Ford Excursion I (1999-2005) injector driver module power relay Wiring diagrams

6 14 2 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) A/C SYSTEM A/T AUXILIARY POWERTRAIN CONTROL MODULE (APCM) (BEHIND LEFT SIDE OF DASH) AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUST ACC TP SIG A/C CLUTCH INPUT SPEED CTRL IND CHASSIS GND DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUSE 103 FUSE 20 FUSE 34 FUSE 22 FUSE 24 GRADE/LOAD SWITCH (A/T) GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T M/T A/T MASS AIRFLOW (MAF) SENSOR NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE OVERHEAD CONSOLE STARTING/CHARGING SYSTEM PARK BRAKE SWITCH ABS CONTROL (ON PARK MODULE BRAKE ASSEMBLY) PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PWR GND PTO CTRL RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE STARTING/ CHARGING SYSTEM CRUISE CONTROL SYSTEM TACH OUTPUT A/C CLUTCH RLY DATA OUTPUT LINK START RLY CTRL FUEL PMP RLY TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT (OR TAN/LT BLU) WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) VIO WIRE WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WHT RED/ WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

2 10 13 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 224 306 553 307 (A/T) (M/T) A/C SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING BRN/ORG WIRE BUS (-) BUS (+) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EXCURSION FUSE 22 FUSE 23 GPCM GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT AT ALL TIMES FUSE 105 IDLE VALIDATION IGNITION SWITCH INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LOW CURRENT SENS LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE NEAR BREAK- NOT USED CCS SOL CAM POS SENS ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERHEAD CONSOLE SYSTEM PCM POWER DIODE PCM POWER RELAY PICKUP CUSTOMER ACCESS PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SPEED CTRL IND STARTING/CHARGING SYSTEM (W/ DUAL GENERATORS) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN SCAN TOOL IN TCS (A/T) CPP (M/T) EBP SENS BRAKE PRESS SW TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TP SENS SPEED/TACH GND VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WASTEGATE CONTROL SOLENOID (AT TOP REAR OF ENGINE COMPT) WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WCS SOL DSL ELECT DRV WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

2 10 13 DATA LINK CONNECTOR (DLC) (BEHIND CENTER OF DASH) 224 306 553 307 (A/T) (M/T) A/C SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING BRN/ORG WIRE BUS (-) BUS (+) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIESEL FUEL PUMP MOTOR (BELOW VEHICLE, NEAR FUEL TANK) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EXCURSION FUSE 22 FUSE 23 GLOW PLUG MON GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT AT ALL TIMES FUSE 105 IDLE VALIDATION IGNITION SWITCH INERTIA FUEL SHUTOFF (IFS) SWITCH (BEHIND RIGHT SIDE OF DASH) INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LOW CURRENT SENS LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE NEAR BREAK- NOT USED CCS SOL CAM POS SENS ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERHEAD CONSOLE SYSTEM PCM POWER DIODE PCM POWER RELAY PICKUP 76 924 795 CUSTOMER ACCESS PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SPEED CTRL IND STARTING/CHARGING SYSTEM (W/ DUAL GENERATORS) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN SCAN TOOL IN TCS (A/T) CPP (M/T) EBP SENS BRAKE PRESS SW TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TP SENS SPEED/TACH GND VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WASTEGATE CONTROL SOLENOID (AT TOP REAR OF ENGINE COMPT) WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WCS SOL DSL ELECT DRV WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/WHT WIRE