Ford Excursion I (1999-2005) hot in run or start Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 NUET SENS 1 PNK/ WIRE 33 22 (PICK-UP) AUXILIARY RELAY BOX 3 (LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION SWITCH COMPUTER DATA LINES CONNECTOR DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE DTR SENSOR, PARK BRAKE RELAY, GAS: SPEED CONTROL SERVO, DSL: VACUUM PUMP MOTOR ELECTRONIC SHIFT-ON-THE-FLY (ESOF) SOLENOID (RIGHT SIDE OF ENGINE COMPT) EXCURSION: PATS MODULE, EATC MODULE FOUR WHEEL DRIVE SWITCH FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 111 FUSE 27 FUSE 31 FUSE 33 FUSE 34 FUSE 45 GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START IGN (ST) B+ IGN (ST/RUN) ILLUM INSTRUMENT CLUSTER INSTRUMENT CLUSTER, WINDSHIELD WIPER MOTOR, PICKUP: FUEL TANK SELECTOR SWITCH ISO BUS GROUND LO TO HI HI TO LO BPP SW LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE MOTOR 5 MOTOR 2 MOTOR 3 MOTOR 4 OFF ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PICKUP PNK PNK WIRE PNK WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT SHIFT SOL ESOF SOL ESOF SOL REVERSE RUN WIRE TRANSFER CASE ASSEMBLY TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VIO/YEL (OR BLK/PNK) WIRE VIO/YEL WIRE VPWR VSS IN VSS OUT WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE YEL WIRE

3 6 11 12 13 15 16 20 GROUND 4-WHEEL DRIVE CONTROL MODULE, PATS MODULE, EATC MODULE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CALIF CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) CHT VPWR GROUND GROUND EPC OSS MAF TP VREF SIG RTN BPP SW VPWR GROUND COAST CLUTCH COMPUTER DATA LINES SYSTEM CONTROL SOLENOIDS CYLINDER HEAD TEMPERATURE SENDER (ON RIGHT CYLINDER HEAD) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE ENGINE CONTROLS FUSE 22 FUSE 23 FUSE 34 FUSE 45 GRN WIRE GROUND TCC TSS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE MAF TFT IAT MASS AIRFLOW SENSOR (LEFT FRONT OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT 1 SHIFT 2 TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA SCP (-) SCP (+) CCS GROUND GROUND TCS THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TRANSMISSION CONVERTER CLUTCH TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

10 11 CHASSIS GND PWR GND 6 14 DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) BLK WIRE BLK/WHT WIRE BRAKE PED POS SW BRAKE PEDAL POSITION (BPP) SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COOL TEMP SENS DK BLU/ORG WIRE EGR THRTL POS ENGINE COOLANT TEMPERATURE (ECT) SENSOR FUSE 116 FUSE 22 FUSE 34 FUSE 45 GRADE/LOAD SWITCH GRD/LOAD SW GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION SWITCH INJECTOR DRIVER MODULE, FUEL HEATER RELAY INTK AIR TEMP SENS LOCK LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE MAF SENS SIG RTN NCA WIRE OFF ORG/LT BLU WIRE PCM POWER DIODE PCM POWER RELAY PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR IN RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT RUN WIRE SIG RTN TAN/LT BLU WIRE TAN/WHT WIRE THROTTLE MASS AIRFLOW POSITION (MAF) SENSOR (TPS) SENSOR TO FUEL PUMP RELAY WHT RED/ WIRE WHT/LT GRN WIRE WHT/RED WIRE WHT/YEL WIRE YEL/WHT WIRE

3 6 11 12 13 15 16 20 GROUND 4-WHEEL DRIVE CONTROL MODULE, PATS MODULE, EATC MODULE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/ORG WIRE BRN/WHT WIRE CALIF CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) CHT VPWR GROUND GROUND EPC OSS MAF TP VREF SIG RTN BPP SW VPWR GROUND COAST CLUTCH COMPUTER DATA LINES SYSTEM CONTROL SOLENOIDS CYLINDER HEAD TEMPERATURE SENDER (ON RIGHT CYLINDER HEAD) DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN/WHT WIRE ELECTRONIC PRESSURE ENGINE CONTROLS FUSE 22 FUSE 23 FUSE 34 FUSE 45 GRN WIRE GROUND TCC TSS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE MAF TFT IAT MASS AIRFLOW SENSOR (LEFT FRONT OF ENGINE COMPT) NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT 1 SHIFT 2 TAN WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA SCP (-) SCP (+) CCS GROUND GROUND TCS THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TRANSMISSION CONVERTER CLUTCH TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE

4-WHEEL DRIVE CONTROL, PATS, EATC MODULE ACCELERATOR PEDAL POSITION SENSOR (ON ACCELERATOR PEDAL SUPPORT) APP BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE PEDAL POSITION SWITCH (AT FLOOR, IN LEFT FRONT FOOTWELL) BRN/ORG WIRE BRN/WHT WIRE CCS APP TCS TFT IAT CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) COAST CLUTCH COMPUTER DATA LINES SYSTEM CONTROL SOLENOIDS DIGITAL TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK DK DK GRN/WHT WIRE ELECTRONIC PRESSURE ENGINE CONTROLS FUSE 22 FUSE 23 FUSE 34 FUSE 36 FUSE 45 GRN WIRE GROUND TCC VBATT OSS GRY WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START INTAKE AIR TEMPERATURE SENSOR (LEFT SIDE OF ENGINE COMPT) LT BLU WIRE LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK PNK WIRE PNK/LT BLU WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT 1 SHIFT 2 TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL TCIL DATA SCP (-) SCP (+) TRANSMISSION CONVERTER CLUTCH TRANSMISSION FLUID TEMPERATURE SENSOR VIO WIRE VIO/ORG WIRE VIO/YEL WIRE VPWR GROUND EPC TSS APP VREF SIG RTN BPP SW VPWR GROUND WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

1 1 INDICATOR CTRL GROUND PRETEN RETURN 649 1080 609 609 IGNITION IGNITION PRETEN FEED PRETEN RETURN AIR BAG INDICATOR AIR BAG SLIDING CONTACT BLK WIRE BLK/ORG WIRE BLK/YEL WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DATA LINK CONNECTOR (DLC) (PARTIAL) (BEHIND LEFT SIDE OF DASH) DRIVER AIR BAG UNIT DRIVER SAFETY BELT RETRACTOR PRETENSIONER FUSE GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HOT IN ACC OR RUN HOT IN RUN HOT IN RUN OR START IGNITION IGNITION AIR BAG FEED AIR BAG RETURN ISO BUS AIR BAG FEED AIR BAG RETURN 1 1 INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT BLU/ORG WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/YEL WIRE PASSENGER AIR BAG MODULE PASSENGER SAFETY BELT RETRACTOR PRETENSIONER PNK WIRE PNK/BLK WIRE PRETEN FEED RED WIRE RESTRAINTS CONTROL MODULE (RCM) (BEHIND CENTER OF DASH) SHORTING BAR TONE DRIVER WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

"C" PILLAR) AIR BAG SLIDING CONTACT AUTO PARK BLK WIRE BLK/PNK WIRE BRN WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DRIVER SIDE FRONT DOOR AJAR SWITCH DRIVER SIDE REAR DOOR AJAR SWITCH EXCURSION FUSE 102 FUSE 19 FUSE 33 FUSE 45 FUSE 7 GRY WIRE GRY/RED WIRE HEAD OFF HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START INSTRUMENT CLUSTER KEY WARNING SWITCH LEFT LIFTGATE AJAR SWITCH LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE ORG/ WIRE PASSENGER SIDE FRONT DOOR AJAR SWITCH PASSENGER SIDE REAR DOOR AJAR SWITCH PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE (BEHIND CENTER OF DASH) RIGHT LIFTGATE AJAR SWITCH SAFETY BELT BUCKLE SWITCH (IN DRIVER'S SEAT BELT BUCKLE) TAN WIRE TAN/LT GRN WIRE VEHICLE SECURITY MODULE (BEHIND LEFT SIDE OF DASH) VIO WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

360 76 1145 1143 570 1028 CUSTOMER ACCESS 570 322 CUSTOMER ACCESS A/C SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CCS CKP(+) CKP(-) PWR GND PWR GND DIAG GRD IGN COIL 1 IGN COIL 5 CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT EGR SOL CUST ACCESS FUSE FUSE 22 FUSE 23 GRN WIRE GRY WIRE GRY/RED WIRE HEGO 12 MAF TFT HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN RUN OR START IAT FUEL PUMP MON A/C PRESS SW NOT USED DATA OUTPUT IGN COIL 6 IGNITION TRANSFORMER CAPACITOR 1 IGNITION TRANSFORMER CAPACITOR 2 (ON REAR OF RIGHT CYL HEAD) KNOCK SENSOR VSS (-) LOCK OFF LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE LT LT PNK/ LT WIRE NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE PCM POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND CUST ACCESS PWR GND IGN COIL 3 RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL 1 SHIFT SOL 2 TRANS CTRL IND REPROG PWR TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

570 322 CUSTOMER ACCESS A/C SYSTEM ANTI-THEFT SYSTEM BLK WIRE BLK/WHT WIRE BLU WIRE BRN/ORG WIRE BRN/PNK WIRE CCS CKP(+) CKP(-) PWR GND PWR GND CASE GND IGN COIL 1 IGN COIL 10 CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) COIL ON PLUG CUSTOMER ACCESS DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (DLC) (BEHIND LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE (DTR) SENSOR (ON LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/ORG WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE DK LT LT EGR SOL CUST ACC 1 FUSE FUSE 22 FUSE 23 GRN WIRE GRY WIRE GRY/RED WIRE HEGO 12 MAF TFT HOT AT ALL TIMES HOT AT ALL TIMES CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) FUSE 116 HOT IN RUN OR START IAT FUEL PUMP MON A/C PRESS SW FUEL INJ 10 DATA OUTPUT IGN COIL 6 IGNITION TRANSFORMER CAPACITOR 1 KNOCK SENSOR VSS (-) LOCK OFF LT BLU/BLK WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA WIRE NOT USED O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/LT GRN WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH (A/T) OVERHEAD CONSOLE PCM POWER DIODE PCM POWER RELAY PNK LT WIRE PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PWR GND CUST ACC 1 PWR GND IGN COIL 5 RED WIRE RED/LT GRN WIRE RED/YEL WIRE RUN WIRE SHIFT SOL 1 SHIFT SOL 2 TRANS CTRL IND EPROM PWR TAN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TCS TO DTR SENSOR (DIAGRAM 4 OF 4) TO FUEL PUMP RELAY (DIAGRAM 2 OF 4) TRANSMISSION CONTROL SWITCH VIO WIRE VIO/ORG WIRE WHT WIRE WHT/BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE