Ford Excursion I (1999-2005) vio/yel Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 NUET SENS 1 PNK/ WIRE 33 22 (PICK-UP) AUXILIARY RELAY BOX 3 (LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION SWITCH COMPUTER DATA LINES CONNECTOR DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE DTR SENSOR, PARK BRAKE RELAY, GAS: SPEED CONTROL SERVO, DSL: VACUUM PUMP MOTOR ELECTRONIC SHIFT-ON-THE-FLY (ESOF) SOLENOID (RIGHT SIDE OF ENGINE COMPT) EXCURSION: PATS MODULE, EATC MODULE FOUR WHEEL DRIVE SWITCH FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 111 FUSE 27 FUSE 31 FUSE 33 FUSE 34 FUSE 45 GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START IGN (ST) B+ IGN (ST/RUN) ILLUM INSTRUMENT CLUSTER INSTRUMENT CLUSTER, WINDSHIELD WIPER MOTOR, PICKUP: FUEL TANK SELECTOR SWITCH ISO BUS GROUND LO TO HI HI TO LO BPP SW LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE MOTOR 5 MOTOR 2 MOTOR 3 MOTOR 4 OFF ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PICKUP PNK PNK WIRE PNK WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT SHIFT SOL ESOF SOL ESOF SOL REVERSE RUN WIRE TRANSFER CASE ASSEMBLY TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VIO/YEL (OR BLK/PNK) WIRE VIO/YEL WIRE VPWR VSS IN VSS OUT WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE YEL WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION MODULE (ON LEFT SIDE OF TRANSMISSION) BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID EVR SOLENOID VALVE (CALIFORNIA) (ON LEFT SIDE OF ENGINE) FUEL INJECTORS GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT M/T ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VAPOR MANAGEMENT VALVE (ON RIGHT REAR OF ENGINE COMPT) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE

199 352 1102 91 1100 331 (A/T) (CALIF) A/C SYSTEM A/T ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 34 FUSE 36 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEGO 12 HEATER CTRL HEGO 21 MAF SENS IN TP SENS IN HOT AT ALL TIMES IGN COIL 4 TCC SOL KAP B(+) VAPOR VALVE KNOCK SENSOR VSS (+) TSS HEGO 11 KNOCK SENSOR (ON LEFT CYL HEAD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MASS AIRFLOW (MAF) SENSOR (IN LEFT FRONT OF ENGINE COMPT) NCA WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 NOT USED PWR GND IGN COIL 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/T AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) FUSE 1 BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/ORG WIRE COMMUMINCATION CYLINDER ID DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ LT GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE DRAIN WIRE FUEL DEL COM GRY/ORG WIRE INJECTOR DRIVER MODULE (IDM) (MOUNTED ON REAR OF LEFT VALVE COVER) LINE PRESS SOL LOGIC PWR LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/YEL WIRE NEUTRAL SW SEN ORG/BLK WIRE ORG/WHT WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PRESSURE CONTROL SOLENOID PRESSURE SW 1 IN PRESSURE SW 2 IN PRESSURE SW 3 IN PRESSURE SW 4 IN PRESSURE SW 5 IN PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT REV LMP RLY CTRL RLY CTRL BAT FEED SIG RTN TCC SOL. CTRL TFT SENS TRAN RANGE SENS TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE SENSOR (TRS) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/ BLK WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION CONTROL MODULE (ON LEFT SIDE OF TRANSMISSION) BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROLLER FUEL INJECTORS GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT LT M/T ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VAPOR MANAGEMENT VALVE (ON RIGHT REAR OF ENGINE COMPT) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

199 352 1102 91 1100 331 (A/T) (CALIF) A/C SYSTEM A/T ANTI-LOCK BRAKES SYSTEM BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CYL HEAD TEMP CANISTER VENT FUEL INJ 9 A/C CLTCH RLY DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 34 FUSE 36 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HEATED OXYGEN SENSOR SENSOR HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEGO 12 HEATER CTRL HEGO 21 MAF SENS IN TP SENS IN HOT AT ALL TIMES IGN COIL 7 TCC SOL KAP B(+) EVAP PURGE KNOCK SENSOR VSS (+) TSS HEGO 11 KNOCK SENSOR (ON LEFT CYL HEAD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MASS AIRFLOW (MAF) SENSOR (IN LEFT FRONT OF ENGINE COMPT) NCA WIRE NOT USED PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 IGN COIL 4 PWR GND IGN COIL 3 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) AUTOMATIC TRANSMISSION MODULE BLK/LT BLU WIRE BLK/PNK WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE OIL TEMPERATURE (EOT) SENSOR (ON TOP FRONT OF ENGINE) FEEDBACK FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 4 FUEL INJ 5 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 FUEL INJECTORS FUEL SIG GRY WIRE GRY/RED WIRE GRY/WHT WIRE INJ FEED INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT, BEHIND AIR CLEANER) LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/YEL WIRE PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIELD SHIFT SHIFT SOLENOID SOLENOID SIG RTN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

ACCL POS SENS VREF SIG RTN BPP SW AIR CHARGE TEMPERATURE (ACT) SENSOR (CENTER FRONT OF ENGINE, IN INTAKE SYSTEM) AIR INTAKE HEATER BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (ON LOWER FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CMP RTN TAKE OFF PWR IN CHARGE IND CRUISE CONTROL SYSTEM CUSTOMER ACCESS DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL PUMP RLY FUEL DELIV SIG CID SIG PWR IN PCM TO RELAY FUSE 34 FUSE 36 FUSE LINK GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES ICP SENS IPR SENS TSS SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD INTAKE AIR HEATER RELAY (AT TOP RIGHT SIDE OF ENGINE) MAP SENS IDM ENABLE OUT EPC SOL PICKUP PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TCC PWR VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VSS (+) OSS SENS GEN PWR SPEED CTRL SW ACT SENS VSS OUT WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) AUTOMATIC TRANSMISSION MODULE BLK/LT BLU WIRE BLK/PNK WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE OIL TEMPERATURE (EOT) SENSOR (ON TOP FRONT OF ENGINE) FEEDBACK FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 4 FUEL INJ 5 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 FUEL INJECTORS FUEL SIG GRY WIRE GRY/RED WIRE GRY/WHT WIRE INJ FEED INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT, BEHIND AIR CLEANER) LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/YEL WIRE PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIELD SHIFT SHIFT SOLENOID SOLENOID SIG RTN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

AIR CHARGE TEMPERATURE (ACT) SENSOR (CENTER FRONT OF ENGINE, IN INTAKE SYSTEM) BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (ON LOWER FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CMP RTN TAKE OFF PWR IN CHARGE IND CRUISE CONTROL SYSTEM CUSTOMER ACCESS DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL PUMP RLY FUEL DELIV SIG CID SIG PWR IN PCM TO RELAY FUSE 34 FUSE 36 GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES ICP SENS IPR SENS TSS SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAP SENS IDM ENABLE OUT EPC SOL NOT USED PICKUP PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TCC PWR VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VSS (+) OSS SENS GEN PWR SPEED CTRL SW ACT SENS VSS OUT WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE