Ford Expedition I (1996-2002) gry Wiring diagrams

AUTO PARK AUTOLAMP MODULE (BEHIND CENTER OF DASH) AUTOLAMP OUT BATTERY JUNCTION BOX BLK WIRE BRN WIRE CENTRAL JUNCTION BOX DAYTIME RUNNING LAMPS RELAY 1 DAYTIME RUNNING LAMPS RELAY 2 DAYTIME RUNNING LAMPS RELAY BLOCK (BEHIND RIGHT SIDE OF DASH) DAYTIME RUNNING LAMPS RESISTOR (IN LEFT FRONT OF ENGINE COMPT) DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 28 FUSE 27 FUSE 26 FUSE 29 FUSE 3 FUSE 5 FUSE 6 FUSE 9 GROUND GRY WIRE HEAD OFF HEADLAMP RELAY HI HI LO LO HI PASS LO HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION INSTRUMENT CLUSTER HI BEAM INDICATOR LEFT FOG LAMP LEFT HEADLAMP RIGHT HEADLAMP LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH ORG/ WIRE ORG/LT GRN WIRE PARK LAMP RELAY PNK WIRE RED WIRE RED/YEL WIRE RELAY GROUND REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND LEFT SIDE OF DASH) RIGHT FOG LAMP RPO RELAY BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/WHT WIRE WHT WIRE YEL WIRE

AUTO PARK AUTOLAMP MODULE (BEHIND CENTER OF DASH) AUTOLAMP OUT BATTERY JUNCTION BOX BLK WIRE BRN WIRE CENTRAL JUNCTION BOX DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 28 FUSE 27 FUSE 26 FUSE 29 FUSE 3 FUSE 6 FUSE 9 GROUND GRY WIRE HEAD OFF HEADLAMP RELAY HI HI LO LO HI PASS LO HOT AT ALL TIMES HOT IN START OR RUN IGNITION INSTRUMENT CLUSTER HI BEAM INDICATOR LEFT FOG LAMP LEFT HEADLAMP RIGHT HEADLAMP LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH ORG/ WIRE PARK LAMP RELAY RED WIRE RED/YEL WIRE RELAY GROUND REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND LEFT SIDE OF DASH) RIGHT FOG LAMP RPO RELAY BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/WHT WIRE WHT WIRE YEL WIRE

ANTI-LOCK BRAKES SYSTEM AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CONSOLE BLOWER RELAY DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER CENTER OF DASH) DK GRN/YEL WIRE FUSE 23 FUSE 7 GRY WIRE GRY/LT BLU WIRE GRY/WHT WIRE HOT IN RUN INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT GRN WIRE PNK WIRE PNK/ (MAIN HARNESS, NEAR BREAKOUT TO PASSENGER AIR BAG) WIRE PNK/ 15 16 41 69 WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPARTMENT) REAR MODE POTENTIOMETER RED WIRE RED/YEL WIRE RPO RELAY BLOCK 1 (BEHIND RIGHT SIDE OF DASH, ABOVE PASSENGER AIR BAG) SOLID STATE TAN WIRE TAN/ORG WIRE VIO WIRE W/O ROOF OPENING PANEL WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE WOT RELAY YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

ACCESSORY DELAY RELAY ACCESSORY DELAY RELAY CTRL HEATED GRID RELAY CTRL IGNITION (ACC/RUN) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CIRCUIT BREAKER FUSE 14 FUSE 15 FUSE 20 FUSE 6 FUSE 8 GENERIC ELECTRONIC MODULE (GEM) GRY WIRE GRY/BLK WIRE HEATED GRID RELAY HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LAMP RELAY LT BLU WIRE LT BLU/BLK WIRE LT GRN/ORG WIRE ONE-TOUCH DOWN RELAY ORG/LT GRN WIRE ORG/WHT WIRE PNK/ORG WIRE POWER WINDOWS SYSTEM POWER WINDOWS SYSTEM POWER WINDOWS SYSTEM RED WIRE RUN WIRE SOUND SYSTEMS ENGINE CONTROLS SYSTEM ELECTRONIC SUSPENSION SYSTEM TAN/LT BLU WIRE TRANSMISSIONS SYSTEM

BATTERY JUNCTION BOX BLK WIRE CENTRAL JUNCTION BOX DAYTIME RUNNING LAMPS RELAY 1 DAYTIME RUNNING LAMPS RELAY 2 DAYTIME RUNNING LAMPS RELAY BLOCK (BEHIND RIGHT SIDE OF DASH) DAYTIME RUNNING LAMPS RESISTOR (IN LEFT FRONT OF ENGINE COMPT) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 26 FUSE 27 FUSE 28 FUSE 3 FUSE 5 FUSE 9 GRY WIRE GRY/WHT WIRE HI BEAM INDICATOR HI LO HI PASS LO HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT FOG LAMP LEFT HEADLAMP LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH OFF HEAD PARK ORG/ WIRE ORG/LT GRN WIRE PASS PNK WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT FOG LAMP RIGHT HEADLAMP TAN WIRE WHT WIRE YEL WIRE

"ANTI-THEFT" INDICATOR BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM FUSE 30 FUSE 6 GRY WIRE GRY/ORG WIRE GRY/YEL WIRE HOT IN HOT IN RUN OR START INSTRUMENT CLUSTER LT BLU WIRE LT GRN WIRE PASSIVE ANTI- THEFT SYSTEM (PATS) TRANS- CEIVER MODULE (BEHIND CENTER OF DASH) PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RUN WIRE TAN/ORG WIRE WHT/LT GRN WIRE YEL WIRE

ACCEL SIG AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BODY COMPUTER SYSTEM BRN WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CKP(+) CKP(-) KS DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER CENTER OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS TP OUT PCM DATA OUT IND INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD EVR CTRL JUNCTION BOX KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MAF TFT NCA WIRE NOT USED OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK LT DK WIRE PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RADIO NOISE CAPACITOR 1 (TOP RIGHT SIDE OF ENGINE) RADIO NOISE CAPACITOR 2 (TOP LEFT SIDE OF ENGINE) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL 1 NOY USED PNK WIRE SHIFT SOL 2 TCIL DLC TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BREAKOUT TO STARTER RELAY) BRN WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE CRANKSHAFT POSITION (CKP) SENSOR (LOWER FRONT OF ENGINE) CRANKSHAFT POSITION SENSOR SHIELD DIFFERENTIAL PRESSURE FEEDBACK EGR (DPFE) SENSOR (LEFT SIDE OF ENGINE) DK BLU WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUEL PUMP RELAY FUEL TANK PRESSURE SENSOR (IN FUEL TANK) FUSE 10 FUSE 18 GENERIC ELECTRONIC MODULE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INTAKE AIR TEMPERATURE (IAT) SENSOR (ON INTAKE MANIFOLD) INTAKE MANIFOLD TUNNING VALVE (TOP FRONT OF ENGINE) LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE REAR OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE TAN/LT BLU WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) VIO WIRE VIO/ORG WIRE VSS INPUT WHT/RED WIRE

ACCEL SIG CCS CKP(+) CKP(-) AIR CONDITIONING SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BODY COMPUTER SYSTEM BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CASE GND IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (PARTIAL) (UNDER LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT FUEL PUMP MON ACCS TP OUT PCM DATA OUT IGNITION COILS IND INSTRUMENT CLUSTER SYSTEM INTAKE MANIFOLD EVR CTRL JUNCTION BOX KS SENSOR LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT MAF TFT NCA WIRE NOT USED OD OFF ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE PCM POWER DIODE PCM POWER RELAY PNK LT DK WIRE PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND PWR GND IGN COIL 3 RADIO NOISE CAPACITOR 1 (TOP RIGHT SIDE OF ENGINE) RADIO NOISE CAPACITOR 2 (TOP RIGHT SIDE OF ENGINE) RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL 1 NOY USED PNK WIRE SHIFT SOL 2 TCIL DLC TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL SWITCH (A/T) VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BREAKOUT TO STARTER RELAY) BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE CRANKSHAFT POSITION (CKP) SENSOR (LOWER FRONT OF ENGINE) CRANKSHAFT POSITION SENSOR SHIELD DIFFERENTIAL PRESSURE FEEDBACK EGR (DPFE) SENSOR (LEFT SIDE OF ENGINE) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM FUEL PUMP RELAY FUEL TANK PRESSURE SENSOR (IN FUEL TANK) FUSE 10 FUSE 18 GENERIC ELECTRONIC MODULE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INTAKE AIR TEMPERATURE (IAT) SENSOR (ON INTAKE MANIFOLD) INTAKE MANIFOLD TUNING VALVE (TOP FRONT OF ENGINE) LT BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE REAR OF ENGINE COMPT) RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE TAN/LT BLU WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) VIO WIRE VIO/ORG WIRE VSS INPUT WHT/RED WIRE