Ford Expedition I (1996-2002) blk/pnk Wiring diagrams

1400 OHM 4-WHEEL ANTI-LOCK BRAKE 820 OHM ANTI- LOCK IND BIAS CKT BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE 102 BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BRAKE FLUID LEVEL INDICATOR SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DIFFERENTIAL SPEED SENSOR (DSS) (ON REAR AXLE) DK GRN WIRE DK GRN/YEL WIRE FUSE 15 FUSE 23 FUSE 6 GENERIC ELECTRONIC MODULE (GEM) GROUND POWER INPUT GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN IGNITION FEED INSTRUMENT CLUSTER LEFT FRONT LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE ORG/YEL WIRE PROCESSOR MICRO- RED/LT GRN WIRE RED/PNK WIRE RIGHT FRONT SENSOR (AT WHEEL) TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE WHT WIRE WHT/ORG WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/RED WIRE

BLK WIRE BLK/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF AUTOMATIC TRANSMISSION) EXTERIOR LAMPS (TRAILER TOW BACK-UP LAMP RELAY) FUSE 5 HOT IN RUN LT BLU WIRE MIRRORS SYSTEM (W ELECTRO- CHROMIC REAR VIEW ONLY) PNK LEFT REVERSING LAMP WIRE PNK RIGHT REVERSING LAMP WIRE PNK WIRE REMOTE ANTI-THEFT PERSONALITY MODULE (BEHIND LEFT SIDE OF DASH)

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ABS ACTIVE IN AIR SUSPENSION OUT TRANSFER CASE RETURN BRAKE PEDAL POSITION SWITCH ANTI-LOCK BRAKES SYSTEM (ABS CONTROL MODULE) ANTI-THEFT SYSTEM (RAP MODULE) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE DEFOGGER SYSTEM (REAR DEFOGGER SWITCH) DK BLU WIRE DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DOOR AJAR OUT GENERIC ELECTRONIC MODULE (GEM) (BEHIND LEFT SIDE OF DASH) GRY/LT BLU WIRE LOW WASHER FLUID OUT REAR WASHER PUMP RELAY OUT WASHER FLUID LEVEL SWITCH IN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PNK/BLK WIRE PNK/YEL WIRE REAR SHAFT SPEED SENSOR IN FRONT SHAFT SPEED SENSOR IN REAR WIPER SWITCH IN RED/LT GRN WIRE RED/WHT WIRE TAN WIRE TAN/RED WIRE TAN/YEL WIRE TRANSMISSION CONTROLS SYSTEM (TRANSFER CASE ASSEMBLY) VIO/YEL WIRE WHT WIRE WHT/ORG WIRE WHT/RED WIRE WHT/VIO WIRE WIPER/WASHER SYSTEM (MULTI-FUNCTION SWITCH) YEL/LT BLU WIRE YEL/WHT WIRE

120 OHMS 2200 OHMS 24 10 BATTERY HORN SWITCH IN 68 91 84 VEHICLE SPEED OUT SIGNAL RETURN OSS SENSOR AIR BAG SLIDING CONTACT (TOP OF STEERING COLUMN) BATTERY JUNCTION BOX (ON LEFT SIDE OF ENG COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER LEFT SIDE OF DASH) BRAKE PRESS IN GROUND BRAKE PRESSURE SWITCH (LEFT REAR CORNER OF ENGINE COMPT) BRN/LT GRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) FUSE 15 CENTRAL SECURITY MODULE (BEHIND LEFT SIDE OF DASH) COAST CONTROL SW IN CONTROL SW GND IGN DK BLU WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE FUSE 13 FUSE 5 FUSE 7 GRY/BLK WIRE GRY/RED WIRE HORN SWITCH HOT AT ALL TIMES HOT IN RUN LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN/RED WIRE NCA WIRE OHMS ON OFF OUTPUT SHAFT SPEED (OSS) SENSOR (ON LEFT SIDE OF TRANSMISSION) PNK/BLK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF ENGINE COMPARTMENT) RED/LT GRN WIRE RESUME SET/ ACCEL SPEED CONTROL SERVO (IN LEFT SIDE OF ENGINE COMPT) SPEED CONTROL SWITCH ASSEMBLY STEERING COLUMN ASSEMBLY VEHICLE SPEED INPUT BRAKE APPLIED IN YEL/LT BLU WIRE YEL/WHT WIRE

11 12 13 14 15 16 17 18 19 20 GEM INPUT WARNING INDICATOR 1999 ONLY 421 900 57 TRANSMISSION CONTROLS AIR SUSPENSION COMPRESSOR MOTOR AND VENT SOLENOID (RIGHT RADIATOR SUPPORT) AIR SUSPENSION COMPRESSOR RELAY (NEAR RIGHT HEADLAMP) AIR SUSPENSION INDICATOR AIR SUSPENSION SERVICE SWITCH (UNDER RIGHT SIDE OF DASH) AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 109 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRN WIRE BRN/ORG WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR (UNDER CENTER OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EVO MODULE FRONT AIR FILL SOLENOID (NEAR TRANS COOLER) FRONT GATE SOLENOID (FRONT OF A/C CONDENSER) FUSE 2 FUSE 20 FUSE 4 FUSE 6 GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER LEFT REAR AIR SPRING SOLENOID (IN FRONT OF LEFT REAR WHEEL) LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/RED WIRE MEMORY SYSTEMS ORG/BLK WIRE ORG/LT GRN WIRE PNK WIRE REAR AIR FILL SOLENOID REAR HEIGHT SEN BPP SWITCH SERVICE SWITCH STEERING SENSOR POWER (START) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT REAR AIR SPRING SOLENOID (IN FRONT OF RIGHT REAR WHEEL) RUN WIRE SOLID STATE TAN WIRE TAN/WHT WIRE VIO/LT GRN WIRE VIO/ORG WIRE YEL/BLK WIRE

BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION (BPP) SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC VARIABLE ORIFICE (EVO) ACTUATOR (LEFT SIDE OF ENGINE COMPT) ELECTRONIC VARIABLE ORIFICE (EVO) DIAGNOSTIC CONNECTOR (UNDER LEFT SIDE OF DASH) EXPEDITION ONLY FRONT HEIGHT SENSOR (BEHIND LEFT RUNNING BOARD) FUSE 11 GENERIC ELECTRONIC (GEM) MODULE (BEHIND LEFT SIDE OF DASH) GENERIC ELECTRONIC MODULE (GEM) GRY/BLK WIRE GRY/YEL WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER LT BLU/BLK WIRE LT BLU/WHT WIRE NCA WIRE ORG/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) REAR HEIGHT SENSOR (REAR FLOOR PANEL) RED WIRE RED/LT GRN WIRE RED/YEL WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) SPEED CONTROL SERVO (LEFT SIDE OF ENGINE COMPT) STEERING WHEEL ROTATION SENSOR (BEHIND STEERING WHEEL, IN DASH) TAN WIRE VIO/LT GRN WIRE WHT/YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 DRVR UNLOCK 1/2 INPUT 3/4 INPUT 7/8 INPUT 9/0 INPUT 5/6 INPUT ALL LOCK/ ANTENNA BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPT) FUSE 8 BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (UNDER LEFT SIDE OF DASH) BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) COMMON DATA LINK CONNECTOR (UNDER CENTER OF DASH) DATALINK DIGITAL TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF AUTOMATIC TRANSMISSION) DISABLE IGNITION BPP SWITCH DK BLU WIRE DOOR AJAR OUT DOOR AJAR TRANS IN DOOR LOCKS SYSTEM DRIVER'S UNLOCK RELAY (BEHIND RIGHT SIDE OF DASH, IN LOCK RELAY BLOCK) ELECTRONIC SUSPENSION SYSTEM EXT LIGHTS FUSE 15 FUSE 4 FUSE 5 FUSE 8 HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC ILLUM ENTRY IN ILLUMINATION INT LIGHTS ALL UNLOCK POWER DISABLE GROUND ILLUM KEYLESS ENTRY SWITCH ASSEMBLY LEFT FRONT POWER DOOR LOCK SWITCH LOCK LOCK UNLOCK LT BLU WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE MEM SEAT MEMORY SYSTEMS NCA WIRE ORG/ WIRE ORG/LT GRN WIRE PNK PNK WIRE PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE REMOTE ANTI-THEFT PERSONALITY (RAP) MODULE (BEHIND LEFT SIDE OF DASH) RIGHT FRONT POWER DOOR LOCK SWITCH RUN WIRE UNLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

4 WHEEL ANTI- LOCK BRAKE SYSTEM MODULE (ON LEFT SIDE OF ENGINE COMPT) 820 OHMS AIR SUSPENSION/ EVO STEERING MODULE (BEHIND CENTER OF DASH) AIRBAG IND ANTI-LOCK BRAKES SYSTEM ANTI-LOCK IND BELT MINDER MODULE (BEHIND CENTER OF DASH) (2001) BIAS CKT BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE FLUID LEVEL INDICATOR SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE IND CENTRAL JUNCTION BOX CHARGE IND CHECK SUSPENSION IND CLOCK COMPUTER DATA LINES SYSTEM CONN A CONN B CRUISE CONTROL IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE DOOR AJAR IND ENGINE OIL PRESSURE SWITCH (ON LEFT FRONT OF ENGINE, NEXT TO P/S PUMP) FASTEN SAFETY BELT IND FUEL PUMP ASSEMBLY (UNDER VEHICLE, AT FUEL TANK) FUEL PUMP MODULE FUSE 18 FUSE 2 FUSE 30 FUSE 6 FUSE 8 GENERIC ELECTRONIC MODULE (BEHIND LEFT SIDE OF DASH) GRY WIRE GRY/ORG WIRE GRY/WHT WIRE GRY/YEL WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT AT ALL TIMES HOT IN ACCY OR RUN HOT IN PARK OR HEAD HOT IN RUN HOT IN START OR RUN ILLUMINATION INSTRUMENT CLUSTER LEFT TURN IND LOW FUEL IND LOW OIL/HIGH COOLANT IND LOW WASHER FLUID IND LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION INDICATOR MICRO- PROCESSOR MICROPROCESSOR NCA WIRE ORG/LT BLU WIRE OVERHEAD TRIP COMPUTER MODULE (IN FRONT OF OVERHEAD CONSOLE) PARKING BRAKE SWITCH (ON RIGHT SIDE OF PARK BRAKE LEVER) PASSIVE ANTI-THEFT SYSTEM TRANSCEIVER MODULE (BEHIND CENTER OF DASH) PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RESTRAINTS CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) RIGHT TURN IND RX INPUT TX INPUT SHIFT INTERLOCK SYSTEM SPEED CONTROL SERVO (LEFT SIDE OF ENG COMPT) STARTING/CHARGING SYSTEM TAN/LT GRN WIRE TAN/ORG WIRE THEFT INDICATOR MICRO CLUSTER WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 15 FUSE 2 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 KS PWR GND IGN COIL 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE WOT RELAY YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BATTERY JUNCTION BOX (ON LEFT SIDE OF ENGINE COMPARTMENT) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF ENGINE) CENTRAL JUNCTION BOX (UNDER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DPFE SENS CYL HEAD TEMP CANISTER VENT VSS (+) WOT RELAY FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 15 FUSE 2 GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CAM POS IN LT BLU WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS IN TP SENS IN MASS AIRFLOW (MAF) SENSOR (IN AIR CLEANER ASSEMBLY) NCA WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (RIGHT SIDE OF ENGINE COMPT) PWR GND IGN COIL 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RTN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE TSS VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE WOT RELAY YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE