Ford Expedition I (1996-2002) fuse 5 Wiring diagrams

AUTO PARK AUTOLAMP MODULE (BEHIND CENTER OF DASH) AUTOLAMP OUT BATTERY JUNCTION BOX BLK WIRE BRN WIRE CENTRAL JUNCTION BOX DAYTIME RUNNING LAMPS RELAY 1 DAYTIME RUNNING LAMPS RELAY 2 DAYTIME RUNNING LAMPS RELAY BLOCK (BEHIND RIGHT SIDE OF DASH) DAYTIME RUNNING LAMPS RESISTOR (IN LEFT FRONT OF ENGINE COMPT) DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 28 FUSE 27 FUSE 26 FUSE 29 FUSE 3 FUSE 5 FUSE 6 FUSE 9 GROUND GRY WIRE HEAD OFF HEADLAMP RELAY HI HI LO LO HI PASS LO HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION INSTRUMENT CLUSTER HI BEAM INDICATOR LEFT FOG LAMP LEFT HEADLAMP RIGHT HEADLAMP LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH ORG/ WIRE ORG/LT GRN WIRE PARK LAMP RELAY PNK WIRE RED WIRE RED/YEL WIRE RELAY GROUND REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND LEFT SIDE OF DASH) RIGHT FOG LAMP RPO RELAY BOX (BEHIND RIGHT SIDE OF DASH) TAN WIRE TAN/WHT WIRE WHT WIRE YEL WIRE

BLK WIRE BLK/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF AUTOMATIC TRANSMISSION) EXTERIOR LAMPS (TRAILER TOW BACK-UP LAMP RELAY) FUSE 5 HOT IN RUN LT BLU WIRE MIRRORS SYSTEM (W ELECTRO- CHROMIC REAR VIEW ONLY) PNK LEFT REVERSING LAMP WIRE PNK RIGHT REVERSING LAMP WIRE PNK WIRE REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND LEFT SIDE OF DASH)

120 OHMS 2200 OHMS 24 10 BATTERY HORN SWITCH IN 68 91 84 VEHICLE SPEED OUT SIGNAL RETURN OSS SENSOR AIR BAG SLIDING CONTACT (TOP OF STEERING COLUMN) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENG COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER LEFT SIDE OF DASH) BRAKE PRESS IN GROUND BRAKE PRESSURE SWITCH (LEFT REAR CORNER OF ENGINE COMPT) BRN/LT GRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 15 CENTRAL SECURITY MODULE (BEHIND LEFT SIDE OF DASH) COAST CONTROL SW IN CONTROL SW GND IGN DK BLU WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE FUSE 13 FUSE 5 FUSE 7 GRY/BLK WIRE GRY/RED WIRE HORN SWITCH HOT AT ALL TIMES HOT IN RUN LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE NCA WIRE OHMS ON OFF OUTPUT SHAFT SPEED (OSS) SENSOR (ON LEFT SIDE OF TRANSMISSION) PNK/BLK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF ENGINE COMPARTMENT) RED/LT GRN WIRE RESUME SET/ ACCEL SPEED CONTROL SERVO (IN LEFT SIDE OF ENGINE COMPT) SPEED CONTROL SWITCH ASSEMBLY STEERING COLUMN ASSEMBLY VEHICLE SPEED INPUT BRAKE APPLIED IN YEL/LT BLU WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DRVR UNLOCK 1/2 INPUT 3/4 INPUT 7/8 INPUT 9/0 INPUT 5/6 INPUT ALL LOCK/ ANTENNA BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPT) FUSE 8 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMMON DATA LINK CONNECTOR (UNDER CENTER OF DASH) DATALINK DIGITAL TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF AUTOMATIC TRANSMISSION) DISABLE IGNITION BPP SWITCH DK BLU WIRE DOOR AJAR OUT DOOR AJAR TRANS IN DOOR LOCKS SYSTEM DRIVER'S UNLOCK RELAY (BEHIND RIGHT SIDE OF DASH, IN LOCK RELAY BLOCK) ELECTRONIC SUSPENSION SYSTEM EXT LIGHTS FUSE 15 FUSE 4 FUSE 5 FUSE 8 HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC ILLUM ENTRY IN ILLUMINATION INT LIGHTS ALL UNLOCK POWER DISABLE GROUND ILLUM KEYLESS ENTRY SWITCH ASSEMBLY LEFT FRONT POWER DOOR LOCK SWITCH LOCK LOCK UNLOCK LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MEM SEAT MEMORY SYSTEMS NCA WIRE ORG/ WIRE ORG/LT GRN WIRE PNK PNK WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RIGHT FRONT POWER DOOR LOCK SWITCH RUN WIRE UNLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX BLK WIRE CENTRAL JUNCTION BOX DAYTIME RUNNING LAMPS RELAY 1 DAYTIME RUNNING LAMPS RELAY 2 DAYTIME RUNNING LAMPS RELAY BLOCK (BEHIND RIGHT SIDE OF DASH) DAYTIME RUNNING LAMPS RESISTOR (IN LEFT FRONT OF ENGINE COMPT) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE FOG LAMP RELAY FOG LAMP SWITCH FOG ON INDICATOR FUSE 16 FUSE 26 FUSE 27 FUSE 28 FUSE 3 FUSE 5 FUSE 9 GRY WIRE GRY/WHT WIRE HI BEAM INDICATOR HI LO HI PASS LO HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT FOG LAMP LEFT HEADLAMP LT BLU WIRE LT GRN WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH OFF HEAD PARK ORG/ WIRE ORG/LT GRN WIRE PASS PNK WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RIGHT FOG LAMP RIGHT HEADLAMP TAN WIRE WHT WIRE YEL WIRE

AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE OF PANEL) AUXILIARY A/C MODE ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK LT GRN/ WIRE BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BRN WIRE BRN/ WHT WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COLD BLEND DOOR POTENT- IOMETER DK GRN/YEL WIRE FUSE 23 FUSE 5 FUSE 7 GRY/ LT BLU WIRE GRY/LT BLU WIRE HOT IN RUN HOT IN RUN CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 22 ILLUMINATION LT BLU GRY/ WIRE LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/WHT WIRE MAX A/C NORM A/C MED HIGH HIGH BLOWER MOTOR SWITCH MED LOW ORG/ BRN WIRE ORG/BLK WIRE PAN, FLR FLOOR FLR, DEF DEF MODE SELECTOR SWITCH PAN/FLR FLOOR DEF/FLR DEF MAX A/C NORM A/C PANEL OFF PANEL OFF PNK WIRE PNK/ LT GRN WIRE PNK/LT GRN WIRE REAR MODE POTENTIOMETER RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/WHT WIRE SOLID STATE SOLID STATE 5 6 7 8 SUPPLEMENTAL RESTRAINTS SYSTEM VIO WIRE VIO/ORG WIRE W/O ROOF OPENING PANEL WARM FUNCTION SELECTOR SWITCH ASSEMBLY WHT BRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AIR SUSPENSION COMPRESSOR RELAY 4 WHEEL ANTI-LOCK BRAKE SYSTEM ALL LOCK RELAY ALL UNLOCK RELAY AUXILIARY A/C RELAY AUXILIARY POWER SOCKET BATTERY BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/PNK WIRE BRN/WHT WIRE CD CHANGER REAR INTEGRATED CONTROL PANEL CELLULAR TELEPHONE SUPPORT ELECTRONICS RADIO SUBWOOFER AMPLIFIER CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CONSOLE AUXILIARY POWER SOCKET DK BLU/ORG WIRE DK GRN/YEL WIRE DRIVER'S UNLOCK RELAY FOG LAMP RELAY DAYTIME RUNNING LAMPS RESISTOR FROM FUSE 8 (DIAGRAM 1 OF 4) FUSE 1 FUSE 101 FUSE 103 FUSE 107 FUSE 11 FUSE 114 FUSE 109 FUSE 102 FUSE 12 FUSE 13 FUSE 31 FUSE 4 FUSE 3 FUSE 5 FUSE 6 FUSE 7 FUSE 8 FUSE 9 FUSIBLE LINK A (12 GA- FUSIBLE LINK B (12 GA- GENERATOR GRY WIRE HEADLAMP RELAY HORN RELAY LOCK RELAY BLOCK LT BLU WIRE LT BLU/PNK WIRE LT GRN/VIO WIRE MAIN LIGHT SWITCH MODULE NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE PARK LAMP RELAY PASSENGER POWER SEAT CONTROL SWITCH PASSENGER POWER LUMBAR SWITCH PNK/LT BLU WIRE PNK/WHT WIRE REAR WIPER DOWN RELAY REAR WIPER UP RELAY RED WIRE RED/ WHT WIRE RPO RELAY BLOCK 1 RPO RELAY BLOCK 2 MULTI- FUNCTION SWITCH STARTER MOTOR STARTER MOTOR RELAY TAN/BLK WIRE TAN/WHT WIRE TO FUSE 103 (DIAGRAM 1 OF 4) TO FUSE 104 (DIAGRAM 2 OF 4) TO FUSE 2 (DIAGRAM 3 OF 4) TRAILER TOW BACK-UP LAMP RELAY TRAILER TOW BATTERY CHARGE RELAY TRAILER TOW RUNNING LAMP RELAY VIO/ORG WIRE W/O LUMBAR WHT RED/ WIRE WHT/VIO WIRE WOT RELAY YEL WIRE YEL/LT BLU WIRE

ADJUSTABLE PEDAL SWITCH BATTERY JUNCTION BOX BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK PNK/ WIRE BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLOWER RELAY BLOWER/ FLASHER RELAY BLOCK CENTRAL JUNCTION BOX CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CIRCUIT BREAKER 601 DAYTIME RUNNING LIGHTS RELAY BLOCK DAYTIME RUNNING LIGHTS 1 RELAY DELAY RELAY DIGITAL TRANSMISSION RANGE (DTR) SENSOR DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DRIVER POWER LUMBAR SWITCH DRIVER POWER SEAT CONTROL SWITCH DRIVER SEAT MODULE DRIVER TEMPERATURE CONTROLLED SEAT MODULE DRIVER HEATED SEAT MODULE FROM FUSE 101 (DIAGRAM 1 OF 4) FRONT WASHER PUMP RELAY FUSE 104 FUSE 108 FUSE 11 FUSE 110 FUSE 111 FUSE 112 FUSE 113 FUSE 105 FUSE 116 FUSE 2 FUSE 10 FUSE 21 FUSE 5 FUSE 6 FUSE 8 GENERIC ELECTRONIC MODULE GRY WIRE GRY YEL/ WIRE GRY/YEL WIRE HEATED GRID RELAY IGNITION SWITCH INSTRUMENT CLUSTER LOCK OFF LT BLU/ORG WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE PARKING AID MODULE (PAM) OVERHEAD TRIP COMPUTER MODULE COMPASS SENSOR PARKING BRAKE RELEASE SWITCH PASSENGER HEATED SEAT MODULE PASSENGER TEMPERATURE CONTROLLED SEAT MODULE PCM POWER RELAY FUEL PUMP RELAY PNK WIRE RADIO (MAIN HARN, IN BREAKOUT TO CENTRAL JUNCTION BOX) REAR WASHER PUMP RELAY WIPER RUN/PARK RELAY WIPER HI/LO RELAY RED WIRE RED/BLK WIRE RED/LT BLU WIRE REMOTE ANTI-THEFT PERSONALITY MODULE CLOCK CELLULAR PHONE SUPPORT ELECTRONICS RUN WIRE SHIFT LOCK ACTUATOR SPEED CONTROL SERVO STEERING WHEEL ROTATION SENSOR TO FUSE 20 (DIAGRAM 3 OF 4) TO FUSE 22 (DIAGRAM 4 OF 4) TO FUSE 29 (DIAGRAM 3 OF 4) TORQUE ON-DEMAND RELAY TRANSFER CASE SHIFT RELAYS TRAILER TOW (BATTERY FEED) W/ MEMORY W/CLIMATE CONTROL W/CLIMATE CONTROL W/O CLIMATE CONTROL W/O CLIMATE CONTROL W/O MEMORY WHT/BLK WIRE WINDSHIELD WIPER MOTOR YEL WIRE YEL/BLK WIRE

14 12 (1999) (2000) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE EXTERIOR LIGHTS (BACK-UP LAMPS CIRCUIT) EXTERIOR LIGHTS (EXTERIOR LIGHTS CIRCUIT) FUSE 101 FUSE 108 FUSE 13 FUSE 19 FUSE 20 FUSE 5 HEAD HOT AT ALL TIMES HOT IN RUN CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 23 LEFT TURN SIGNAL OUTPUT LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE MAIN LIGHT SWITCH MULTI- FUNCTION SWITCH OFF PARK ORG/ WIRE PNK WIRE RED WIRE RIGHT TURN SIGNAL OUTPUT TRAILER ELECTRONIC BRAKE CONTROL TRAILER ELECTRONIC BRAKE CONTROL TRAILER/ CAMPER ADAPTER TRAILER TOW BATTERY CHARGE RELAY TRAILER TOW REVERSING LAMP RELAY TRAILER TOW RUNNING LAMP RELAY TRAILER/ CAMPER ADAPTER (TRAILER BACKUP LAMPS) TRAILER/ CAMPER ADAPTER (TRAILER BATTERY) TRAILER/ CAMPER ADAPTER (TRAILER LEFT TURN LAMPS) TRAILER/ CAMPER ADAPTER (TRAILER RIGHT TURN LAMPS) TRAILER/ CAMPER ADAPTER (TRAILER RUNNING LAMPS) TRAILER/ CAMPER ADAPTER TRAILER ELECTRONIC BRAKE CONTROL WHT WIRE YEL WIRE