH, ABOVE PASSENGER AIR BAG) TAN WIRE TRAILER/ CAMPER ADAPTER CIRCUIT WHT WIRE YEL WIRE

AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE OF PANEL) AUXILIARY A/C MODE ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK LT GRN/ WIRE BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BRN WIRE BRN/ WHT WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COLD BLEND DOOR POTENT- IOMETER DK GRN/YEL WIRE FUSE 23 FUSE 5 FUSE 7 GRY/ LT BLU WIRE GRY/LT BLU WIRE HOT IN RUN HOT IN RUN CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 22 ILLUMINATION LT BLU GRY/ WIRE LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/WHT WIRE MAX A/C NORM A/C MED HIGH HIGH BLOWER MOTOR SWITCH MED LOW ORG/ BRN WIRE ORG/BLK WIRE PAN, FLR FLOOR FLR, DEF DEF MODE SELECTOR SWITCH PAN/FLR FLOOR DEF/FLR DEF MAX A/C NORM A/C PANEL OFF PANEL OFF PNK WIRE PNK/ LT GRN WIRE PNK/LT GRN WIRE REAR MODE POTENTIOMETER RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/WHT WIRE SOLID STATE SOLID STATE 5 6 7 8 SUPPLEMENTAL RESTRAINTS SYSTEM VIO WIRE VIO/ORG WIRE W/O ROOF OPENING PANEL WARM FUNCTION SELECTOR SWITCH ASSEMBLY WHT BRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE