Ford Excursion I (1999-2005) (in engine control harn, near break- Wiring diagrams

199 352 1102 91 1100 331 (A/T) (CALIF) A/C SYSTEM A/T ANTI-LOCK BRAKES SYSTEM BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR (ON FRONT OF LEFT CYL HEAD) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CYL HEAD TEMP CANISTER VENT FUEL INJ 9 A/C CLTCH RLY DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 34 FUSE 36 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN HEATED OXYGEN SENSOR SENSOR HEATED OXYGEN SENSOR HEGO 11 HEGO 21 HEGO 12 HEATER CTRL HEGO 21 MAF SENS IN TP SENS IN HOT AT ALL TIMES IGN COIL 7 TCC SOL KAP B(+) EVAP PURGE KNOCK SENSOR VSS (+) TSS HEGO 11 KNOCK SENSOR (ON LEFT CYL HEAD) LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE M/T MASS AIRFLOW (MAF) SENSOR (IN LEFT FRONT OF ENGINE COMPT) NCA WIRE NOT USED PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE SIG RETURN BPP SW TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 IGN COIL 4 PWR GND IGN COIL 3 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

2 10 13 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 224 306 553 307 (A/T) (M/T) A/C SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING BRN/ORG WIRE BUS (-) BUS (+) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EXCURSION FUSE 22 FUSE 23 GPCM GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT AT ALL TIMES FUSE 105 IDLE VALIDATION IGNITION SWITCH INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LOW CURRENT SENS LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE NEAR BREAK- NOT USED CCS SOL CAM POS SENS ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERHEAD CONSOLE SYSTEM PCM POWER DIODE PCM POWER RELAY PICKUP CUSTOMER ACCESS PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SPEED CTRL IND STARTING/CHARGING SYSTEM (W/ DUAL GENERATORS) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN SCAN TOOL IN TCS (A/T) CPP (M/T) EBP SENS BRAKE PRESS SW TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TP SENS SPEED/TACH GND VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WASTEGATE CONTROL SOLENOID (AT TOP REAR OF ENGINE COMPT) WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WCS SOL DSL ELECT DRV WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

2 10 13 DATA LINK CONNECTOR (DLC) (BEHIND CENTER OF DASH) 224 306 553 307 (A/T) (M/T) A/C SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING BRN/ORG WIRE BUS (-) BUS (+) CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DIESEL FUEL PUMP MOTOR (BELOW VEHICLE, NEAR FUEL TANK) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE EXCURSION FUSE 22 FUSE 23 GLOW PLUG MON GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT AT ALL TIMES FUSE 105 IDLE VALIDATION IGNITION SWITCH INERTIA FUEL SHUTOFF (IFS) SWITCH (BEHIND RIGHT SIDE OF DASH) INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LOW CURRENT SENS LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE NEAR BREAK- NOT USED CCS SOL CAM POS SENS ORG/BLK WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERHEAD CONSOLE SYSTEM PCM POWER DIODE PCM POWER RELAY PICKUP 76 924 795 CUSTOMER ACCESS PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SPEED CTRL IND STARTING/CHARGING SYSTEM (W/ DUAL GENERATORS) TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL GEN SCAN TOOL IN TCS (A/T) CPP (M/T) EBP SENS BRAKE PRESS SW TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TP SENS SPEED/TACH GND VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WASTEGATE CONTROL SOLENOID (AT TOP REAR OF ENGINE COMPT) WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WCS SOL DSL ELECT DRV WHT/BLK WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/BLK WIRE YEL/WHT WIRE