Ford Excursion I (1999-2005) hot in Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 NUET SENS 1 PNK/ WIRE 33 22 (PICK-UP) AUXILIARY RELAY BOX 3 (LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION SWITCH COMPUTER DATA LINES CONNECTOR DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE DTR SENSOR, PARK BRAKE RELAY, GAS: SPEED CONTROL SERVO, DSL: VACUUM PUMP MOTOR ELECTRONIC SHIFT-ON-THE-FLY (ESOF) SOLENOID (RIGHT SIDE OF ENGINE COMPT) EXCURSION: PATS MODULE, EATC MODULE FOUR WHEEL DRIVE SWITCH FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 111 FUSE 27 FUSE 31 FUSE 33 FUSE 34 FUSE 45 GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START IGN (ST) B+ IGN (ST/RUN) ILLUM INSTRUMENT CLUSTER INSTRUMENT CLUSTER, WINDSHIELD WIPER MOTOR, PICKUP: FUEL TANK SELECTOR SWITCH ISO BUS GROUND LO TO HI HI TO LO BPP SW LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE MOTOR 5 MOTOR 2 MOTOR 3 MOTOR 4 OFF ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PICKUP PNK PNK WIRE PNK WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT SHIFT SOL ESOF SOL ESOF SOL REVERSE RUN WIRE TRANSFER CASE ASSEMBLY TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VIO/YEL (OR BLK/PNK) WIRE VIO/YEL WIRE VPWR VSS IN VSS OUT WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE YEL WIRE

6.0L 7.3L POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) 5.4L/6.8L 6.0L A/C CLUTCH RELAY A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) A/C PRESS SWITCH SIG 18 69 PNK/ A/C CLUTCH RELAY WIRE AUXILIARY AIR CONDITIONING CIRCUIT BLK WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN/ORG WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) DK BLU/ORG WIRE DUAL PRESSURE (6.0L) (AT FRONT OF ENGINE) EXC 6.0L (AT LEFT SIDE OF ENG COMPT) EXCEPT 6.0L FRONT BLOWER MOTOR SPEED CONTROLLER (AT RIGHT REAR SIDE OF ENGINE COMPT) FUSE 10 FUSE 107 FUSE 23 FUSE 27 GRY WIRE GRY/WHT WIRE HEATER BLOWER MOTOR (AT RIGHT REAR SIDE OF ENGINE COMPT) HOT AT ALL TIMES HOT IN LT BLU/PNK WIRE LT GRN WIRE LT GRN/WHT WIRE NCA WIRE OR RUN ORG/ WIRE ORG/BLK WIRE PNK/ORG WIRE PNK/YEL WIRE RED WIRE RED/YEL WIRE RUN WIRE SUNLOAD SENSOR (ON TOP CENTER OF DASH) SWITCH TAN WIRE TAN/LT GRN WIRE VACUUM PUMP MOTOR (6.0L) (IN RIGHT SIDE OF ENGINE COMPARTMENT) VIO WIRE WHT WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILL GROUND POWER ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK GRN/ORG WIRE EARLY PRODUCTION FUSE 11 FUSE 32 FUSE 42 HOT AT ALL TIMES HOT IN HOT WITH ACC DELAY RELAY ENERGIZED LATE PRODUCTION LEFT FRONT SPEAKER LEFT MIDDLE SPEAKER LEFT REAR SPEAKER LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/VIO WIRE NCA WIRE ORG/LT GRN WIRE PNK WIRE RADIO RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT MIDDLE SPEAKER RIGHT REAR SPEAKER TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE WHT/LT GRN WIRE

2 2 LEFT TAIL LAMPS RIGHT TAIL LAMPS 6.0L 6.0L 1 2 AUXILIARY RELAY BOX 4 (EXCEPT 6.0L) (AT LEFT REAR SIDE OF ENGINE COMPARTMENT) AUXILIARY RELAY BOX 5 (6.0L) (AT LEFT REAR SIDE OF ENGINE COMPARTMENT) BACK-UP LAMPS CIRCUIT BATTERY CHARGE TRAILER TOW RELAY BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 6 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE EXCEPT 6.0L FUSE 115 FUSE 38 HOT AT ALL TIMES HOT IN LEFT LICENSE PLATE LAMP LEFT REAR PARK/STOP TURN LAMP LEFT TURN TRAILER TOW RELAY LT GRN WIRE LT GRN/ORG WIRE MICROPROCESSOR ORG/ WIRE ORG/LT BLU WIRE PARK LAMP RELAY PARKING LAMP TRAILER TOW RELAY REVERSING LAMP TRAILER TOW RELAY RIGHT LICENSE PLATE LAMP RIGHT REAR PARK/STOP TURN LAMP RIGHT TURN TRAILER TOW RELAY RUN WIRE TAN/WHT WIRE TRAILER TOW CONNECTOR (4 PIN) TRAILER TOW CONNECTOR (7 PIN) VEHICLE SECURITY MODULE (VSM) (BEHIND LEFT SIDE OF DASH) WHT WIRE YEL WIRE

5.4L/6.8L 7.3L 6.0L 6.0L 8 16 A/C PRESS SW IN A/C PRESS SW IN A/C CLUTCH SOLENOID A/C COMPRESSOR CLUTCH DIODE A/C HIGH PRESSURE SWITCH (IN RIGHT SIDE OF ENGINE COMPT) 6.0L A/C PRESS SWITCH SIG RTN 18 69 PNK/ A/C CLUTCH RELAY WIRE BLK WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BLOWER MOTOR SWITCH BRN WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COOLING FAN SPEED SIG DK BLU WIRE DUAL PRESSURE (6.0L) (AT FRONT OF ENGINE) ELECTRONIC FAN CLUTCH (6.0L) ELECTRONIC FAN CLUTCH CTRL EXC 6.0L EXCEPT 6.0L EXCEPT 6.0L 6.0L FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FRONT HEATER BLOWER MOTOR RESISTOR (AT REAR OF ENGINE COMPT) FUSE 10 FUSE 107 FUSE 23 FUSE 25 FUSE 27 FUSE 28 GRY WIRE GRY/WHT WIRE HEATER BLOWER MOTOR (AT RIGHT REAR SIDE OF ENGINE COMPT) HIGH MED LOW HOT AT ALL TIMES HOT IN HOT IN RUN HOT IN START OR RUN ILLUMINATION LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/WHT WIRE MIX FLOOR DEFROST OFF MODE SWITCH VENT NORMAL MAX MODE SELECTOR SWITCH MIX FLOOR DEFROST NCA WIRE OFF MODE SWITCH VENT NORMAL MAX OR RUN ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) REAR AIR CONDITIONING CIRCUIT (EXCURSION) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE SIG RTN SOLID STATE SWITCH TAN WIRE TAN/LT GRN WIRE TEMPERATURE BLEND DOOR ACTUATOR TEMPERATURE CONTROL POTENTIOMETER VACUUM PUMP MOTOR (DIESEL) (IN RIGHT SIDE OF ENGINE COMPT) VIO WIRE VREF WHT WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND IGNITION 1 2 3 4 5 6 7 8 9 10 11 12 RICP FEED ASYSON 6.8L 5.4L 6.8L, 5.4L ENGINE CONTROLS SYSTEM 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE AIR BAG SLIDING CONTACT ANTENNA ASYS ON ASYS ON PROTOCOL A PROTOCOL B AUDIO CONTRL BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CD LEFT + CD RIGHT + PROTOCOL A PROTOCOL B CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COMPARTMENT) DK GRN/ORG WIRE DRAIN WIRE AUDIO RT + AUDIO RT - AUDIO LF + AUDIO LF - DVD PLAYER FUSE 11 FUSE 16 FUSE 32 FUSE 42 GROUND ACP A ACP B GROUND CD LEFT - CD RIGHT - GROUND ILLUMINATION GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT WITH ACC DELAY RELAY ENERGIZED INSTRUMENT CLUSTER, WIPER/WASHER, TRANSMISSIONS ENGINE CONTROLS SYSTEMS LEFT FRONT SPEAKER LEFT MIDDLE SPEAKER LEFT REAR SPEAKER LR SIG + LR SIG - LR AMP + LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/VIO WIRE NCA WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER RIGHT MIDDLE SPEAKER RIGHT REAR SPEAKER RR AMP + RR SIG - RR SIG + 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SHIELD SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STEERING WHEEL RADIO SWITCH TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VSS WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND IGNITION 5.4L/6.8L 6.8L 5.4L 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPARTMENT) AIR BAG SLIDING CONTACT ANTENNA ASYS ON ASYS ON AUD NTWRK AUD NTWRK BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK GRN/ORG WIRE ENGINE CONTROLS SYSTEM FUSE 11 FUSE 16 FUSE 32 FUSE 42 GROUND ACP A ACP B GROUND ILLUMINATION GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT WITH ACC DELAY RELAY ENERGIZED INSTRUMENT CLUSTER, WIPER/WASHER, TRANSMISSIONS ENGINE CONTROLS SYSTEMS LEFT MIDDLE SPEAKER LEFT REAR SPEAKER LR SIG + LR SIG - LR AMP + LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE NCA WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (ON LEFT SIDE OF FIREWALL) RADIO REAR INTEGRATED CONTROL PANEL RED WIRE RED/BLK WIRE RIGHT FRONT SPEAKER LEFT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT MIDDLE SPEAKER RR AMP + RR SIG - RR SIG + 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STEERING WHEEL RADIO SWITCH STR CONTROL TAN WIRE TAN/LT GRN WIRE TAN/WHT WIRE TAN/YEL WIRE VIO WIRE VSS WHT WIRE WHT/LT GRN WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 ILLUM GROUND IGNITION 5.4L, 6.8L 6.8L 5.4L 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ACC DELAY AIR BAG SLIDING CONTACT ANTENNA AUD POS RT AUD SIG LF + AUD SIG RT - AUD SW ILL AUDIO CONTRL BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/ORG WIRE DRAIN WIRE ENGINE CONTROLS SYSTEM FUSE 11 FUSE 32 FUSE 42 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT WITH ACC DELAY RELAY ENERGIZED INSTRUMENT CLUSTER, WIPER/WASHER, TRANSMISSIONS ENGINE CONTROLS SYSTEMS INTERIOR LIGHTS SYSTEM PNK WIRE LT BLU WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/LT GRN WIRE ORG/RED WIRE PNK WIRE POWER CHOKE 1 POWERTRAIN CONTROL MODULE RADIO RED WIRE RED/ GRY WIRE RED/BLK WIRE RED/WHT WIRE RSEM L R SPKR RSEM SHIELD SHIELD RSEM RSEM RSEM RSEM SHIELD SHIELD SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STEERING WHEEL RADIO SWITCH TAN WIRE TAN/YEL WIRE VCP IR DATA + VCP VIDEO - VIDEO CASSETTE PLAYER VIDEO DISPLAY VIO WIRE VSS WHT LT GRN/ WIRE WHT WIRE WHT/LT GRN WIRE YEL WIRE

6 14 2 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) A/C SYSTEM A/T AUXILIARY POWERTRAIN CONTROL MODULE (APCM) (BEHIND LEFT SIDE OF DASH) AUXILIARY RELAY BOX 5 (AT LEFT REAR SIDE OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN/PNK WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION (CPP) SWITCH (M/T) (ABOVE CLUTCH PEDAL) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUST ACC TP SIG A/C CLUTCH INPUT SPEED CTRL IND CHASSIS GND DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUSE 103 FUSE 20 FUSE 34 FUSE 22 FUSE 24 GRADE/LOAD SWITCH (A/T) GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN INJECTOR DRIVER MODULE POWER RELAY LOCK OFF LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T M/T A/T MASS AIRFLOW (MAF) SENSOR NCA WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE OVERHEAD CONSOLE STARTING/CHARGING SYSTEM PARK BRAKE SWITCH ABS CONTROL (ON PARK MODULE BRAKE ASSEMBLY) PCM POWER DIODE PCM POWER RELAY PNK/BLK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FENDER, NEAR BATTERY) PWR GND PTO CTRL RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE RUN WIRE STARTING/ CHARGING SYSTEM CRUISE CONTROL SYSTEM TACH OUTPUT A/C CLUTCH RLY DATA OUTPUT LINK START RLY CTRL FUEL PMP RLY TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT (OR TAN/LT BLU) WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) VIO WIRE WATER IN FUEL SENSOR (AT TOP RIGHT SIDE OF ENGINE) WHT RED/ WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE