Ford Excursion I (1999-2005) overdrive cancel switch Wiring diagrams

3 6 11 12 13 15 16 20 GROUND 4-WHEEL DRIVE CONTROL MODULE, PATS MODULE, EATC MODULE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CALIF CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) CHT VPWR GROUND GROUND EPC OSS MAF TP VREF SIG RTN BPP SW VPWR GROUND COAST CLUTCH COMPUTER DATA LINES SYSTEM CONTROL SOLENOIDS CYLINDER HEAD TEMPERATURE SENDER (ON RIGHT CYLINDER HEAD) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE ENGINE CONTROLS FUSE 22 FUSE 23 FUSE 34 FUSE 45 GRN WIRE GROUND TCC TSS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE MAF TFT IAT MASS AIRFLOW SENSOR (LEFT FRONT OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT 1 SHIFT 2 TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA SCP (-) SCP (+) CCS GROUND GROUND TCS THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TRANSMISSION CONVERTER CLUTCH TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

3 6 11 12 13 15 16 20 GROUND 4-WHEEL DRIVE CONTROL MODULE, PATS MODULE, EATC MODULE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CALIF CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) CHT VPWR GROUND GROUND EPC OSS MAF TP VREF SIG RTN BPP SW VPWR GROUND COAST CLUTCH COMPUTER DATA LINES SYSTEM CONTROL SOLENOIDS CYLINDER HEAD TEMPERATURE SENDER (ON RIGHT CYLINDER HEAD) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE ENGINE CONTROLS FUSE 22 FUSE 23 FUSE 34 FUSE 45 GRN WIRE GROUND TCC TSS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE MAF TFT IAT MASS AIRFLOW SENSOR (LEFT FRONT OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT 1 SHIFT 2 TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA SCP (-) SCP (+) CCS GROUND GROUND TCS THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TRANSMISSION CONVERTER CLUTCH TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

4-WHEEL DRIVE CONTROL, PATS, EATC MODULE ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) APP BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (AT FLOOR, IN LEFT FRONT FOOTWELL) BRN/ORG WIRE BRN/WHT WIRE CCS APP TCS TFT IAT CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) COAST CLUTCH COMPUTER DATA LINES SYSTEM CONTROL SOLENOIDS DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK DK DK GRN/WHT WIRE ELECTRONIC PRESSURE ENGINE CONTROLS FUSE 22 FUSE 23 FUSE 34 FUSE 36 FUSE 45 GRN WIRE GROUND TCC VBATT OSS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK PNK WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT 1 SHIFT 2 TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA SCP (-) SCP (+) TRANSMISSION CONVERTER CLUTCH TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR GROUND EPC TSS APP VREF SIG RTN BPP SW VPWR GROUND WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

168837 INSTRUMENT CLUSTER FOUR WHEEL DRIVE CONTROL MODULE 4 SPEED 5.4L/6.8L 6.0L 6.0L/7.3L 6.8L 5.4L ABS CONTROL MODULE RESTRAINTS CONTROL MODULE ACCELERATOR PEDAL POSITION SENSOR MAIN LIGHT SWITCH (W/ FOG LAMPS) AUXILIARY RELAY BOX 5 (LEFT REAR SIDE OF ENGINE COMPT) BLK) (OR YEL/ TAN/RED WIRE BLK/ YEL WIRE BLOWER MOTOR RELAY CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG (COP) 10 COIL ON PLUG (COP) 2 COIL ON PLUG (COP) 1 COIL ON PLUG (COP) 4 COIL ON PLUG (COP) 3 IGNITION TRANSFORMER CAPACITOR 1 COIL ON PLUG (COP) 5 COIL ON PLUG (COP) 6 IGNITION TRANSFORMER CAPACITOR 2 COIL ON PLUG (COP) 7 COIL ON PLUG (COP) 8 COIL ON PLUG (COP) 9 (6.8L) DK BLU/LT GRN WIRE DK GRN WIRE ELECTRONIC FAN CLUTCH (6.0L) EXCEPT 6.0L EXCEPT 6.0L 6.0L FOG LAMP RELAY FROM FUSE 115 (DIAGRAM 2 OF 4) FUEL HEATER RELAY FUEL HEATER WASTE GATE SOLENOID FUSE 103 FUSE 107 FUSE 110 FUSE 116 FUSE 25 FUSE 26 FUSE 38 FUSE 43 FUSE 44 FUSE 45 FUSE 8 GRADE/ LOAD SWITCH GRN LT RED/ WIRE GRY/YEL WIRE IGNITION SWITCH INJECTOR DRIVER MODULE (IDM) INJECTOR DRIVER MODULE (IDM) POWER RELAY LOCK LOCK OFF LT GRN RED/ WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE OFF ORG DK BLU/ WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PARKING LAMP TRAILER TOW RELAY PASSIVE ANTI-THEFT TRANSCEIVER MODULE PASSIVE ANTI-THEFT TRANSCEIVER PCM POWER RELAY RED WIRE RED YEL/ WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP TRAILER TOW RELAY REVERSING LAMPS RELAY (LATE PRODUCTION) RUN WIRE TAN/RED WIRE TO FUSE 27 (DIAGRAM 4 OF 4) TO FUSE 31 (DIAGRAM 2 OF 4) TO FUSE 48 (DIAGRAM 2 OF 4) VIO WIRE WHT WIRE WHT/YEL WIRE YEL RED/ WIRE YEL WIRE YEL/ WHT WIRE

360 76 1145 1143 570 1028 CUSTOMER ACCESS 570 322 CUSTOMER ACCESS A/C SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CCS CKP(+) CKP(-) PWR GND PWR GND DIAG GRD IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT EGR SOL CUST ACCESS FUSE FUSE 22 FUSE 23 GRN WIRE GRY WIRE GRY/RED WIRE HEGO 12 MAF TFT HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN RUN OR START IAT FUEL PUMP MON A/C PRESS SW NOT USED DATA OUTPUT IGN COIL 6 IGNITION TRANSFORMER CAPACITOR 1 IGNITION TRANSFORMER CAPACITOR 2 (ON REAR OF RIGHT CYL HEAD) KNOCK SENSOR VSS (-) LOCK OFF LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT PNK/ LT WIRE NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND CUST ACCESS PWR GND IGN COIL 3 RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL 1 SHIFT SOL 2 TRANS CTRL IND REPROG PWR TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

A/T BLK/ORG WIRE BRN/BLU WIRE BRN/GRN WIRE BRN/ORG WIRE BRN/RED WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) CNTL OUT DK GRN WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON FRONT OF ENGINE) FROM PCM POWER RELAY (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUSE 40 GLOW PLUGS GLW PLG 1 GLW PLG 2 GLW PLG 3 GLW PLG 4 GLW PLG 5 GLW PLG 6 GLW PLG 7 GLW PLG 8 GPCM GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSE LINK C (12 GA FUSE LINK D (12 GA INSTRUMENT CLUSTER SPEED CONTROL SET LAMP INSTRUMENT CLUSTER SYSTEM PARK BRAKE SWITCH (ON PARK BRAKE ASSEMBLY) LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE M/T NCA WIRE O/D OFF IND ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH POWER IN RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/WHT WIRE TCS VIO/LT BLU WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/LT GRN WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE YEL/WHT WIRE

& FUEL CHARGE HARN, NEAR BREAKOUT FOR RIGHT SIDE OF ENGINE) A/T BLK WIRE BLK/ORG WIRE BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON FRONT OF ENGINE) FROM PCM POWER RELAY (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUSE 40 FUSE LINK C (12 GA FUSE LINK D (12 GA FUSE LINK F (20 GA FUSE LINK G (20 GA- GLOW PLUG RELAY (AT TOP OF ENGINE) GLOW PLUGS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INJECTOR PRESSURE SENSOR (ON TOP CENTER OF ENGINE) INSTRUMENT CLUSTER SPEED CONTROL SET LAMP INSTRUMENT CLUSTER SYSTEM LT BLU/ORG WIRE LT GRN WIRE LT GRN/RED WIRE M/T MANIFOLD INTAKE AIR HEATER 58 AMP MANIFOLD INTAKE AIR HEATER RELAY (AT TOP RIGHT SIDE OF ENGINE) NCA WIRE O/D OFF IND ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PARK BRAKE SWITCH (ON PARK BRAKE ASSEMBLY) RED WIRE RED YEL/ WIRE RED/LT GRN WIRE RED/YEL WIRE TAN/LT BLU WIRE TAN/WHT WIRE TCS VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WHT LT GRN/ WIRE WHT/BLK WIRE WHT/LT GRN WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE