Ford Expedition I (1996-2002) dk grn/org Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ABS ACTIVE IN AIR SUSPENSION OUT TRANSFER CASE RETURN BRAKE PEDAL POSITION SWITCH ANTI-LOCK BRAKES SYSTEM (ABS CONTROL MODULE) ANTI-THEFT SYSTEM (RAP MODULE) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE DEFOGGER SYSTEM (REAR DEFOGGER SWITCH) DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DOOR AJAR OUT GENERIC ELECTRONIC MODULE (GEM) (BEHIND LEFT SIDE OF DASH) GRY/LT BLU WIRE LOW WASHER FLUID OUT REAR WASHER PUMP RELAY OUT WASHER FLUID LEVEL SWITCH IN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PNK/BLK WIRE PNK/YEL WIRE REAR SHAFT SPEED SENSOR IN FRONT SHAFT SPEED SENSOR IN REAR WIPER SWITCH IN RED/LT GRN WIRE RED/WHT WIRE TAN WIRE TAN/RED WIRE TAN/YEL WIRE TRANSMISSION CONTROLS SYSTEM (TRANSFER CASE ASSEMBLY) VIO/YEL WIRE WHT WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM (MULTI-FUNCTION SWITCH) YEL/LT BLU WIRE YEL/WHT WIRE

120 OHMS 2200 OHMS 24 10 BATTERY HORN SWITCH IN 68 91 84 VEHICLE SPEED OUT SIGNAL RETURN OSS SENSOR AIR BAG SLIDING CONTACT (TOP OF STEERING COLUMN) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENG COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER LEFT SIDE OF DASH) BRAKE PRESS IN GROUND BRAKE PRESSURE SWITCH (LEFT REAR CORNER OF ENGINE COMPT) BRN/LT GRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 15 CENTRAL SECURITY MODULE (BEHIND LEFT SIDE OF DASH) COAST CONTROL SW IN CONTROL SW GND IGN DK BLU WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE FUSE 13 FUSE 5 FUSE 7 GRY/BLK WIRE GRY/RED WIRE HORN SWITCH HOT AT ALL TIMES HOT IN RUN LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE NCA WIRE OHMS ON OFF OUTPUT SHAFT SPEED (OSS) SENSOR (ON LEFT SIDE OF TRANSMISSION) PNK/BLK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF ENGINE COMPARTMENT) RED/LT GRN WIRE RESUME SET/ ACCEL SPEED CONTROL SERVO (IN LEFT SIDE OF ENGINE COMPT) SPEED CONTROL SWITCH ASSEMBLY STEERING COLUMN ASSEMBLY VEHICLE SPEED INPUT BRAKE APPLIED IN YEL/LT BLU WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 SEAT POSITION SENSOR (+) 1 2 POWER GROUND 1476 1477 (LOWER LEFT INNER KICK PANEL) POWER MIRRORS SYSTEM ADJ. BRAKE PEDAL CIRCUIT ADJ. BRAKE PEDAL CIRCUIT (1998-99) (2000) ADJUSTABLE PEDAL MOTOR (1999-2000 ONLY) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BRN/LT GRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (UNDER CENTER OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DRIVER POWER LUMBER SWITCH (2000 ONLY) DRIVER POWER MOTOR SEAT ASSEMBLY DRIVER POWER SEAT CONTROL SWITCH DRIVER SEAT MODULE (UNDER DRIVER'S SEAT) ENTIRE SEAT FRONT HEIGHT MOTOR FRONT OF SEAT FUSE 20 FUSE 4 FWD/RWD MOTOR GRY WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN LEFT FRONT MOTOR LEFT HORIZ MOTOR PEDAL SENSOR PEDAL FORWARD LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MEM 1 MEM 2 MEMORY SEAT SWITCH NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE ORG/WHT WIRE PEDAL, MIRROR MODULE) PNK/BLK WIRE POWER MIRRORS SYSTEM POWER MIRRORS SYSTEM 954 951 REAR HEIGHT MOTOR REAR OF SEAT RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RWD SET- VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

AIR BAG SLIDING CONTACT BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLOCK 1 (BEHIND RIGHT SIDE OF DASH) CLIMATE CONTROL SYSTEM DK BLU WIRE DK GRN/ORG WIRE DK/BLU WIRE FUSE 7 HORN RELAY HORN SWITCH HORN- RIGHT HOT AT ALL TIMES NCA WIRE REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND LEFT SIDE OF DASH) RPO RELAY SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPT) STEERING COLUMN ASSEMBLY YEL/LT BLU WIRE YEL/LT GRN WIRE

4 WHEEL ANTI- LOCK BRAKE SYSTEM MODULE (ON LEFT SIDE OF ENGINE COMPT) 820 OHMS AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) AIRBAG IND ANTI-LOCK BRAKES SYSTEM ANTI-LOCK IND BELT MINDER MODULE (BEHIND CENTER OF DASH) (2001) BIAS CKT BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE FLUID LEVEL INDICATOR SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE IND CENTRAL JUNCTION BOX CHARGE IND CHECK SUSPENSION IND CLOCK COMPUTER DATA LINES SYSTEM CONN A CONN B CRUISE CONTROL IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE DOOR AJAR IND ENGINE OIL PRESSURE SWITCH (ON LEFT FRONT OF ENGINE, NEXT TO P/S PUMP) FASTEN SAFETY BELT IND FUEL PUMP ASSEMBLY (UNDER VEHICLE, AT FUEL TANK) FUEL PUMP MODULE FUSE 18 FUSE 2 FUSE 30 FUSE 6 FUSE 8 GENERIC ELECTRONIC MODULE (BEHIND LEFT SIDE OF DASH) GRY WIRE GRY/ORG WIRE GRY/WHT WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN PARK OR HEAD HOT IN RUN HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LEFT TURN IND LOW FUEL IND LOW OIL/HIGH COOLANT IND LOW WASHER FLUID IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION INDICATOR MICRO- PROCESSOR MICROPROCESSOR NCA WIRE ORG/LT BLU WIRE OVERHEAD TRIP COMPUTER MODULE (IN FRONT OF OVERHEAD CONSOLE) PARKING BRAKE SWITCH (ON RIGHT SIDE OF PARK BRAKE LEVER) PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER MODULE (BEHIND CENTER OF DASH) PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) RIGHT TURN IND RX INPUT TX INPUT SHIFT INTERLOCK SYSTEM SPEED CONTROL SERVO (LEFT SIDE OF ENG COMPT) STARTING/CHARGING SYSTEM TAN/LT GRN WIRE TAN/ORG WIRE THEFT INDICATOR MICRO CLUSTER WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

ADJUST- ABLE PEDAL SWITCH AIRBAG SLIDILNG CONTACT 4 WHEEL DRIVE MODE SWITCH AIRBAG SLIDING CONTACT ASHTRAY ILLUMINATION BATTERY JUNCTION BOX BLK WIRE BLK/LT BLU WIRE BLU WIRE BRN WIRE CENTRAL JUNCTION BOX CIGAR LIGHTER CLOCK CLOCK NAVIGATION SYSTEM MODULE (NAVIGATOR) DIMMER MODULE DK BLU/WHT WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE EXPEDITION, NAVIGATOR EXTERIOR LIGHTS CIRCUIT FRONT BLOWER ILLUMI- NATION SWITCH FRONT BLOWER ILLUMINATION SWITCH FULL OVERHEAD CONSOLE OR XLT FUSE 18 FUSE 6 HEAD OFF HOT AT ALL TIMES INSTRUMENT CLUSTER (6 BULBS) LEFT FRONT POWER DOOR LOCK SWITCH LEFT FRONT POWER WINDOW SWITCH LEFT REAR WINDOW SWITCH LEFT REAR VENT WINDOW SWITCH LT BLU WIRE LT BLU/RED WIRE MAIN LIGHT SWITCH MINI OVERHEAD CONSOLE NCA WIRE OVERHEAD CONSOLE PARK PARKING AID DISABLE SWITCH NAV- IGATION CONTROL PANEL (NAV- IGATOR) RADIO FUNCTION SELECTOR SWITCH REAR BLOWER ILLUMI- NATION SWITCH REAR BLOWER ILLUMINATION SWITCH REAR INTE- GRATED CONTROL PANEL REAR WINDOW DEFOGGER SWITCH RED WIRE RIGHT FRONT POWER WINDOW SWITCH RIGHT FRONT POWER DOOR LOCK SWITCH RIGHT REAR VENT WINDOW SWITCH RIGHT REAR WINDOW SWITCH ROOF OPENING PANEL SWITCH STEERING COLUMN ASSEMBLY TAN/WHT WIRE W/FULL OVERHEAD CONSOLE W/O AUX A/C XLT ONLY

1999 ONLY BLK WIRE BLK/LT BLU WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (UNDER CENTER OF DASH) DEFOGGER SYSTEM DIRECT- TIONAL SWITCH DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DRIVER SEAT MODULE (UNDER DRIVER'S SEAT) FUSE 4 GRY WIRE GRY/RED WIRE HORIZ HORIZ MTR HOT AT ALL TIMES LEFT EXTERIOR REAR VIEW MIRROR LEFT HEATED MIRROR LEFT/RIGHT MIRROR SELECT SWITCH LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE POWER MIRROR SWITCH RED WIRE RED/ORG WIRE RED/WHT WIRE RIGHT EXTERIOR REAR VIEW MIRROR RIGHT HEATED MIRROR VERT VERT MTR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND GROUND 1 2 3 4 5 6 7 8 9 10 HIGH AUDIO MUTE GROUND 1 2 3 4 5 6 7 8 SUBWOOFER (-) SUBWOOFER (+) AUDIO SHIELD HIGH AUDIO MUTE 19 57 694 INTERIOR LIGHTS 434 57 1000 57 802 803 805 811 797 1499 694 800 801 804 813 694 INTERIOR LIGHTS AIR BAG SLIDING CONTACT AMP L REAR (+) AMP R REAR (+) AUDIO ON AUDIO SYSTEM ON AUDIO NETWORK AUDIO NETWORK AUDIO/ CLIMATE CONTROL SWITCH ASSEMBLY BAND MEM UP DWN BARE BLK WIRE BLK/LT GRN WIRE BODY COMPUTER BRN/LT BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CD CHANGER CELLULAR PHONE WIRING CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK GRN/ORG WIRE DK GRN/VIO WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE (BEHIND CENTER OF DASH) FUSE 1 FUSE 20 FUSE 31 GENERIC ELECTRONIC MODULE GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN LEFT FRONT SPEAKER LEFT REAR SPEAKER LEFT SIG (-) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK/LT GRN WIRE POWER POWER SUBWOOFER (+) SUBWOOFER (-) PROTOCOL A PROTOCOL B PROTOCOL B PROTOCOL A R REAR SIG (-) R REAR SIG (+) L REAR SIG (-) L REAR SIG (+) POWER AUDIO SYTEM ON RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT SIG SHIELD SUB SPEAKER (-) SUBWOOFER SUBWOOFER AMPLIFIER TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VSS WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND GROUND 19 57 694 INTERIOR LIGHTS AMP L REAR (+) AMP R REAR (+) ANTENNA AUDIO ON AUDIO SYSTEM ON AUDIO NETWORK AUDIO NETWORK BARE BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN/PNK WIRE CD CHANGER CELLULAR PHONE WIRING CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK GRN/ORG WIRE FUSE 1 FUSE 20 FUSE 31 FUSE 8 GENERIC ELECTRONIC MODULE GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC INTERIOR LIGHTS LEFT FRONT SPEAKER LEFT REAR SPEAKER LEFT SIG (-) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWER PROTOCOL A PROTOCOL B PROTOCOL B PROTOCOL A R REAR SIG (-) R REAR SIG (+) L REAR SIG (-) L REAR SIG (+) POWER AUDIO SYTEM ON RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT SIG SHIELD TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VEHICLE SPEED SIG CELL PHONE CELL PHONE (-) CELL PHONE (+) CELL PHONE SHIELD VIO WIRE VSS WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE