Ford Excursion I (1999-2005) pwr in Wiring diagrams

10 11 CHASSIS GND PWR GND 6 14 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/WHT WIRE BRAKE PED POS SW BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COOL TEMP SENS DK BLU/ORG WIRE EGR THRTL POS ENGINE COOLANT TEMPERATURE (ECT) SENSOR FUSE 116 FUSE 22 FUSE 34 FUSE 45 GRADE/LOAD SWITCH GRD/LOAD SW GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION SWITCH INJECTOR DRIVER MODULE, FUEL HEATER RELAY INTK AIR TEMP SENS LOCK LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE MAF SENS SIG RTN NCA WIRE OFF ORG/LT BLU WIRE PCM POWER DIODE PCM POWER RELAY PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT RUN WIRE SIG RTN TAN/LT BLU WIRE TAN/WHT WIRE THROTTLE MASS AIRFLOW POSITION (MAF) SENSOR (TPS) SENSOR TO FUEL PUMP RELAY WHT RED/ WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/WHT WIRE

A/T AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) FUSE 1 BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/ORG WIRE COMMUMINCATION CYLINDER ID DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ LT GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE DRAIN WIRE FUEL DEL COM GRY/ORG WIRE INJECTOR DRIVER MODULE (IDM) (MOUNTED ON REAR OF LEFT VALVE COVER) LINE PRESS SOL LOGIC PWR LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/YEL WIRE NEUTRAL SW SEN ORG/BLK WIRE ORG/WHT WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PRESSURE CONTROL SOLENOID PRESSURE SW 1 IN PRESSURE SW 2 IN PRESSURE SW 3 IN PRESSURE SW 4 IN PRESSURE SW 5 IN PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT REV LMP RLY CTRL RLY CTRL BAT FEED SIG RTN TCC SOL. CTRL TFT SENS TRAN RANGE SENS TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE SENSOR (TRS) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/ BLK WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE

ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) AUTOMATIC TRANSMISSION MODULE BLK/LT BLU WIRE BLK/PNK WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE OIL TEMPERATURE (EOT) SENSOR (ON TOP FRONT OF ENGINE) FEEDBACK FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 4 FUEL INJ 5 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 FUEL INJECTORS FUEL SIG GRY WIRE GRY/RED WIRE GRY/WHT WIRE INJ FEED INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT, BEHIND AIR CLEANER) LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/YEL WIRE PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIELD SHIFT SHIFT SOLENOID SOLENOID SIG RTN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/WHT WIRE

ACCL POS SENS VREF SIG RTN BPP SW AIR CHARGE TEMPERATURE (ACT) SENSOR (CENTER FRONT OF ENGINE, IN INTAKE SYSTEM) AIR INTAKE HEATER BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (ON LOWER FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CMP RTN TAKE OFF PWR IN CHARGE IND CRUISE CONTROL SYSTEM CUSTOMER ACCESS DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL PUMP RLY FUEL DELIV SIG CID SIG PWR IN PCM TO RELAY FUSE 34 FUSE 36 FUSE LINK GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES ICP SENS IPR SENS TSS SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MANIFOLD INTAKE AIR HEATER RELAY (AT TOP RIGHT SIDE OF ENGINE) MAP SENS IDM ENABLE OUT EPC SOL PICKUP PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TCC PWR VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VSS (+) OSS SENS GEN PWR SPEED CTRL SW ACT SENS VSS OUT WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) AUTOMATIC TRANSMISSION MODULE BLK/LT BLU WIRE BLK/PNK WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID ENGINE OIL TEMPERATURE (EOT) SENSOR (ON TOP FRONT OF ENGINE) FEEDBACK FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 4 FUEL INJ 5 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 FUEL INJECTORS FUEL SIG GRY WIRE GRY/RED WIRE GRY/WHT WIRE INJ FEED INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT, BEHIND AIR CLEANER) LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/YEL WIRE PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIELD SHIFT SHIFT SOLENOID SOLENOID SIG RTN TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

AIR CHARGE TEMPERATURE (ACT) SENSOR (CENTER FRONT OF ENGINE, IN INTAKE SYSTEM) BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (ON LOWER FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CMP RTN TAKE OFF PWR IN CHARGE IND CRUISE CONTROL SYSTEM CUSTOMER ACCESS DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL PUMP RLY FUEL DELIV SIG CID SIG PWR IN PCM TO RELAY FUSE 34 FUSE 36 GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES ICP SENS IPR SENS TSS SENS LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAP SENS IDM ENABLE OUT EPC SOL NOT USED PICKUP PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE STARTING/ CHARGING SYSTEM (W/ DUAL GENERATORS) TCC PWR VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE VIO/YEL WIRE VSS (+) OSS SENS GEN PWR SPEED CTRL SW ACT SENS VSS OUT WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE