Ford Excursion I (1999-2005) org/blk Wiring diagrams

A/C DEMAND SIG BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR AIR BAG SLIDING CONTACT AMBIENT AIR TEMPERATURE SENSOR (ON LEFT FRONT OF ENGINE COMPT) AMBIENT TEMP BLEND DOOR SENSE + BLOW MOTOR RLY CONTROL BRN WIRE BRN/LT BLU WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DIESEL DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/ORG (OR GRY/RED) WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN TEMP FAN SPEED (+) SPEED (-) (+) FUSE 28 FUSE 34 GASOLINE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN IGN IN CAR TEMP SENSOR SUNLOAD SENSOR SIG BLEND DOOR MONITOR IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT SIDE OF DASH) LOGIC GND BLOWER SPEED CONTROL SIGNAL RETURN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) SIG RTN RED/LT GRN WIRE RED/WHT WIRE REMOTE SOLENOID ASSEMBLY REST REST REST SENSOR RETURN BLEND DOOR SIGNAL - SOLENOID ASSEMBLY SOLENOID ASSEMBLY SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) SIG RTN SPEED CONTROLLER STEERING WHEEL RADIO SWITCH TAN/WHT WIRE TEMP TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) UBP DIAG VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/LT GRN WIRE YEL/RED WIRE

6.0L 7.3L POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) 5.4L/6.8L 6.0L A/C CLUTCH RELAY A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) A/C PRESS SWITCH SIG 18 69 PNK/ A/C CLUTCH RELAY WIRE AUXILIARY AIR CONDITIONING CIRCUIT BLK WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN/ORG WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) DK BLU/ORG WIRE DUAL PRESSURE (6.0L) (AT FRONT OF ENGINE) EXC 6.0L (AT LEFT SIDE OF ENG COMPT) EXCEPT 6.0L FRONT BLOWER MOTOR SPEED CONTROLLER (AT RIGHT REAR SIDE OF ENGINE COMPT) FUSE 10 FUSE 107 FUSE 23 FUSE 27 GRY WIRE GRY/WHT WIRE HEATER BLOWER MOTOR (AT RIGHT REAR SIDE OF ENGINE COMPT) HOT AT ALL TIMES HOT IN LT BLU/PNK WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE OR RUN ORG/ WIRE ORG/BLK WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/YEL WIRE RUN WIRE SUNLOAD SENSOR (ON TOP CENTER OF DASH) SWITCH TAN WIRE TAN/LT GRN WIRE VACUUM PUMP MOTOR (6.0L) (IN RIGHT SIDE OF ENGINE COMPARTMENT) VIO WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

5.4L/6.8L 7.3L 6.0L 6.0L 8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) 6.0L A/C PRESS SWITCH SIG RTN 18 69 PNK/ A/C CLUTCH RELAY WIRE BLK WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COOLING FAN SPEED SIG DK BLU WIRE DUAL PRESSURE (6.0L) (AT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (6.0L) ELECTRONIC FAN CLUTCH CTRL EXC 6.0L EXCEPT 6.0L EXCEPT 6.0L 6.0L FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FRONT HEATER BLOWER MOTOR RESISTOR (AT REAR OF ENGINE COMPT) FUSE 10 FUSE 107 FUSE 23 FUSE 25 FUSE 27 FUSE 28 GRY WIRE GRY/WHT WIRE HEATER BLOWER MOTOR (AT RIGHT REAR SIDE OF ENGINE COMPT) HIGH MED LOW HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN START OR RUN ILLUMINATION LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/WHT WIRE MIX FLOOR DEFROST OFF MODE SWITCH VENT NORMAL MAX MODE SELECTOR SWITCH MIX FLOOR DEFROST NCA WIRE OFF MODE SWITCH VENT NORMAL MAX OR RUN ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) REAR AIR CONDITIONING CIRCUIT (EXCURSION) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SIG RTN SOLID STATE SWITCH TAN WIRE TAN/LT GRN WIRE TEMPERATURE BLEND DOOR ACTUATOR TEMPERATURE CONTROL POTENTIOMETER VACUUM PUMP MOTOR (DIESEL) (IN RIGHT SIDE OF ENGINE COMPT) VIO WIRE VREF WHT WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

360 76 1145 1143 570 1028 CUSTOMER ACCESS 570 322 CUSTOMER ACCESS A/C SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CCS CKP(+) CKP(-) PWR GND PWR GND DIAG GRD IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT EGR SOL CUST ACCESS FUSE FUSE 22 FUSE 23 GRN WIRE GRY WIRE GRY/RED WIRE HEGO 12 MAF TFT HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN RUN OR START IAT FUEL PUMP MON A/C PRESS SW NOT USED DATA OUTPUT IGN COIL 6 IGNITION TRANSFORMER CAPACITOR 1 IGNITION TRANSFORMER CAPACITOR 2 (ON REAR OF RIGHT CYL HEAD) KNOCK SENSOR VSS (-) LOCK OFF LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT PNK/ LT WIRE NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND CUST ACCESS PWR GND IGN COIL 3 RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL 1 SHIFT SOL 2 TRANS CTRL IND REPROG PWR TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CRANKSHAFT POSITION (CKP) SENSOR (ON LOWER FRONT CENTER OF ENGINE) CRANKSHAFT POSITION SENSOR SHIELD DIFFERENTIAL PRESSURE FEEDBACK EGR (DPFE) SENSOR (CALIFORNIA) (AT TOP OF ENGINE) DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE FEDERAL CALIFORNIA EXCEPT PICKUP PICKUP FROM PCM POWER RELAY (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUEL TANK UNIT (CALIFORNIA) (AT FUEL TANK) FUSE 40 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES LT BLU/ORG WIRE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE TAN/LT BLU WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) VIO/ORG WIRE WHT/RED WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION MODULE (ON LEFT SIDE OF TRANSMISSION) BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROL SOLENOID EVR SOLENOID VALVE (CALIFORNIA) (ON LEFT SIDE OF ENGINE) FUEL INJECTORS GRN WIRE GRY WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT M/T ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VAPOR MANAGEMENT VALVE (ON RIGHT REAR OF ENGINE COMPT) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE

A/T AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) FUSE 1 BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/ORG WIRE COMMUMINCATION CYLINDER ID DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ LT GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE DRAIN WIRE FUEL DEL COM GRY/ORG WIRE INJECTOR DRIVER MODULE (IDM) (MOUNTED ON REAR OF LEFT VALVE COVER) LINE PRESS SOL LOGIC PWR LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/YEL WIRE NEUTRAL SW SEN ORG/BLK WIRE ORG/WHT WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PRESSURE CONTROL SOLENOID PRESSURE SW 1 IN PRESSURE SW 2 IN PRESSURE SW 3 IN PRESSURE SW 4 IN PRESSURE SW 5 IN PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT REV LMP RLY CTRL RLY CTRL BAT FEED SIG RTN TCC SOL. CTRL TFT SENS TRAN RANGE SENS TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE SENSOR (TRS) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/ BLK WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE

570 322 CUSTOMER ACCESS A/C SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CCS CKP(+) CKP(-) PWR GND PWR GND CASE GND IGN COIL 1 IGN COIL 10 CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG CUSTOMER ACCESS DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT LT EGR SOL CUST ACC 1 FUSE FUSE 22 FUSE 23 GRN WIRE GRY WIRE GRY/RED WIRE HEGO 12 MAF TFT HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN RUN OR START IAT FUEL PUMP MON A/C PRESS SW FUEL INJ 10 DATA OUTPUT IGN COIL 6 IGNITION TRANSFORMER CAPACITOR 1 KNOCK SENSOR VSS (-) LOCK OFF LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE NOT USED O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH (A/T) OVERHEAD CONSOLE PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND CUST ACC 1 PWR GND IGN COIL 5 RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL 1 SHIFT SOL 2 TRANS CTRL IND EPROM PWR TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BRN/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CRANKSHAFT POSITION (CKP) SENSOR (ON LOWER FRONT CENTER OF ENGINE) CRANKSHAFT POSITION SENSOR SHIELD DK BLU WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE FEDERAL CALIFORNIA EXCEPT PICKUP PICKUP FROM PCM POWER RELAY (DIAGRAM 1 OF 4) FUEL PUMP RELAY FUEL TANK UNIT (CALIFORNIA) (AT FUEL TANK) FUSE 40 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INSTRUMENT (AT VEHICLE UNDER BODY, CHASSIS LEFT SIDE MEMBER) CLUSTER SYSTEM LT BLU/ORG WIRE NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE TAN/LT BLU WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) VIO/ORG WIRE WHT/RED WIRE YEL/BLK WIRE YEL/WHT WIRE

A/C SYSTEM A/T AUTOMATIC TRANSMISSION CONTROL MODULE (ON LEFT SIDE OF TRANSMISSION) BLK WIRE BLU WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE COAST CLUTCH SOLENOID DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE CONTROLLER FUEL INJECTORS GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE BODY ASSEMBLY) LT BLU WIRE LT BLU/ORG WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT LT LT M/T ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OUTPUT SHAFT SPEED (OSS) SENSOR (ON TOP OF TRANSMISSION EXTENSION HOUSING) PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/YEL WIRE SHIFT SOLENOID 1 SHIFT SOLENOID 2 TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TURBINE SHAFT SPEED (TSS) SENSOR (ON TOP OF TRANSMISSION, AT CONVERTER HOUSING) VAPOR MANAGEMENT VALVE (ON RIGHT REAR OF ENGINE COMPT) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE