Ford Expedition I (1996-2002) fuse 15 Wiring diagrams

"HIGH RANGE" INDICATOR "LOW RANGE" INDICATOR 240 OHMS OHMS 4 WHEEL DRIVE MODE SWITCH 680 OHMS ABS INPUT ANTI-LOCK BRAKE SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLU WIRE BPP SW INPUT BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE EXTERIOR LIGHTS FUSE 104 FUSE 15 FUSE 23 FUSE 6 GENERIC ELECTRONIC MODULE (GEM) (BEHIND LEFT SIDE OF DASH) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN ILLUMINATION INSTRUMENT CLUSTER INTERIOR LIGHTS (INSTRUMENT ILLUMINATION) LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT LT ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE OVERHEAD TRIP COMPUTER MODULE PNK WIRE PNK/ORG WIRE REAR SPEED SENSOR MAGNETIC CLUTCH FRONT SPEED SENSOR RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN SW D INPUT SW C INPUT SW B INPUT SW A INPUT NEUTRAL SW IN TOD RELAY TORQUE ON DEMAND (TOD) RELAY (BEHIND CENTER OF DASH) TRANSFER CASE ASSEMBLY TRANSFER CASE SHIFT RELAYS (BEHIND CENTER OF DASH) TS OUT VIO WIRE VIO/YEL WIRE VSS WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WIPER/WASHER (MULTI-FUNCTION SWITCH) YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

1400 OHM 4-WHEEL ANTI-LOCK BRAKE 820 OHM ANTI- LOCK IND BIAS CKT BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE 102 BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BRAKE FLUID LEVEL INDICATOR SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DIFFERENTIAL SPEED SENSOR (DSS) (ON REAR AXLE) DK GRN WIRE DK GRN/YEL WIRE FUSE 15 FUSE 23 FUSE 6 GENERIC ELECTRONIC MODULE (GEM) GROUND POWER INPUT GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN IGNITION FEED INSTRUMENT CLUSTER LEFT FRONT LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE ORG/YEL WIRE PROCESSOR MICRO- RED/LT GRN WIRE RED/PNK WIRE RIGHT FRONT SENSOR (AT WHEEL) TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE WHT WIRE WHT/ORG WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/RED WIRE

AIR CONDITIONING SYSTEM AUTOLAMP MODULE, INSTRUMENT CLUSTER BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND EPC OSS TP VREF SIG RTN BOO VPWR PWR GND COAST CLUTCH CONTROL CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE DK LT DK PNK WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY PNK BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC TSS RED WIRE RED/LT GRN WIRE SHIFT CONTROL 1 SHIFT CONTROL 2 SPEED CONTROL TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA DLC (-) DLC (+) CCS TCS TFT IAT THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

3 6 11 12 13 15 16 570 237 315 911 107 915 914 PWR GND AIR CONDITIONING SYSTEM AUTOLAMP MODULE BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CHT VPWR PWR GND EPC OSS TP VREF SIG RTN BOO VPWR PWR GND CYLINDER HEAD TEMPERATURE (CHT) SENSOR (TOP FRONT OF ENGINE) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK LT ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE CONTROLS SYSTEM FUSE 15 FUSE 18 FUSE 2 FUSE 29 FUSE 30 GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION COILS, RADIO NOISE CAPACITOR INSTRUMENT CLUSTER, ANTI- THEFT SYSTEM INTAKE AIR TEMPERATURE SENSOR (ON INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE MODULE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) PCM POWER DIODE PCM POWER RELAY PNK BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND TCC RED WIRE RED/LT GRN WIRE SHIFT SOLENOIDS (SS) SPEED CONTROL TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA DLC (-) DLC (+) TFT IAT THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH (TCC) SOLENOID TRANSMISSION CONTROL SWITCH (TCS) (END OF TRANSMISSION SELECTOR LEVER) TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

ACCESSORY DELAY RELAY ACCESSORY DELAY RELAY CTRL HEATED GRID RELAY CTRL IGNITION (ACC/RUN) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CIRCUIT BREAKER FUSE 14 FUSE 15 FUSE 20 FUSE 6 FUSE 8 GENERIC ELECTRONIC MODULE (GEM) GRY WIRE GRY/BLK WIRE HEATED GRID RELAY HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LAMP RELAY LT BLU WIRE LT BLU/BLK WIRE LT GRN/ORG WIRE ONE-TOUCH DOWN RELAY ORG/LT GRN WIRE ORG/WHT WIRE PNK/ORG WIRE POWER WINDOWS SYSTEM POWER WINDOWS SYSTEM POWER WINDOWS SYSTEM RED WIRE RUN WIRE SOUND SYSTEMS ENGINE CONTROLS SYSTEM ELECTRONIC SUSPENSION SYSTEM TAN/LT BLU WIRE TRANSMISSIONS SYSTEM

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DRVR UNLOCK 1/2 INPUT 3/4 INPUT 7/8 INPUT 9/0 INPUT 5/6 INPUT ALL LOCK/ ANTENNA BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPT) FUSE 8 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMMON DATA LINK CONNECTOR (UNDER CENTER OF DASH) DATALINK DIGITAL TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF AUTOMATIC TRANSMISSION) DISABLE IGNITION BPP SWITCH DK BLU WIRE DOOR AJAR OUT DOOR AJAR TRANS IN DOOR LOCKS SYSTEM DRIVER'S UNLOCK RELAY (BEHIND RIGHT SIDE OF DASH, IN LOCK RELAY BLOCK) ELECTRONIC SUSPENSION SYSTEM EXT LIGHTS FUSE 15 FUSE 4 FUSE 5 FUSE 8 HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC ILLUM ENTRY IN ILLUMINATION INT LIGHTS ALL UNLOCK POWER DISABLE GROUND ILLUM KEYLESS ENTRY SWITCH ASSEMBLY LEFT FRONT POWER DOOR LOCK SWITCH LOCK LOCK UNLOCK LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MEM SEAT MEMORY SYSTEMS NCA WIRE ORG/ WIRE ORG/LT GRN WIRE PNK PNK WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RIGHT FRONT POWER DOOR LOCK SWITCH RUN WIRE UNLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

13 10 2 2 (OTHERS) 4-WHEEL ANTI-LOCK BRAKE SYSTEM AUXILIARY A/C BLEND ACTAUTOR AUXILIARY A/C CONTROL MODULE AUXILIARY A/C MODE ACTUATOR AUXILIARY A/C RELAY BATTERY JUNCTION BOX BLOWER/ FLASHER RELAY BLOCK BLK WIRE BLOWER RELAY BLOWER/ FLASHER RELAY BLOCK BRAKE PEDAL POSITION SWITCH BRAKE PRESSURE SWITCH CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CIGAR LIGHTER CONSOLE BLOWER RELAY DATA LINK CONNECTOR DRIVER HEATED SEAT MODULE DRIVER HEATED SEAT SWITCH DRIVER TEMPERATURE CONTROLLED SEAT MODULE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE ELECTRONIC DAY/ NIGHT MIRROR FLASHER RELAY FROM FUSE 4 (DIAGRAM 3 OF 4) FROM IGNITION SWITCH (DIAGRAM 2 OF 4) FUSE 13 FUSE 15 FUSE 22 FUSE 23 FUSE 3 FUSE 7 GENERIC ELECTRONIC MODULE GRY WIRE LT BLU WIRE LT BLU/WHT WIRE LT GRN/RED WIRE MODE SWITCH NCA WIRE OVERHEAD CONSOLE PASSENGER HEATED SEAT MODULE PASSENGER HEATED SEAT SWITCH FUNCTION SELECTOR SWITCH ASSEMBLY PASSENGER TEMPERATURE CONTROLLED SEAT MODULE PNK/LT BLU WIRE REAR INTEGRATED CONTROL PANEL RED WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE RPO RELAY BLOCK 1 RPO RELAY BLOCK 2 TAN/RED WIRE TORQUE ON-DEMAND (TOD) RELAY TRAILER TOW BATTERY CHARGE RELAY FLASHER RELAY VIO WIRE VIO/ORG WIRE W/CLIMATE CONTROLLED SEATS W/HEATED SEATS W/O EATC WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BRAKE PEDAL POSITION(BPP) SWITCH (UNDER LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 15 FUSE 6 GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER (LEFT SIDE OF DASH) LT BLU WIRE LT GRN WIRE PARK BRAKE SWITCH (RIGHT SIDE OF PARK BRAKE LEVER) PARKING BRAKE RELEASE DIODE PARKING BRAKE RELEASE SOLENOID (BEHIND LEFT SIDE OF DASH) PARKING BRAKE RELEASE SWITCH (BEHIND LEFT SIDE OF DASH) RED WIRE RED/LT GRN WIRE SHIFT LOCK ACTUATOR (IN STEERING COLUMN) SOLID STATE W/O PARKING BRAKE RELEASE W/PARKING BRAKE RELEASE WHT/YEL WIRE YEL WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 15 FUSE 2 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 KS PWR GND IGN COIL 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE WOT RELAY YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 15 FUSE 2 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND IGN COIL 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE TSS VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE WOT RELAY YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE