Ford Excursion I (1999-2005) lt grn/vio Wiring diagrams

A/C DEMAND SIG BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR AIR BAG SLIDING CONTACT AMBIENT AIR TEMPERATURE SENSOR (ON LEFT FRONT OF ENGINE COMPT) AMBIENT TEMP BLEND DOOR SENSE + BLOW MOTOR RLY CONTROL BRN WIRE BRN/LT BLU WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DIESEL DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/ORG (OR GRY/RED) WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN TEMP FAN SPEED (+) SPEED (-) (+) FUSE 28 FUSE 34 GASOLINE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN IGN IN CAR TEMP SENSOR SUNLOAD SENSOR SIG BLEND DOOR MONITOR IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT SIDE OF DASH) LOGIC GND BLOWER SPEED CONTROL SIGNAL RETURN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) SIG RTN RED/LT GRN WIRE RED/WHT WIRE REMOTE SOLENOID ASSEMBLY REST REST REST SENSOR RETURN BLEND DOOR SIGNAL - SOLENOID ASSEMBLY SOLENOID ASSEMBLY SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) SIG RTN SPEED CONTROLLER STEERING WHEEL RADIO SWITCH TAN/WHT WIRE TEMP TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) UBP DIAG VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILL GROUND POWER ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK GRN/ORG WIRE EARLY PRODUCTION FUSE 11 FUSE 32 FUSE 42 HOT AT ALL TIMES HOT IN HOT WITH ACC DELAY RELAY ENERGIZED LATE PRODUCTION LEFT FRONT SPEAKER LEFT MIDDLE SPEAKER LEFT REAR SPEAKER LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE ORG/LT GRN WIRE PNK WIRE RADIO RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT MIDDLE SPEAKER RIGHT REAR SPEAKER TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE WHT/LT GRN WIRE

A/C CLUTCH RELAY A/C CLUTCH RELAY ABS CONTROL MODULE ACCESSORY DELAY RELAY ADJUSTABLE PEDAL SWITCH AUXILIARY A/C RELAY AUXILIARY RELAY BOX 1 (BEHIND GLOVE BOX) AUXILIARY RELAY BOX 3 (LEFT REAR SIDE OF ENGINE COMPT) AUXILIARY RELAY BOX 4 AUXILIARY RELAY BOX 5 (LEFT REAR SIDE OF ENGINE COMPT) AUXILIARY RELAY BOX 5 (LEFT REAR SIDE OF ENGINE COMPT) BATTERY BATTERY II (6.0L/7.3L) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLU/ BLK WIRE BRAKE PEDAL POSITION SWITCH BRAKE PRESSURE SWITCH (5.4L/6.8L) BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) CONSOLE POWER POINT DATA LINK CONNECTOR (DLC) DAYTIME RUNNING LAMPS RESISTOR DK BLU/ORG WIRE DK GRN/ ORG WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DRIVER SEAT MODULE DRIVER SIDE FRONT SEAT ADJUST SWITCH DVD PLAYER REAR INTEGRATED CONTROL PANEL POWER CHOKE 2 ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE EXCEPT 6.0L 6.0L EXTERIOR REAR VIEW MIRROR SWITCH FOUR WHEEL DRIVE CONTROL MODULE FROM FUSE 10 (DIAGRAM 1 OF 4) FROM FUSE 16 (DIAGRAM 1 OF 4) FRONT CIGAR LIGHTER FUSE 1 FUSE 10 FUSE 108 FUSE 11 FUSE 111 FUSE 114 FUSE 12 FUSE 13 FUSE 14 FUSE 15 FUSE 16 FUSE 17 FUSE 18 FUSE 19 FUSE 2 FUSE 3 FUSE 20 FUSE 21 FUSE 34 FUSE 4 FUSE 5 FUSE 6 FUSE 602 FUSE 7 FUSIBLE LINK A FUSIBLE LINK B INDICATOR FLASHER RELAY INJECTOR DRIVER MODULE (IDM) POWER RELAY INSTRU- MENT PANEL POWER POINT JUNCTION BLOCK LEFT "C" PILLAR) LEFT TURN TRAILER TOW RELAY LT BLU/ WHT WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN/RED WIRE LT GRN/VIO WIRE MAIN LIGHT SWITCH MULTIFUNCTION SWITCH NCA WIRE ORG DK GRN/ WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/YEL WIRE PASSENGER SIDE FRONT SEAT ADJUST SWITCH PASSIVE ANTI-THEFT TRANSCEIVER MODULE PNK/WHT WIRE POINT RADIO REAR POWER POINT REAR WIPER MOTOR ASSEMBLY RED WIRE RED/ LT GRN WIRE RED/LT BLU WIRE RIGHT TURN TRAILER TOW RELAY TAN/WHT WIRE TAN/YEL WIRE TO FUSE 12 (DIAGRAM 1 OF 4) TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VEHICLE SECURITY MODULE (VSM) VIO/ WHT WIRE VIO/WHT WIRE W/O VIDEO CASSETTE PLAYER VIDEO CASSETTE PLAYER WHT LT BLU/ WIRE WHT/ VIO WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE ``C" PILLAR POWER

168837 INSTRUMENT CLUSTER FOUR WHEEL DRIVE CONTROL MODULE 4 SPEED 5.4L/6.8L 6.0L 6.0L/7.3L 6.8L 5.4L ABS CONTROL MODULE RESTRAINTS CONTROL MODULE ACCELERATOR PEDAL POSITION SENSOR MAIN LIGHT SWITCH (W/ FOG LAMPS) AUXILIARY RELAY BOX 5 (LEFT REAR SIDE OF ENGINE COMPT) BLK) (OR YEL/ TAN/RED WIRE BLK/ YEL WIRE BLOWER MOTOR RELAY CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG (COP) 10 COIL ON PLUG (COP) 2 COIL ON PLUG (COP) 1 COIL ON PLUG (COP) 4 COIL ON PLUG (COP) 3 IGNITION TRANSFORMER CAPACITOR 1 COIL ON PLUG (COP) 5 COIL ON PLUG (COP) 6 IGNITION TRANSFORMER CAPACITOR 2 COIL ON PLUG (COP) 7 COIL ON PLUG (COP) 8 COIL ON PLUG (COP) 9 (6.8L) DK BLU/LT GRN WIRE DK GRN WIRE ELECTRONIC FAN CLUTCH (6.0L) EXCEPT 6.0L EXCEPT 6.0L 6.0L FOG LAMP RELAY FROM FUSE 115 (DIAGRAM 2 OF 4) FUEL HEATER RELAY FUEL HEATER WASTE GATE SOLENOID FUSE 103 FUSE 107 FUSE 110 FUSE 116 FUSE 25 FUSE 26 FUSE 38 FUSE 43 FUSE 44 FUSE 45 FUSE 8 GRADE/ LOAD SWITCH GRN LT RED/ WIRE GRY/YEL WIRE IGNITION SWITCH INJECTOR DRIVER MODULE (IDM) INJECTOR DRIVER MODULE (IDM) POWER RELAY LOCK LOCK OFF LT GRN RED/ WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE OFF ORG DK BLU/ WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PARKING LAMP TRAILER TOW RELAY PASSIVE ANTI-THEFT TRANSCEIVER MODULE PASSIVE ANTI-THEFT TRANSCEIVER PCM POWER RELAY RED WIRE RED YEL/ WIRE RED/BLK WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP TRAILER TOW RELAY REVERSING LAMPS RELAY (LATE PRODUCTION) RUN WIRE TAN/RED WIRE TO FUSE 27 (DIAGRAM 4 OF 4) TO FUSE 31 (DIAGRAM 2 OF 4) TO FUSE 48 (DIAGRAM 2 OF 4) VIO WIRE WHT WIRE WHT/YEL WIRE YEL RED/ WIRE YEL WIRE YEL/ WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND IGNITION 1 2 3 4 5 6 7 8 9 10 11 12 RICP FEED ASYSON 6.8L 5.4L 6.8L, 5.4L ENGINE CONTROLS SYSTEM 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE AIR BAG SLIDING CONTACT ANTENNA ASYS ON ASYS ON PROTOCOL A PROTOCOL B AUDIO CONTRL BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CD LEFT + CD RIGHT + PROTOCOL A PROTOCOL B CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COMPARTMENT) DK GRN/ORG WIRE DRAIN WIRE AUDIO RT + AUDIO RT - AUDIO LF + AUDIO LF - DVD PLAYER FUSE 11 FUSE 16 FUSE 32 FUSE 42 GROUND ACP A ACP B GROUND CD LEFT - CD RIGHT - GROUND ILLUMINATION GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT WITH ACC DELAY RELAY ENERGIZED INSTRUMENT CLUSTER, WIPER/WASHER, TRANSMISSIONS ENGINE CONTROLS SYSTEMS LEFT FRONT SPEAKER LEFT MIDDLE SPEAKER LEFT REAR SPEAKER LR SIG + LR SIG - LR AMP + LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT MIDDLE SPEAKER RIGHT REAR SPEAKER RR AMP + RR SIG - RR SIG + 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SHIELD SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STEERING WHEEL RADIO SWITCH TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VSS WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND IGNITION 5.4L/6.8L 6.8L 5.4L 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPARTMENT) AIR BAG SLIDING CONTACT ANTENNA ASYS ON ASYS ON AUD NTWRK AUD NTWRK BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK GRN/ORG WIRE ENGINE CONTROLS SYSTEM FUSE 11 FUSE 16 FUSE 32 FUSE 42 GROUND ACP A ACP B GROUND ILLUMINATION GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT WITH ACC DELAY RELAY ENERGIZED INSTRUMENT CLUSTER, WIPER/WASHER, TRANSMISSIONS ENGINE CONTROLS SYSTEMS LEFT MIDDLE SPEAKER LEFT REAR SPEAKER LR SIG + LR SIG - LR AMP + LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (ON LEFT SIDE OF FIREWALL) RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER LEFT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT MIDDLE SPEAKER RR AMP + RR SIG - RR SIG + 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STEERING WHEEL RADIO SWITCH STR CONTROL TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VSS WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND IGNITION 5.4L, 6.8L 6.8L 5.4L 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ACC DELAY AIR BAG SLIDING CONTACT ANTENNA AUD POS RT AUD SIG LF + AUD SIG RT - AUD SW ILL AUDIO CONTRL BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRAIN WIRE ENGINE CONTROLS SYSTEM FUSE 11 FUSE 32 FUSE 42 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT WITH ACC DELAY RELAY ENERGIZED INSTRUMENT CLUSTER, WIPER/WASHER, TRANSMISSIONS ENGINE CONTROLS SYSTEMS INTERIOR LIGHTS SYSTEM PNK WIRE LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWER CHOKE 1 POWERTRAIN CONTROL MODULE RADIO RED WIRE RED/ GRY WIRE RED/BLK WIRE RED/WHT WIRE RSEM L R SPKR RSEM SHIELD SHIELD RSEM RSEM RSEM RSEM SHIELD SHIELD SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STEERING WHEEL RADIO SWITCH TAN WIRE TAN/YEL WIRE VCP IR DATA + VCP VIDEO - VIDEO CASSETTE PLAYER VIDEO DISPLAY VIO WIRE VSS WHT LT GRN/ WIRE WHT WIRE WHT/LT GRN WIRE YEL WIRE