Ford Excursion I (1999-2005) (on vehicle floor, in left front footwell) Wiring diagrams

1 2 3 4 5 6 7 8 9 10 SPEED CTRL IND A/T ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPARTMENT) VSS SIGNAL AIR BAG SLIDING CONTACT AIR CONDITIONING SYSTEM BLK WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESS IN GROUND BRAKE PRESSURE SWITCH (ON LEFT SIDE OF ENGINE COMPT) CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COAST DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE ENGINE COMPT) EXC EXCURSION EXCURSION FUSE FUSE 34 GRY/BLK WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN WIRE M/T NCA WIRE ON OFF REST ORG/ WIRE ORG/LT BLU WIRE PNK WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE REST REST REST RESUME SET/ ACCEL SPEED CONTROL INDICATOR SPEED CONTROL SERVO (IN RIGHT SIDE OF STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/LT BLU WIRE VSS INPUT BRAKE/CLUTCH SW IN SPEED CTRL SW IN SPEED CTRL SW RTN POWER W/ STEERING WHEEL CONTROLS

ABS CONTROL MODULE (AT LEFT SIDE OF ENG COMPT) AIR BAG SLIDING CONTACT BLK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (ON LEFT SIDE OF ENGINE COMPARTMENT) CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) FUSE 22 FUSE 34 FUSE 45 GRY/BLK WIRE HORN HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE M/T NCA WIRE ON OFF ORG/LT BLU WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) RED WIRE RED/LT GRN WIRE RED/YEL WIRE REST REST REST RESUME SET/ ACCELERATE COAST SPEED CONTROL INDICATOR STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/LT BLU WIRE VSS INPUT VSS SIGNAL

1 2 3 4 5 6 7 8 9 10 SPEED CTRL IND A/T ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPARTMENT) VSS SIGNAL AIR BAG SLIDING CONTACT AIR CONDITIONING SYSTEM BLK WIRE BLK/YEL WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESS IN GROUND BRAKE PRESSURE SWITCH (ON LEFT SIDE OF ENGINE COMPT) CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COAST DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE ENGINE COMPT) EXC EXCURSION EXCURSION FUSE FUSE 34 GRY/BLK WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT GRN WIRE M/T NCA WIRE ON OFF REST ORG/ WIRE ORG/LT BLU WIRE PNK WIRE PNK/ORG WIRE RED WIRE RED/LT GRN WIRE REST REST REST RESUME SET/ ACCEL SPEED CONTROL INDICATOR SPEED CONTROL SERVO (IN RIGHT SIDE OF STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/LT BLU WIRE VSS INPUT BRAKE/CLUTCH SW IN SPEED CTRL SW IN SPEED CTRL SW RTN POWER W/ STEERING WHEEL CONTROLS

A/T EXC EXCURSION ABS CONTROL MODULE (AT LEFT SIDE OF ENG COMPT) AIR BAG SLIDING CONTACT BLK WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH (ON LEFT SIDE OF ENGINE COMPARTMENT) CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DECEL- ERATE DK BLU WIRE FUSE 22 FUSE 34 FUSE 45 GRY/BLK WIRE GRY/RED WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE M/T EXC EXCURSION NCA WIRE OFF ORG/LT BLU WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) RED WIRE RED/LT GRN WIRE RED/YEL WIRE RESUME SET- SPEED CONTROL INDICATOR STEERING WHEEL/ SPEED CONTROL SWITCH TAN WIRE TAN/LT BLU WIRE VSS INPUT VSS SIGNAL

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 ISO VPWR 6.0L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) BLK WIRE BLU WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM DK GRN WIRE DK GRN/YEL WIRE FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 25 FUSE 34 FUSE 602 GROUND VBATT GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN INDICATOR SWITCH (NEAR DIGITAL TRANSMISSION RANGE SENSOR) INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (AT LEFT FRONT WHEEL) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE ORG/YEL WIRE PNK/ORG WIRE REAR AXLE SPEED SENSOR (ON DIFFERENTIAL) RED/LT GRN WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (AT RIGHT FRONT WHEEL) TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED (OR YEL/BLK) WIRE TAN/RED WIRE VBATT WITH ELECTRONIC SHIFT ON THE FLY WITH MECHANICAL SHIFT ON THE FLY YEL/BLK WIRE YEL/RED WIRE

A/C DEMAND SIG BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR AIR BAG SLIDING CONTACT AMBIENT AIR TEMPERATURE SENSOR (ON LEFT FRONT OF ENGINE COMPT) AMBIENT TEMP BLEND DOOR SENSE + BLOW MOTOR RLY CONTROL BRN WIRE BRN/LT BLU WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DIESEL DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/ORG (OR GRY/RED) WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN TEMP FAN SPEED (+) SPEED (-) (+) FUSE 28 FUSE 34 GASOLINE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN IGN IN CAR TEMP SENSOR SUNLOAD SENSOR SIG BLEND DOOR MONITOR IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT SIDE OF DASH) LOGIC GND BLOWER SPEED CONTROL SIGNAL RETURN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) SIG RTN RED/LT GRN WIRE RED/WHT WIRE REMOTE SOLENOID ASSEMBLY REST REST REST SENSOR RETURN BLEND DOOR SIGNAL - SOLENOID ASSEMBLY SOLENOID ASSEMBLY SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) SIG RTN SPEED CONTROLLER STEERING WHEEL RADIO SWITCH TAN/WHT WIRE TEMP TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) UBP DIAG VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/LT GRN WIRE YEL/RED WIRE

6.0L 7.3L POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) 5.4L/6.8L 6.0L A/C CLUTCH RELAY A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) A/C PRESS SWITCH SIG 18 69 PNK/ A/C CLUTCH RELAY WIRE AUXILIARY AIR CONDITIONING CIRCUIT BLK WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN/ORG WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) DK BLU/ORG WIRE DUAL PRESSURE (6.0L) (AT FRONT OF ENGINE) EXC 6.0L (AT LEFT SIDE OF ENG COMPT) EXCEPT 6.0L FRONT BLOWER MOTOR SPEED CONTROLLER (AT RIGHT REAR SIDE OF ENGINE COMPT) FUSE 10 FUSE 107 FUSE 23 FUSE 27 GRY WIRE GRY/WHT WIRE HEATER BLOWER MOTOR (AT RIGHT REAR SIDE OF ENGINE COMPT) HOT AT ALL TIMES HOT IN LT BLU/PNK WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE OR RUN ORG/ WIRE ORG/BLK WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/YEL WIRE RUN WIRE SUNLOAD SENSOR (ON TOP CENTER OF DASH) SWITCH TAN WIRE TAN/LT GRN WIRE VACUUM PUMP MOTOR (6.0L) (IN RIGHT SIDE OF ENGINE COMPARTMENT) VIO WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TX SIG IND 5 SPEED A/T ANTI- THEFT IND BLK WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) FUSE 34 FUSE 44 GND VBATT GRY/ORG WIRE HOT AT ALL TIMES HOT IN START OR RUN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE NCA WIRE ORG/RED WIRE PASSIVE ANTI-THEFT TRANSCEIVER (BEHIND LEFT SIDE OF DASH, NEAR STEERING COLUMN) PASSIVE ANTI-THEFT TRANSCEIVER MODULE (BEHIND LEFT CENTER OF DASH) PNK/LT BLU WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (ON LEFT SIDE OF FIREWALL) RED/YEL WIRE RX SIG SCP - SCP + SCP+ STARTER RELAY TAN/ORG WIRE TAN/WHT WIRE TX SIG VBATT VBATT RX SIG WHT/LT GRN WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 1 14 DOOR LOCK OUT DOOR UNLOCK DOOR LOCK 1/2 3/4 5/6 7/8 9/0 AIR CONDITIONING SYSTEM BLK BLK WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/LT GRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DOOR AJAR SW DOOR AJAR SW DOOR AJAR SW DOOR AJAR SW LIFTGATE AJAR DR DOOR RELAY DOOR UNLOCK DRIVER SIDE DOOR LOCK SWITCH DRIVER SIDE FRONT DOOR AJAR SWITCH DRIVER SIDE REAR DOOR AJAR SWITCH FUSE 102 FUSE 17 FUSE 19 FUSE 7 GROUND GRY/RED WIRE HEADLIGHTS SYSTEM HORNS SYSTEM HEADLIGHTS SYSTEM HOT AT ALL TIMES KEY PAD 1/2 KEY PAD 3/4 KEY PAD COM DIAGNOSTIC KEY PAD ILLUM KEY PAD 7/8 KEY PAD SWITCH ASSEMBLY LEFT FRONT DOOR LOCK ACTUATOR LEFT LIFTGATE AJAR SWITCH LEFT REAR DOOR LOCK ACTUATOR RIGHT REAR DOOR LOCK ACTUATOR LIFTGATE LOCK ACTUATOR PASSENGER SIDE DOOR LOCK ACTUATOR LOCK LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/YEL WIRE ORG/ WIRE PASSENGER SIDE DOOR LOCK SWITCH PASSENGER SIDE FRONT DOOR AJAR SWITCH PASSENGER SIDE REAR DOOR AJAR SWITCH PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/ORG WIRE RED/YEL WIRE RIGHT LIFTGATE AJAR SWITCH SUNLOAD SENSOR (ON TOP CENTER OF DASH) TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE UNLOCK VBATT VEHICLE SECURITY MODULE (VSM) (BEHIND LEFT SIDE OF DASH) VIO WIRE WHT WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

6 14 2 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) A/C SYSTEM A/T AUXILIARY POWERTRAIN CONTROL MODULE (APCM) (BEHIND LEFT SIDE OF DASH) AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUST ACC TP SIG A/C CLUTCH INPUT SPEED CTRL IND CHASSIS GND DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUSE 103 FUSE 20 FUSE 34 FUSE 22 FUSE 24 GRADE/LOAD SWITCH (A/T) GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T M/T A/T MASS AIRFLOW (MAF) SENSOR NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE OVERHEAD CONSOLE STARTING/CHARGING SYSTEM PARK BRAKE SWITCH ABS CONTROL (ON PARK MODULE BRAKE ASSEMBLY) PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PWR GND PTO CTRL RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE STARTING/ CHARGING SYSTEM CRUISE CONTROL SYSTEM TACH OUTPUT A/C CLUTCH RLY DATA OUTPUT LINK START RLY CTRL FUEL PMP RLY TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT (OR TAN/LT BLU) WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) VIO WIRE WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WHT RED/ WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE