Ford Excursion I (1999-2005) hot in run or acc Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 NUET SENS 1 PNK/ WIRE 33 22 (PICK-UP) AUXILIARY RELAY BOX 3 (LEFT REAR SIDE OF ENGINE COMPARTMENT) BLK WIRE BLK/PNK WIRE BRAKE PEDAL POSITION SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (LOWER LEFT SIDE OF DASH) CLUTCH PEDAL POSITION SWITCH COMPUTER DATA LINES CONNECTOR DATA LINK CONNECTOR (BEHIND CENTER OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/LT GRN WIRE DTR SENSOR, PARK BRAKE RELAY, GAS: SPEED CONTROL SERVO, DSL: VACUUM PUMP MOTOR ELECTRONIC SHIFT-ON-THE-FLY (ESOF) SOLENOID (RIGHT SIDE OF ENGINE COMPT) EXCURSION: PATS MODULE, EATC MODULE FOUR WHEEL DRIVE SWITCH FOUR-WHEEL DRIVE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 111 FUSE 27 FUSE 31 FUSE 33 FUSE 34 FUSE 45 GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC HOT IN RUN OR START IGN (ST) B+ IGN (ST/RUN) ILLUM INSTRUMENT CLUSTER INSTRUMENT CLUSTER, WINDSHIELD WIPER MOTOR, PICKUP: FUEL TANK SELECTOR SWITCH ISO BUS GROUND LO TO HI HI TO LO BPP SW LT BLU WIRE LT BLU/BLK WIRE LT BLU/PNK WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE MOTOR 5 MOTOR 2 MOTOR 3 MOTOR 4 OFF ORG/ WIRE ORG/LT BLU WIRE ORG/WHT WIRE PICKUP PNK PNK WIRE PNK WIRE RED WIRE RED/LT GRN WIRE RED/WHT WIRE RED/YEL WIRE REF VOLT SHIFT SOL ESOF SOL ESOF SOL REVERSE RUN WIRE TRANSFER CASE ASSEMBLY TRANSFER CASE HIGH TO LOW RELAY TRANSFER CASE LOW TO HIGH RELAY VIO/YEL (OR BLK/PNK) WIRE VIO/YEL WIRE VPWR VSS IN VSS OUT WHT WIRE WHT/LT BLU WIRE WHT/PNK WIRE YEL WIRE

3 PNK WIRE ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE FUSE 106 FUSE 33 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR ACC INTERVAL SWITCH LT GRN WIRE MULTI- FUNCTION SWITCH ORG/ WIRE PNK WIRE REAR WIPER MOTOR ASSEMBLY RED WIRE REST RUN WIRE SOLID STATE VIO WIRE WASHER PUMP RELAY WASHER SWITCH WHT WIRE WINDSHIELD WASHER PUMP MOTOR (ON RIGHT SIDE OF ENGINE COMPT) WINDSHIELD WASHER RELAY WIPER HIGH/LOW RELAY WIPER RUN/PARK RELAY YEL WIRE

3 3 759 760 679 975 210 85 688 1332 158 1083 162 904 WARNING SYSTEM 4 DK 54 53 1269 2 12 45 39 INTERIOR LIGHTS SYSTEM 6.0L EXCEPT 6.0L AIR FILTER SENSOR (DIESEL) (ON LEFT SIDE OF ENGINE COMPARTMENT) ANTI-LOCK BRAKE SYSTEM ANTI-THEFT SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM BATTERY SAVER RELAY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/PNK WIRE BLK/YEL WIRE BLU WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE FLUID RESERVOIR) BRN WIRE BRN/LT BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM COOLANT TEMPERATURE SENSOR 2 (DIESEL) (AT TOP OF ENGINE, ON WATER PUMP) DEFOGGER SYSTEM DIESEL DK BLU/ORG WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ELECTRONIC SUSPENSION SYSTEM EXCURSION EXCURSION PICKUP W/O REMOTE KEYLESS ENTRY FUEL TANK SELECTOR SWITCH FUEL TANK SELECTOR VALVE FUEL TANK UNIT EXCEPT CALIFORNIA FUSE 33 FUSE 35 FUSE 41 FUSE 45 GASOLINE GRN WIRE GRY/BLK WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN START OR RUN ILLUMINATION (6 BULBS) INSTRUMENT CLUSTER INTERIOR LAMPS RELAY LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED (OR RED/WHT) WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH MICROPROCESSOR NCA WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/RED WIRE OVERHEAD CONSOLE PICKUP PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT SIDE OF FIREWALL) PRIMARY FUEL SENDER (ON FUEL TANK) RED WIRE RED/WHT WIRE RED/YEL WIRE SECONDARY FUEL SENDER (ON FUEL TANK) SPEED CONTROL SERVO (IN RIGHT SIDE OF ENGINE COMPT) STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM INTERIOR LIGHTS SYSTEM TAN WIRE TAN/LT GRN WIRE TAN/ORG WIRE TRANSMISSIONS SYSTEM TRIP COMPUTER MODULE (ON FRONT CENTER OF ROOF) W/ AUXILIARY FUEL TANK W/ ROOF OPENING PANEL W/O AUXILIARY FUEL TANK W/O ROOF OPENING PANEL WARNING SYSTEM WARNING SYSTEM DEFOGGER SYSTEM INTERIOR LIGHTS, POWER WINDOWS SYSTEM WHT WIRE WHT/LT BLU WIRE WHT/RED (OR BRN/ORG) WIRE WHT/RED WIRE YEL WIRE YEL/RED WIRE YEL/WHT WIRE

BLK WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LOWER LEFT SIDE OF DASH) FUSE 21 FUSE 48 HOT AT ALL TIMES HOT IN RUN OR ACC LT GRN WIRE MULTI-FUNCTION SWITCH 1. WASH 2. OFF 3. VARIABLE INTERMITTENT 4. ON SOLID STATE VIO WIRE WASHER PUMP RELAY WHT WIRE WINDSHIELD WASHER PUMP MOTOR (ON RIGHT SIDE OF ENGINE COMPT) WINDSHIELD WASHER RELAY WINDSHIELD WIPER MOTOR ASSEMBLY WIPER RUN/PARK RELAY

"C" PILLAR) AIR BAG SLIDING CONTACT AUTO PARK BLK WIRE BLK/PNK WIRE BRN WIRE BRN/LT BLU WIRE CENTRAL JUNCTION BOX (BEHIND LOWER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DRIVER SIDE FRONT DOOR AJAR SWITCH DRIVER SIDE REAR DOOR AJAR SWITCH EXCURSION FUSE 102 FUSE 19 FUSE 33 FUSE 45 FUSE 7 GRY WIRE GRY/RED WIRE HEAD OFF HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START INSTRUMENT CLUSTER KEY WARNING SWITCH LEFT LIFTGATE AJAR SWITCH LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/YEL WIRE MAIN LIGHT SWITCH NCA WIRE ORG/ WIRE PASSENGER SIDE FRONT DOOR AJAR SWITCH PASSENGER SIDE REAR DOOR AJAR SWITCH PNK WIRE PNK/LT BLU WIRE PNK/ORG WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/YEL WIRE RESTRAINTS CONTROL MODULE (BEHIND CENTER OF DASH) RIGHT LIFTGATE AJAR SWITCH SAFETY BELT BUCKLE SWITCH (IN DRIVER'S SEAT BELT BUCKLE) TAN WIRE TAN/LT GRN WIRE VEHICLE SECURITY MODULE (BEHIND LEFT SIDE OF DASH) VIO WIRE WHT WIRE YEL WIRE YEL/BLK WIRE