Ford Excursion I (1999-2005) lt blu/red Wiring diagrams

A/C DEMAND SIG BLEND DOOR ACTUATOR BLEND DOOR ACTUATOR AIR BAG SLIDING CONTACT AMBIENT AIR TEMPERATURE SENSOR (ON LEFT FRONT OF ENGINE COMPT) AMBIENT TEMP BLEND DOOR SENSE + BLOW MOTOR RLY CONTROL BRN WIRE BRN/LT BLU WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DIESEL DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/ORG (OR GRY/RED) WIRE DK GRN/ORG WIRE ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) FAN TEMP FAN SPEED (+) SPEED (-) (+) FUSE 28 FUSE 34 GASOLINE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN IGN IN CAR TEMP SENSOR SUNLOAD SENSOR SIG BLEND DOOR MONITOR IN-VEHICLE TEMPERATURE SENSOR (BEHIND LEFT SIDE OF DASH) LOGIC GND BLOWER SPEED CONTROL SIGNAL RETURN LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) SIG RTN RED/LT GRN WIRE RED/WHT WIRE REMOTE SOLENOID ASSEMBLY REST REST REST SENSOR RETURN BLEND DOOR SIGNAL - SOLENOID ASSEMBLY SOLENOID ASSEMBLY SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) SIG RTN SPEED CONTROLLER STEERING WHEEL RADIO SWITCH TAN/WHT WIRE TEMP TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH) UBP DIAG VIO WIRE WHT WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL/LT GRN WIRE YEL/RED WIRE

3 3 759 760 679 975 210 85 688 1332 158 1083 162 904 WARNING SYSTEM 4 DK 54 53 1269 2 12 45 39 INTERIOR LIGHTS SYSTEM 6.0L EXCEPT 6.0L AIR FILTER SENSOR (DIESEL) (ON LEFT SIDE OF ENGINE COMPARTMENT) ANTI-LOCK BRAKE SYSTEM ANTI-THEFT SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/YEL WIRE BLU WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE FLUID RESERVOIR) BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM COOLANT TEMPERATURE SENSOR 2 (DIESEL) (AT TOP OF ENGINE, ON WATER PUMP) DEFOGGER SYSTEM DIESEL DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EXCURSION EXCURSION PICKUP W/O REMOTE KEYLESS ENTRY FUEL TANK SELECTOR SWITCH FUEL TANK SELECTOR VALVE FUEL TANK UNIT EXCEPT CALIFORNIA FUSE 33 FUSE 35 FUSE 41 FUSE 45 GASOLINE GRN WIRE GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN ILLUMINATION (6 BULBS) INSTRUMENT CLUSTER INTERIOR LAMPS RELAY LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED (OR RED/WHT) WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH MICROPROCESSOR NCA WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/RED WIRE OVERHEAD CONSOLE PICKUP PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PRIMARY FUEL SENDER (ON FUEL TANK) RED WIRE RED/WHT WIRE RED/YEL WIRE SECONDARY FUEL SENDER (ON FUEL TANK) SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM INTERIOR LIGHTS SYSTEM TAN WIRE TAN/LT GRN WIRE TAN/ORG WIRE TRANSMISSIONS SYSTEM TRIP COMPUTER MODULE (ON FRONT CENTER OF ROOF) W/ AUXILIARY FUEL TANK W/ ROOF OPENING PANEL W/O AUXILIARY FUEL TANK W/O ROOF OPENING PANEL WARNING SYSTEM WARNING SYSTEM DEFOGGER SYSTEM INTERIOR LIGHTS, POWER WINDOWS SYSTEM WHT WIRE WHT/LT BLU WIRE WHT/RED (OR BRN/ORG) WIRE WHT/RED WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

ACCESSORY DELAY RELAY ADJUSTABLE PEDAL SWITCH AIR BAG SLIDING CONTACT AUTO OFF BLK LT BLU/ WIRE BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CIRCUIT BREAKER 601 DK GRN WIRE DRIVER SIDE DOOR LOCK SWITCH DVD PLAYER EATC ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE (BEHIND CENTER OF DASH) FOUR WHEEL DRIVE SWITCH FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 17 FUSE 42 HEAD AUTO PARK OFF HEAD PARK HOT AT ALL TIMES INSTRUMENT CLUSTER LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE MAIN LIGHT SWITCH MANUAL A/C MICROPROCESSOR NCA WIRE ORG/ WIRE PARKING AID DISABLE SWITCH PASSENGER SIDE DOOR LOCK SWITCH PNK WIRE RADIO REAR AUXILIARY FUNCTION SELECTOR SWITCH ASSEMBLY REAR INTEGRATED CONTROL PANEL REAR SEAT ENTERTAINMENT MODULE (IN CENTER CONSOLE) REAR WINDOW DEFROST SWITCH RED WIRE SPEED CONTROL SERVO STEERING WHEEL RADIO SWITCH STEERING WHEEL/SPEED CONTROL SWITCH TAN/WHT WIRE TO MASTER WINDOW ADJUST SWITCH (DIAGRAM 2 OF 2) VIDEO DISPLAY (W/ VIDEO CASSETTE PLAYER) W/ STEERING WHEEL CONTROLS W/O REAR SEAT ENTERTAINMENT SYSTEM W/ REAR SEAT ENTERTAINMENT SYSTEM

ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) AMBIENT AIR TEMPERATURE SENSOR (ON LEFT FRONT OF ENGINE COMPT) BLK WIRE BLU WIRE CALIFORNIA EXCEPT CALIFORNIA COMPUTER DATA LINES SYSTEM FUEL TANK UNIT FUSE 27 GRY/BLK WIRE HOT IN RUN CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) INSTRUMENT CLUSTER SYSTEM LT BLU WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE PNK WIRE PNK/BLK WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) TRIP COMPUTER MODULE (ON FRONT CENTER OF ROOF) WHT WIRE YEL WIRE YEL/WHT WIRE

199 352 1102 91 1100 331 (A/T) (CALIF) A/C SYSTEM A/T ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 34 FUSE 36 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEGO 12 HEATER CTRL HEGO 21 MAF SENS IN TP SENS IN HOT AT ALL TIMES IGN COIL 4 TCC SOL KAP B(+) VAPOR VALVE KNOCK SENSOR VSS (+) TSS HEGO 11 KNOCK SENSOR (ON LEFT CYL HEAD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MASS AIRFLOW (MAF) SENSOR (IN LEFT FRONT OF ENGINE COMPT) NCA WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 NOT USED PWR GND IGN COIL 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

6 14 2 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) A/C SYSTEM A/T AUXILIARY POWERTRAIN CONTROL MODULE (APCM) (BEHIND LEFT SIDE OF DASH) AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUST ACC TP SIG A/C CLUTCH INPUT SPEED CTRL IND CHASSIS GND DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUSE 103 FUSE 20 FUSE 34 FUSE 22 FUSE 24 GRADE/LOAD SWITCH (A/T) GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T M/T A/T MASS AIRFLOW (MAF) SENSOR NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE OVERHEAD CONSOLE STARTING/CHARGING SYSTEM PARK BRAKE SWITCH ABS CONTROL (ON PARK MODULE BRAKE ASSEMBLY) PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PWR GND PTO CTRL RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE STARTING/ CHARGING SYSTEM CRUISE CONTROL SYSTEM TACH OUTPUT A/C CLUTCH RLY DATA OUTPUT LINK START RLY CTRL FUEL PMP RLY TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT (OR TAN/LT BLU) WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) VIO WIRE WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WHT RED/ WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) BAROMETRIC ABSOLUTE PRESSURE (BAP) SENSOR (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/ORG WIRE BLK/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE FROM PCM POWER RELAY (DIAGRAM 1 OF 4) FUEL HEATER RELAY FUEL PUMP RELAY FUSE 105 FUSE 40 GLOW PLUGS LEFT VALVE COVER ASSEMBLY GLOW PLUGS RIGHT VALVE COVER ASSEMBLY GLW PLG 1 GLW PLG 2 GLW PLG 3 GLW PLG 4 GLW PLG 5 GLW PLG 6 GLW PLG 7 GLW PLG 8 GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSE LINK FUSE LINK I (12 GA INSTRUMENT CLUSTER LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (AT RIGHT SIDE OF FIREWALL) NCA WIRE ORG/LT BLU WIRE ORG/YEL WIRE PCM PNK/BLK WIRE PNK/LT GRN WIRE POWER IN RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SPEED CTRL SET LAMP VIO/ORG WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN WIRE DK BLU WIRE DK BLU/ORG WIRE DK BLU/VIO WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/VIO WIRE FUEL INJ 1 GND FUEL INJ 1 PWR FUEL INJ 2 GND FUEL INJ 2 PWR FUEL INJ 3 GND FUEL INJ 3 PWR FUEL INJ 4 GND FUEL INJ 4 PWR FUEL INJ 5 GND FUEL INJ 5 PWR FUEL INJ 6 GND FUEL INJ 6 PWR FUEL INJ 7 GND FUEL INJ 7 PWR FUEL INJ 8 GND FUEL INJ 8 PWR FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE FUSE 36 LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE RED WIRE RED/BLK WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE TAN/LT GRN WIRE TAN/YEL WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/VIO WIRE WHT/YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE

A/T AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) FUSE 1 BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BLK/WHT WIRE BRN/ORG WIRE COMMUMINCATION CYLINDER ID DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ LT GRN WIRE DK GRN/LT GRN WIRE DK GRN/WHT WIRE DRAIN WIRE FUEL DEL COM GRY/ORG WIRE INJECTOR DRIVER MODULE (IDM) (MOUNTED ON REAR OF LEFT VALVE COVER) LINE PRESS SOL LOGIC PWR LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/YEL WIRE NEUTRAL SW SEN ORG/BLK WIRE ORG/WHT WIRE ORG/YEL WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PRESSURE CONTROL SOLENOID PRESSURE SW 1 IN PRESSURE SW 2 IN PRESSURE SW 3 IN PRESSURE SW 4 IN PRESSURE SW 5 IN PWR GND PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT REV LMP RLY CTRL RLY CTRL BAT FEED SIG RTN TCC SOL. CTRL TFT SENS TRAN RANGE SENS TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE SENSOR (TRS) VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/ BLK WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/LT GRN WIRE YEL/WHT WIRE

199 352 1102 91 1100 331 (A/T) (CALIF) A/C SYSTEM A/T ANTI-LOCK BRAKES SYSTEM BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CYL HEAD TEMP CANISTER VENT FUEL INJ 9 A/C CLTCH RLY DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 34 FUSE 36 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HEATED OXYGEN SENSOR SENSOR HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEGO 12 HEATER CTRL HEGO 21 MAF SENS IN TP SENS IN HOT AT ALL TIMES IGN COIL 7 TCC SOL KAP B(+) EVAP PURGE KNOCK SENSOR VSS (+) TSS HEGO 11 KNOCK SENSOR (ON LEFT CYL HEAD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MASS AIRFLOW (MAF) SENSOR (IN LEFT FRONT OF ENGINE COMPT) NCA WIRE NOT USED PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 IGN COIL 4 PWR GND IGN COIL 3 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE