Ford Expedition I (1996-2002) brn Wiring diagrams

8 9 10 11 12 13 14 21 22 23 24 25 26 STEERING WHL SW BLEND DOOR ACT GND A/C PRESS CUTOFF SIG AIR BAG SLIDING CONTACT (AT BASE OF STEERING COLUMN) AMBIENT AIR TEMPERATURE SENSOR (LEFT FRONT OF ENGINE COMPARTMENT) AUDIO/CLIMATE CONTROL SWITCH ASSEMBLY AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR SPEED CONTROLLER (BEHIND RIGHT SIDE OF DASH) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 2 DK BLU/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FUSE 105 FUSE 13 FUSE 22 FUSE 23 HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IN-CAR TEMPERATURE SENSOR (BEHIND CENTER OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/ORG WIRE NCA WIRE ORG/ WIRE PNK WIRE PNK/ 1 2 3 4 5 6 7 15 16 17 18 19 20 WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE SOLID STATE SPC (-) BATTERY GROUND SENSOR INPUT GND STEERING COLUMN ASSEMBLY SUNLOAD SENSOR (TOP RIGHT SIDE OF DASH) TAN/ORG WIRE VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

ANTI-LOCK BRAKES SYSTEM AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) CONSOLE BLOWER RELAY DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER CENTER OF DASH) DK GRN/YEL WIRE FUSE 23 FUSE 7 GRY WIRE GRY/LT BLU WIRE GRY/WHT WIRE HOT IN RUN INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT GRN WIRE PNK WIRE PNK/ (MAIN HARNESS, NEAR BREAKOUT TO PASSENGER AIR BAG) WIRE PNK/ 15 16 41 69 WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPARTMENT) REAR MODE POTENTIOMETER RED WIRE RED/YEL WIRE RPO RELAY BLOCK 1 (BEHIND RIGHT SIDE OF DASH, ABOVE PASSENGER AIR BAG) SOLID STATE TAN WIRE TAN/ORG WIRE VIO WIRE W/O ROOF OPENING PANEL WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE WOT RELAY YEL WIRE YEL/BLK WIRE YEL/RED WIRE YEL/WHT WIRE

0.6 OHMS 2 OHMS 2.7 OHMS 3.8 OHMS 4.6L 5.4L A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT REAR CORNER OF ENGINE COMPARTMENT) A/C CLUTCH DIODE A/C COMPRESSOR CLUTCH SOLENOID (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C PRESSURE CUT-OFF SWITCH (IN RIGHT SIDE OF ENGINE COMPARTMENT) AUXILIARY A/C BLOWER MOTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C BLOWER MOTOR RESISTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C RELAY BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE 114 BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE CONSOLE BLEND DOOR ACTUATOR (INSIDE LEFT CENTER OF FLOOR CONSOLE) CONSOLE BLOWER MOTOR (INSIDE CENTER OF FLOOR CONSOLE) CONSOLE BLOWER MOTOR RESISTOR (IN CENTER OF FLOOR CONSOLE) DK BLU/WHT WIRE DK DK DK GRN/YEL WIRE FRONT BLOWER MOTOR SWITCH GRY/WHT WIRE HOT AT ALL TIMES LOW MED LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT LT MED OFF OFF LOW OFF LOW MED OFF REAR ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE REAR BLOWER MOTOR SWITCH REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RPO RELAY BLOCK 2 (IN FRONT OF LEFT REAR WHEELWELL) VIO WIRE W/O ROOF OPENING PANEL WHT WIRE WHT/LT BLU WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENG COMPT) BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DEFROST SWITCH INPUT DK BLU WIRE DK GRN WIRE DK GRN/VIO WIRE FUSE 116 FUSE 17 FUSE 6 GENERIC ELECTRONIC MODULE (UNDER LEFT SIDE OF DASH) DEFROST RELAY CONTROL HEATED GRID RELAY HOT AT ALL TIMES HOT IN RUN LEFT POWER/ HEATED MIRROR RIGHT POWER/ HEATED MIRROR LT BLU WIRE NCA WIRE ON INDICATOR ON/OFF SWITCH ORG/ WIRE REAR HEATED WINDOW SWITCH REAR WINDOW DEFROST GRID RED WIRE SWITCH ILLUM. VIO WIRE

2 3 4 ROTATION RATE INPUT VEHICLE SIGNAL INPUT IGNITION AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) ENGINE CONTROL SYSTEM EVO ACT OUTPUT EVO ACTUATOR (LEFT SIDE OF ENGINE COMPT) FUSE 6 GENERIC ELECTRONIC MODULE GROUND GRY/BLK WIRE GRY/YEL WIRE HOT IN RUN NCA WIRE ORG/ WIRE RED WIRE RED/YEL WIRE ROTATION RATE INPUT SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPARTMENT) STEERING WHEEL ROTATION SENSOR (BEHIND STEERING WHEEL, IN DASH) YEL WIRE

5 4 2 EVO DIAGNOSTIC CONNECTOR (LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPARTMENT) ELECTRONIC VARIABLE ORIFICE (EVO) MODULE (BEHIND CENTER OF DASH) ENGINE CONTROL SYSTEM EVO ACT OUTPUT EVO ACT OUTPUT EVO ACTUATOR (LEFT SIDE OF OF ENGINE FUSE 6 FUSE 5 GENERIC ELECTRONIC MODULE GRY/BLK WIRE GRY/YEL WIRE HOT IN RUN LT BLU/PNK WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/LT BLU WIRE PNK/ORG WIRE RED WIRE RED/YEL WIRE SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPARTMENT) STEERING WHEEL ROTATION SENSOR (BEHIND STEERING WHEEL, IN DASH) YEL WIRE

11 12 13 14 15 16 17 18 19 20 GEM INPUT WARNING INDICATOR 1999 ONLY 421 900 57 TRANSMISSION CONTROLS AIR SUSPENSION COMPRESSOR MOTOR AND VENT SOLENOID (RIGHT RADIATOR SUPPORT) AIR SUSPENSION COMPRESSOR RELAY (NEAR RIGHT HEADLAMP) AIR SUSPENSION INDICATOR AIR SUSPENSION SERVICE SWITCH (UNDER RIGHT SIDE OF DASH) AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 109 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (UNDER CENTER OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EVO MODULE FRONT AIR FILL SOLENOID (NEAR TRANS COOLER) FRONT GATE SOLENOID (FRONT OF A/C CONDENSER) FUSE 2 FUSE 20 FUSE 4 FUSE 6 GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LEFT REAR AIR SPRING SOLENOID (IN FRONT OF LEFT REAR WHEEL) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE MEMORY SYSTEMS ORG/BLK WIRE ORG/LT GRN WIRE PNK WIRE REAR AIR FILL SOLENOID REAR HEIGHT SEN BPP SWITCH SERVICE SWITCH STEERING SENSOR POWER (START) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT REAR AIR SPRING SOLENOID (IN FRONT OF RIGHT REAR WHEEL) RUN WIRE SOLID STATE TAN WIRE TAN/WHT WIRE VIO/LT GRN WIRE VIO/ORG WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DRVR UNLOCK 1/2 INPUT 3/4 INPUT 7/8 INPUT 9/0 INPUT 5/6 INPUT ALL LOCK/ ANTENNA BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPT) FUSE 8 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMMON DATA LINK CONNECTOR (UNDER CENTER OF DASH) DATALINK DIGITAL TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF AUTOMATIC TRANSMISSION) DISABLE IGNITION BPP SWITCH DK BLU WIRE DOOR AJAR OUT DOOR AJAR TRANS IN DOOR LOCKS SYSTEM DRIVER'S UNLOCK RELAY (BEHIND RIGHT SIDE OF DASH, IN LOCK RELAY BLOCK) ELECTRONIC SUSPENSION SYSTEM EXT LIGHTS FUSE 15 FUSE 4 FUSE 5 FUSE 8 HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC ILLUM ENTRY IN ILLUMINATION INT LIGHTS ALL UNLOCK POWER DISABLE GROUND ILLUM KEYLESS ENTRY SWITCH ASSEMBLY LEFT FRONT POWER DOOR LOCK SWITCH LOCK LOCK UNLOCK LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MEM SEAT MEMORY SYSTEMS NCA WIRE ORG/ WIRE ORG/LT GRN WIRE PNK PNK WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RIGHT FRONT POWER DOOR LOCK SWITCH RUN WIRE UNLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

AUXILIARY A/C BLEND ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C CONTROL MODULE (IN REAR OF VEHICLE, BEHIND LEFT SIDE OF PANEL) AUXILIARY A/C MODE ACTUATOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) BLEND DOOR ACTUATOR (BEHIND CENTER OF DASH) BLK LT GRN/ WIRE BLK WIRE BLOWER MOTOR (ON RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER RELAY BLOWER/FLASHER RELAY BLOCK (BEHIND CENTER OF DASH) BRN WIRE BRN/ WHT WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COLD BLEND DOOR POTENT- IOMETER DK GRN/YEL WIRE FUSE 23 FUSE 5 FUSE 7 GRY/ LT BLU WIRE GRY/LT BLU WIRE HOT IN RUN HOT IN RUN CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 22 ILLUMINATION LT BLU GRY/ WIRE LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/WHT WIRE MAX A/C NORM A/C MED HIGH HIGH BLOWER MOTOR SWITCH MED LOW ORG/ BRN WIRE ORG/BLK WIRE PAN, FLR FLOOR FLR, DEF DEF MODE SELECTOR SWITCH PAN/FLR FLOOR DEF/FLR DEF MAX A/C NORM A/C PANEL OFF PANEL OFF PNK WIRE PNK/ LT GRN WIRE PNK/LT GRN WIRE REAR MODE POTENTIOMETER RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/WHT WIRE SOLID STATE SOLID STATE 5 6 7 8 SUPPLEMENTAL RESTRAINTS SYSTEM VIO WIRE VIO/ORG WIRE W/O ROOF OPENING PANEL WARM FUNCTION SELECTOR SWITCH ASSEMBLY WHT BRN WIRE WHT WIRE WHT/LT BLU WIRE WHT/VIO WIRE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE YEL/WHT WIRE

0.6 OHMS 2.7 OHMS 3.8 OHMS 3.8 OHMS 2.7 OHMS 0.6 OHMS 4.6L 5.4L 69 41 331 347 WOT RELAY ACCS A/C CLUTCH CYCLING PRESSURE SWITCH (IN RIGHT REAR CORNER OF ENGINE COMPARTMENT) A/C CLUTCH DIODE A/C COMPRESSOR CLUTCH SOLENOID (IN RIGHT FRONT OF ENGINE COMPARTMENT) A/C PRESSURE CUT-OFF SWITCH (IN RIGHT SIDE OF ENGINE COMPARTMENT) AUXILIARY A/C BLOWER MOTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C BLOWER MOTOR RESISTOR (IN REAR OF VEHICLE, BEHIND LEFT SIDE PANEL) AUXILIARY A/C RELAY BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK ORG/ WIRE BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE CONSOLE BLOWER MOTOR (INSIDE CENTER OF FLOOR CONSOLE) DK BLU/WHT WIRE DK GRN/YEL WIRE FRONT BLOWER MIOTOR SWITCH FUSE 114 FUSE 13 FUSE 23 GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LOW MED LT BLU PNK/ WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE OFF OFF LOW MED OFF REAR ORG RED/ WIRE ORG-LT BLU WIRE ORG/BLK WIRE ORG/RED WIRE PNK WIRE PNK/ WHT WIRE PNK/LT BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON RIGHT SIDE OF ENGINE COMPARTMENT) REAR BLOWER MOTOR SWITCH REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED ORG/ WIRE RED YEL/ WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RPO RELAY BLOCK 2 (IN FRONT OF LEFT REAR WHEELWELL) VIO WIRE W/O ROOF OPENING PANEL W/ROOF PANEL OPENING WHT LT GRN/ WIRE WHT WIRE WHT/ DK BLU WIRE WHT/LT BLU WIRE WOT RELAY YEL BLK/ WIRE YEL RED/ WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE